Abstract
In recent years, the safe disposal of used face masks has become troublesome due to their non-biodegradable nature. This study focuses on the reuse potential of used face masks as a reinforcement to enhance the engineering properties of expansive soil treated with biopolymers such as Xanthan Gum and Guar Gum. The face masks were shredded into 5 × 5 mm chips and added to expansive soil at 0.5% by volume. A series of laboratory tests such as Unconfined Compressive Strength (UCS) Test, Splitting Tensile Test, Free swell Index (FSI) Tests, Swelling Pressure, Swelling Potential Tests, and California—Bearing Ratio (CBR) tests were performed for the evaluation of engineering behaviour of Shredded Face Mask Chips (SFMC) reinforced expansive soil treated with various dosages of Xanthan Gum and Guar Gum. The experimental test results showed that the inclusion of SFMC significantly improved the engineering characteristics of the soil. The maximum compressive strength and tensile strength have been attained at 2% inclusion of Xanthan gum and Guar gum into the expansive soil. The maximum values of compressive strength at optimum biopolymer content of 2% Xanthan gum and Guar gum were 369–437 kPa, respectively. The free swell index percentage for stabilized expansive soils with xanthan gum and guar gum decreased to 73.6–75.9%, respectively. The swell pressure of the treated soil showed up to a reduction of 90.2–94.1%. In all the tests, Guar Gum exhibited greater efficiency when compared to Xanthan Gum. Thus, the investigation results confirmed the efficient use of SFMC in biopolymer stabilization of expansive soil that would lead to the beneficial way for the safe disposal of used face masks.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data Availability
All data generated or analysed during this study are included in this published article.
References
Ahmed W, Lim CW (2022) Effective recycling of disposable medical face masks for sustainable green concrete via a new fiber hybridization technique. Constr Build Mater 344:128245
Al-Rawas AA, Hago AW, Al-Sarmi H (2005) Effect of lime, cement and Sarooj (artificial pozzolan) on the swelling potential of an expansive soil from Oman. Build Environ 40(5):681–687. https://doi.org/10.1016/j.buildenv.2004.08.028
Anandha Kumar S, Sujatha ER, Pugazhendi A, Jamal MT (2021) Guar gum-stabilized soil: A clean, sustainable and economic alternative liner material for landfills. Clean Technol Environ Policy. https://doi.org/10.1007/s10098-021-02032-z
Ayeldeen M, Negm A, El-Sawwaf M, Kitazume M (2017) Enhancing mechanical behaviors of collapsible soil using two biopolymers. J Rock Mech Geotech Eng 9(2):329–339
Bahmani SH, Huat BB, Asadi A, Farzadnia N (2014) Stabilization of residual soil using SiO2 nanoparticles and cement. Constr Build Mater 64:350–359. https://doi.org/10.1016/j.conbuildmat.2014.04.086
Bekhiti M, Trouzine H, Rabehi M (2019) Influence of waste tire rubber fibers on swelling behavior, unconfined compressive strength and ductility of cement stabilized bentonite clay soil. Constr Build Mater 208:304–313. https://doi.org/10.1016/j.conbuildmat.2019.03.011
Bhattacharja S, Bhatty J (2003) Comparative performance of portland cement and lime stabilization of moderate to high plasticity clay soils. Portl Cem Assoc 2066:60–67
Bozyigit I, Javadi A, Altun S (2021) Strength properties of xanthan gum and guar gum treated kaolin at different water contents. J Rock Mech Geotech Eng 13(5):1160–1172. https://doi.org/10.1016/j.jrmge.2021.06.007
Brahmachary TK, Rokonuzzaman M (2018) Investigation of random inclusion of bamboo fiber on ordinary soil and its effect CBR value. Int J Geo Eng 9:1–11
