Abstract
ZrO2 is widely used. However, surface hydrophilicity is harmful to waterproof devices. In this work, epoxy-based polyhedral oligomeric silsesquioxane (POSS) was chemically bonded to ZrO2 sheet surface for weather-resistant hydrophobicity and anti-adherence property. First, ZrO2 sheet was modified with hydroxyls, followed by amino modification. Then, surface POSS modification was performed via ring-opening addition. Next, composition and micro-morphology of POSS-treated sheet were clarified. Ultimately, the dependence of water contact angle of POSS-modified sheet on POSS solution treating time was researched, and the highest contact angle of 132.6° was gained by 24-h treating. Acid corrosion, alkali corrosion, and ultraviolet radiation for 48 h were employed to verify good weather resistance with contact angles over 120°. POSS-modified sheet had good anti-adherence capacity. Cooperation of POSS and ZrO2 was utilized to obtain low surface energy and high surface roughness. This work might help to obtain hydrophobic ceramics as catalyst supports for oil-phase reactions.
Similar content being viewed by others
Data availability
The datasets generated during and/or analyzed during the current study are available from the corresponding author on reasonable request.
References
Traversa, E.: Intelligent ceramic materials for chemical sensors. J Intell Mater Syst Struct. 6, 860 (1995)
Qiu, J., Tani, J., Yanada, N., Kobayashi, Y., Takahashi, H.: Fabrication of Pb (Nb, Ni) O3-Pb (Zr, Ti) O3 piezoelectric ceramic fibers by extrusion of a sol-powder mixture. J Intell Mater Syst Struct. 15, 643 (2004)
Alotaibi, A., Sathasivam, S., Parkin, I.: Aerosol assisted chemical vapour deposition of a ZrO 2–TiO 2 composite thin film with enhanced photocatalytic activity. RSC Adv. 5, 67944 (2015)
Gogotsi, G.A., Yu Ostrovoy, D.: Deformation behaviour of partially stabilized ZrO 2 crystals in the temperature range of tetragonal-to-monoclinic transformation. J Mater Sci Lett. 15, 1467 (1996)
Chen, N., Fu, W., Zhou, J., Mei, L., Yang, J., Tian, Y., Wang, Q., Yin, W.: Mn2+-doped ZrO2@ PDA nanocomposite for multimodal imaging-guided chemo-photothermal combination therapy. Chin Chem Lett. 32, 2405 (2021)
Tan, G., Wu, X.: Thin Solid Films. 330, 59 (1998)
Liu, R., Wang, Y., Li, B., Liu, B., Ma, H., Li, D., Dong, L., Li, F., Chen, X., Yin, X.: Materials. 12, 3637 (2019)
Mendret, J., Hatat-Fraile, M., Rivallin, M., Brosillon, S.: Sep Purif Technol. 118, 406 (2013)
Bai, M., Kazi, H., Zhang, X., Liu, J., Hussain, T.: Sci Rep. 8, 6973 (2018)
Tanimoto, R., Yoshikawa, K., Isobe, T., Matsushita, S., Nakajima, A.: J Ceram Soc Jpn. 125, 638 (2017)
Vargas-Garcia, A., Torrestiana-Sanchez, B., Garcia-Borquez, A., Aguilar-Uscanga, G.: Sep Purif Technol. 80, 473 (2011)
Ma, X., He, L., Huang, S., Wu, Y., Pan, A., Liang, J.: Colloid Polym Sci. 298, 1559 (2020)
Li, Z., He, Z., Chen, X., Tang, Y., You, S., Chen, Y., Jin, T.: RSC Adv. 9, 24659 (2019)
Raghu, S.N.V., Killian, M.S.: Wetting behavior of zirconia nanotubes. RSC Adv. 11, 29585 (2021)
Cassie, A.B.D., Baxter, S.: Trans Faraday Soc. 40, 546 (1944)
Gao, W., Dickinson, L., Grozinger, C., Morin, F.G., Reven, L.: Self-assembled monolayers of alkylphosphonic acids on metal oxides. Langmuir. 12, 6429 (1996)
Wang, L.N., Shen, C., Shinbine, A., Luo, J.L.: Thin Solid Films. 531, 277 (2013)
Raghu, S.N.V., Chuluunbandi, K., Killian, M.S.: Zirconia nanotube coatings-UV-resistant superhydrophobic surfaces. Surfaces and Interfaces. 26, 101357 (2021)
Wang, R., Hashimoto, K., Fujishima, A., Chikuni, M., Kojima, E., Kitamura, A., Shimohigoshi, M., Watanabe, T.: Light-induced amphiphilic surfaces. Nature. 388, 431 (1997)
Lousada, C., Johansson, A., Brinck, T., Jonsson, M.: J Phys Chem C. 116, 9533 (2012)
P. Dao, T. Nguyen, T. Phung, T. Nguyen, A. Nguyen, T. Lan Vu, Q. Vu, D. Vu, T. Tran, and H. Thai, Journal of Chemistry, 2021, 9925355 (2021).