Buazar F (2019) Impact of biocompatible nanosilica on green stabilization of subgrade soil. Sci Rep 9(1):1–9. https://doi.org/10.1038/s41598-019-51663-2
Cabalar AF, Wiszniewski M, Skutnik Z (2017) Effects of xanthan gum biopolymer on the permeability, odometer, unconfined compressive and triaxial shear behavior of sand. Soil Mech Found Eng 54(5):356–361. https://doi.org/10.1007/s11204-017-9481-1
Chang I, Im J, Prasidhi AK, Cho GC (2015a) Effects of Xanthan gum biopolymer on soil strengthening. Constr Build Mater 74:65–72. https://doi.org/10.1016/j.conbuildmat.2014.10.026
Chang I, Jeon M, Cho GC (2015b) Application of microbial biopolymers as an alternative construction binder for earth buildings in underdeveloped countries. Int J Poly Sci. https://doi.org/10.1155/2015/326745
Chang I, Im J, Cho GC (2016) Introduction of microbial biopolymers in soil treatment for future environmentally-friendly and sustainable geotechnical engineering. Sustainability 8(3):251. https://doi.org/10.3390/su8030251
Chang I, Lee M, Tran ATP, Lee S, Kwon YM, Im J, Cho GC (2020) Review on biopolymer-based soil treatment (BPST) technology in geotechnical engineering practices. Transport Geotech. https://doi.org/10.1016/j.trgeo.2020.100385
Cheng Y, Wang S, Li J, Huang X, Li C, Wu J (2018) Engineering and mineralogical properties of stabilized expansive soil compositing lime and natural pozzolans. Constr Build Mater 187:1031–1038. https://doi.org/10.1016/j.conbuildmat.2018.08.061
Chudzikowski RJ (1971) Guar gum and its applications. J SocCosmet Chem 22(1):43
Dang LC, Fatahi B, Khabbaz H (2016) Behaviour of expansive soils stabilized with hydrated lime and bagasse fibres. Proced Eng 143:658–665. https://doi.org/10.1016/j.proeng.2016.06.093
Fatehi H, Ong DE, Yu J, Chang I (2021) Biopolymers as green binders for soil improvement in geotechnical applications: a review. Geosciences 11(7):291. https://doi.org/10.3390/geosciences11070291
Garcıa-Ochoa F, Santos VE, Casas JA, Gómez E (2000) Xanthan gum: production, recovery, and properties. Biotechnol Adv 18(7):549–579. https://doi.org/10.1016/S0734-9750(00)00050-1
Ghavami S, Naseri H, Jahanbakhsh H, Nejad FM (2021) The impacts of nano-SiO2 and silica fume on cement kiln dust treated soil as a sustainable cement-free stabilizer. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2021.122918
Hamza M, Nie Z, Aziz M, Ijaz N, Ameer M F, Ijaz Z (2022). Geotechnical properties of problematic expansive subgrade stabilized with xanthan gum biopolymer. Road Mater Pav Des https://doi.org/10.1080/14680629.2022.2092027
Hataf N, Ghadir P, Ranjbar N (2018) Investigation of soil stabilization using chitosan biopolymer. J Clean Prod 170:1493–1500. https://doi.org/10.1016/j.jclepro.2017.09.256
Huang J, Kogbara RB, Hariharan N, Masad EA, Little DN (2021) A state-of-the-art review of polymers used in soil stabilization. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2021.124685
Joga JR, Varaprasad BJS (2019) Sustainable improvement of expansive clays using xanthan gum as a biopolymer. Civ Eng 5:1893–1903
Kafodya I, Okonta F (2018) Effects of natural fiber inclusions and pre-compression on the strength properties of lime-fly ash stabilised soil. Construct Buil Mater 170:737–746. https://doi.org/10.1016/j.conbuildmat.2018.02.194
Kantesaria N, Chandra P, Sachan A (2021) Stabilization of expansive soil using Agar biopolymer. IFCEE. https://doi.org/10.1061/9780784483411.026
Kibria MG, Masuk NI, Safayet R, Nguyen HQ (2023) Mourshed M (2023) Plastic Waste: Challenges and Opportunities to Mitigate Pollution and Effective Management. Int J Environ Res 17:20. https://doi.org/10.1007/s41742-023-00507-z
Kulanthaivel P, Soundara B, Das A (2020) Performance study on stabilization of fine-grained clay soils using calcium source producing microbes. KSCE J Civ Eng 24(9):2631–2642. https://doi.org/10.1007/s12205-020-2028-4
Kulanthaivel P, Soundara B, Velmurugan S, Naveenraj V (2021) Experimental investigation on stabilization of clay soil using nano-materials and white cement. Mater Today Proceed 45:507–511. https://doi.org/10.1016/j.matpr.2020.02.107
Kulanthaivel P, Soundara B, Selvakumar S, Das A (2022b) Application of waste eggshell as a source of calcium in bacterial bio-cementation to enhance the engineering characteristics of sand. Environ Sci Pollut Res. https://doi.org/10.1007/s11356-022-20484-8
Kulanthaivel P, Soundara B, Selvakumar S, Das A (2022c) Effect of bio-cementation on the strength behaviour of clay soils using egg shell as calcium source. Environ Earth Scie 81(13):1–15. https://doi.org/10.1007/s12665-022-10475-w
Kulanthaivel P, Selvakumar S, Soundara B, Krishnaraja A R (2022) Strength Enhancement of Clay Soil Stabil1ized with Ordinary Portland Cement, Sodium Silicate and Sodium Hydroxide. Int J Pav Res Technol https://doi.org/10.1007/s42947-022-00197-4
Kulkarni PP, Mandal JN (2022) Strength evaluation of soil stabilized with nano silica-cement mixes as road construction material. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2021.125363
Kumar PG, Harika S (2021) Stabilization of expansive subgrade soil by using fly ash. Mater Today Proceed 45:6558–6562. https://doi.org/10.1016/j.matpr.2020.11.469
Kumar SA, Sujatha ER (2021) An appraisal of the hydro-mechanical behaviour of polysaccharides, xanthan gum, guar gum and β-glucan amended soil. Carbohyd Polym. https://doi.org/10.1016/j.carbpol.2021.118083
Lang L, Chen B, Duan H (2021) Modification of nanoparticles for the strength enhancing of cement-stabilized dredged sludge. J Rock Mech Geotech Eng 13(3):694–704. https://doi.org/10.1016/j.jrmge.2021.01.006
Miturski M, Głuchowski A, Sas W (2021) Influence of Dispersed Reinforcement on Mechanical Properties of Stabilized Soil. Materials 14(20):5982
Moghal AAB, Vydehi KV (2021) State-of-the-art review on efficacy of xanthan gum and guar gum inclusion on the engineering behavior of soils. Innovat Infrastruct Solut 6(2):1–14. https://doi.org/10.1007/s41062-021-00462-8
Muguda S, Booth SJ, Hughes PN, Augarde CE, Perlot C, Bruno AW, Gallipoli D (2017) Mechanical properties of biopolymer-stabilised soil-based construction materials. Géotech Lett 7(4):309–314. https://doi.org/10.1680/jgele.17.00081
Muguda S, Booth S, Hughes P N, Augarde C E, Perlot C, Bruno A W, Gallipoli D (2018) Preliminary study on use of biopolymers in earthen construction. In The 7th International conference on unsaturated SoilsAt: The Hong Kong University of Science and Technology 8:1–2
Ni J, Li SS, Ma L, Geng XY (2020) Performance of soils enhanced with eco-friendly biopolymers in unconfined compression strength tests and fatigue loading tests. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2020.120039
Rehman MA, Jafri T (2020) Stabilization of low plastic and high plastic clay using guar gum biopolymer. J Appl Res Indust Eng 7(4):329–343
Rehman ZU, Khalid U (2021) Reuse of COVID-19 face mask for the amelioration of mechanical properties of fat clay: a novel solution to an emerging waste problem. Sci Total Environ 794:148746
Saberian M, Li J, Kilmartin-Lynch S, Boroujeni M (2021) Repurposing of COVID-19 single-use face masks for pavements base/subbase. Sci Total Environ 769:145527
Said S, Rahhal ME (2022) Improving the compaction properties and shear resistance of a sand reinforced with COVID-19 waste mask fibers. Heliyon 8:e12129