Falk, A., Dreimann, J., Vogt, D.: ACS Sustain Chem Eng. 6, 7221 (2018)
Su, J., Yang, L., Wang, Q.: J Chromatogr A. 1533, 136 (2018)
Keine, S., Holthausen, R., Raupach, M.: J Cult Herit. 36, 128 (2019)
Biehl, M., Ahr, M., Kinzel, W., Much, F.: Thin Solid Films. 428, 52 (2003)
Chakarova, K., Hadjiivanov, K.: Microporous Mesoporous Mater. 143, 180 (2011)
Wang, S., Lao, W., He, Y., Shi, H., Ye, Q., Ma, J.: RSC Adv. 11, 35673 (2021)
Murat, E., Devrim, P.: Fabrication of micro/nano hydrophobic surfaces by a soft molding method using polyurethane-based elastomer. Journal of Elastomers & Plastics. 53, 1033 (2021)
Miwa, M., Nakajima, A., Fujishima, A., Hashimoto, K., Watanabe, T.: Effects of the surface roughness on sliding angles of water droplets on superhydrophobic surfaces. Langmuir. 16, 5754 (2000)
Chen, S., Yang, J., Li, K., Lu, B., Ren, L.: Int J Food Prop. 21, 2557 (2018)
Takahashi, A., Okada, T., Nakano, K., Ishida, Y., Kameyama, A.: Polym J. 53, 1213 (2021)
Song, X., Zhang, X., Li, T., Li, Z., Chi, H.: Polymers. 11, 373 (2019)
Lyu, Z., An, Q., Qin, P., Li, W., Wang, X.: RSC Adv. 9, 4765 (2019)
Schutzius, T., Bayer, I., Jursich, G., Das, A., Megaridis, C.: Nanoscale. 4, 5378 (2012)
Yang, Z., Liu, X., Tian, Y.: Colloids Surf A Physicochem Eng Asp. 587, 124343 (2020)
Xiang, T., Xie, Y., Wang, R., Wu, M., Sun, S., Zhao, C.: Mater Lett. 137, 192 (2014)
Ponnupandian, S., Mondal, P., Becker, T., Hoogenboom, R., Lowe, A., Singha, N.: Polym Chem. 12, 876 (2021)
Yu, M., Liu, F., Du, F.: Prog Org Coat. 94, 34 (2016)
Guo, R., Guo, X., Pei, H., Liu, W., Guo, W., Fang, M., Liu, N., Mo, Z.: Surfaces and Interfaces. 27, 101577 (2021)
Rossi, G., Altavilla, C., Scarfato, P., Ciambelli, P., Incarnato, L.: Durability study of transparent and flexible nanolayer barrier for photovoltaic devices. Polym Degrad Stab. 112, 160 (2015)
Yuan, J., Zhang, Z., Yang, M., Wang, W., Men, X., Liu, W.: POSS grafted hybrid-fabric composites with a biomimic middle layer for simultaneously improved UV resistance and tribological properties. Compos Sci Technol. 160, 69 (2018)
Wang, D., Bai, T., Cheng, W., Xu, C., Wang, G., Cheng, H., Han, G.: Surface modification of bamboo fibers to enhance the interfacial adhesion of epoxy resin-based composites prepared by resin transfer molding. Polymers. 11, 2107 (2019)
Wang, H., Yao, Y., Li, Y., Ma, S., Peng, X., Ou, J., Ye, M.: Preparation of open tubular capillary columns by in situ ring-opening polymerization and their applications in cLC-MS/MS analysis of tryptic digest. Anal Chim Acta. 979, 58 (2017)
Sherman, P., Smith, S., Johannessen, B.: Textile Characteristics Affecting the Release of Soil During Laundering: Part II: Fluorochemical Soil-Release Textile Finishes. Text Res J. 39, 449 (1969)
Han, T., Ma, Z., Wang, D.: Biofouling-inspired growth of superhydrophilic coating of polyacrylic acid on hydrophobic surfaces for excellent anti-fouling. ACS Macro Lett. 10, 354 (2021)
Funding
This work was supported by Youth Project of Science and Technology Research Program of Chongqing Education Commission of China (Grant No. KJQN202101436).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The author declares no competing interests.
Additional information
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary information
ESM 1:
Figure S1 (DOC 1314 kb)
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Zhang, J. Achieving high stability and anti-adherence performance of ZrO2 ceramic product via hydrophobic modified surface. J Aust Ceram Soc 59, 915–922 (2023). https://doi.org/10.1007/s41779-023-00884-w
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s41779-023-00884-w