Selvakumar S, Kulanthaivel P, Soundara B (2021) Influence of nano-silica and sodium silicate on the strength characteristics of clay soil. Nanotechnol Environ Eng 6(3):1–10. https://doi.org/10.1007/s41204-021-00142-z
Selvakumar S, Soundara B, Kulanthaivel P (2022) Model tests on swelling behavior of an expansive soil with recycled geofoam granules column inclusion. Arab J Geosci 15(2):1–11. https://doi.org/10.1007/s12517-022-09427-2
Seo S, Lee M, Im J, Kwon YM, Chung MK, Cho GC, Chang I (2021) Site application of biopolymer-based soil treatment (BPST) for slope surface protection: in-situ wet-spraying method and strengthening effect verification. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2021.124983
Singh HP, Bagra M (2013) Improvement in CBR value of soil reinforced with jute fiber. Int J Innovat Res Sci Eng Technol 2(8):3447–3452
Sivabalaselvamani D, Kulanthaivel P, Yogapriya J, Dhanoa IS (2022) Study on engineering properties of ceramic waste powder stabilised expansive soil using machine learning algorithms. J Ceram Process Res 23(6):902–911
Soldo A, Miletić M, Auad ML (2020) Biopolymers as a sustainable solution for the enhancement of soil mechanical properties. Sci Rep 10(1):1–13. https://doi.org/10.1038/s41598-019-57135-x
Song U, Kim J (2023) Recycling of Anti-COVID-19 Filtering Facepiece Respirators for Use as Preliminary Water Filters. Int J Environ Res 17:35. https://doi.org/10.1007/s41742-023-00526-w
Sujatha ER, Saisree S (2019) Geotechnical behaviour of guar gum-treated soil. Soils Found 59(6):2155–2166. https://doi.org/10.1016/j.sandf.2019.11.012
Taher ZJ, Scalia J IV, Bareither CA (2020) Comparative assessment of expansive soil stabilization by commercially available polymers. Transport Geotech. https://doi.org/10.1016/j.trgeo.2020.100387
Vijayan DS, Parthiban D (2020) Effect of Solid waste based stabilizing material for strengthening of Expansive soil-A review. Environ Technol Innov. https://doi.org/10.1016/j.eti.2020.101108
Xu W, Yin ZY, Wang HL, Wang X (2022) Experimental study on the monotonic mechanical behavior of completely decomposed granite soil reinforced by disposable face-mask chips. J Clean Prod. https://doi.org/10.1016/j.jclepro.2022.131528
Acknowledgements
Not applicable.
Funding
Not applicable.
Author information
Authors and Affiliations
Contributions
KP, VS, and RPR identified the problem, conducted various tests and analyses, and was involved in the preparation of the manuscript. SB and KAR guided and interpreted results and were involved in the preparation of the manuscript. SMT and VS are involved in visualization, validation, and writing. SS contributed to the final article reviewing and drafting. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Conflict of Interest
The authors have no conflicts of interest to declare that are relevant to the content of this article.
Ethical Standards
This article does not contain any studies involving animals performed by any of the authors.
This article does not contain any studies involving human participants performed by any of the authors.
Consent to Participate
Not Applicable.
Consent for Publication
Not Applicable.
Supplementary Information
Below is the link to the electronic supplementary material.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Ponnusamy, K., Ramasamy, K.A., Balu, S. et al. Sustainable Reuse of Shredded Face Mask in Biopolymer Treated Expansive Soil. Int J Environ Res 18, 15 (2024). https://doi.org/10.1007/s41742-024-00566-w
Received:
Revised:
Accepted:
Published:
DOI: https://doi.org/10.1007/s41742-024-00566-w