Abstract
In this research, the permanent deformation property of asphalt concrete containing different percentages of recycled asphalt pavement (RAP) and dosages of waste engine and cooking oil has been investigated using response surface methodology (RSM). 25, 50 and 75% of total aggregates have been replaced with RAP, and each rejuvenated with 5, 10 and 15% (by the weight of total binder) of waste engine oil (WEO) and waste cooking oil (WCO). Experiments were designed using composite central design method in RSM, and the permanent strain accumulated after applying 1000 cycles of 300 kPa vertical stress at a frequency of 1 Hz and temperature of 40 °C was measured. Using RSM in Design Expert program, a polynomial quadratic model was found to be capable for predicting the permanent strain. It was found that the significant terms for prediction of permanent strain are RAP and oil content, the squared oil content and type of oil. Results reveal that permanent strain decreases with increasing RAP content; however, for each RAP content, the lowest permanent strain is achieved at a certain level of oil content. At the same dosage of use, WEO results in lower strain than WCO. Interaction effect was found between RAP content and oil type, such that the decrease of strain with RAP content is higher with WCO than WEO. Using optimization in RSM, the content of oils to achieve a mixture with similar deformation property of control mix was obtained.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Abdullah ME, Zamhari KA, Hainin MR, Oluwasola EA, Yusoff NIM, Hassan NA (2016) High temperature characteristics of warm mix asphalt mixtures with nanoclay and chemical warm mix asphalt modified binders. J Clean Prod 122:326–334. https://doi.org/10.1016/j.jclepro.2016.02.033
Al-Qadi IL, Aurangzeb Q, Carpenter SH, Pine WJ, Trepanier J (2012) Impact of high RAP contents on structural and performance properties of asphalt mixtures. Report Number FHWA-ICT-12-002. Illinois Center for Transportation, Springfield. http://hdl.handle.net/2142/45810
Al Saffar ZH, Yaacob H, Idham MK, Saleem MK, Lai Putra Jaya R JC, Putra Jaya T (2020) A review on rejuvenating materials used with reclaimed hot mix asphalt. Can J Civ Eng. https://doi.org/10.1139/cjce-2019-0635
Asli H, Ahmadinia E, Zargar M, Karim MR (2012) Investigation on physical properties of waste cooking oil–rejuvenated bitumen binder. Constr Build Mater 37:398–405. https://doi.org/10.1016/j.conbuildmat.2012.07.042
Azahar WNAW, Jaya RP, Hainin MR, Bujang M, Ngadi N (2017) Mechanical performance of asphaltic concrete incorporating untreated and treated waste cooking oil. Constr Build Mater 150:653–663. https://doi.org/10.1016/j.conbuildmat.2017.06.048
Bailey H, Zoorob S (2012) The use of vegetable oil in asphalt mixtures, in the laboratory and field. In: 5th Euroasphlat and Eurobitume congress. http://www.h-a-d.hr/pubfile.php?id=676
Behnood A (2019) Application of rejuvenators to improve the rheological and mechanical properties of asphalt binders and mixtures: a review. J Clean Prod 231:171–182. https://doi.org/10.1016/j.jclepro.2019.05.209
Behnood A (2020) A review of the warm mix asphalt (WMA) technologies: effects on thermo-mechanical and rheological properties. J Clean Prod 259:120817. https://doi.org/10.1016/j.jclepro.2020.120817
Bennert T, Ericson C, Pezeshki D, Corun R (2016) Fatigue performance of re-refined engine oil bottom–modified asphalt: laboratory study. Transp Res Rec 2574:1–16. https://doi.org/10.3141/2574-01
Chen M, Leng B, Wu S, Sang Y (2014) Physical, chemical and rheological properties of waste edible vegetable oil rejuvenated asphalt binders. Constr Build Mater 66:286–298. https://doi.org/10.1016/j.conbuildmat.2014.05.033
DeDene CD (2011) Investigation of using waste engine oil blended with reclaimed asphalt materials to improve pavement recyclability. Michigan Technological University. https://digitalcommons.mtu.edu/etds/229/
DeDene CD, You Z (2014) The Performance of Aged Asphalt Materials Rejuvenated with Waste Engine Oil. Int J Pavement Res Technol 7(2):145–152
Dokandari PA, Kaya D, Sengoz B, Topal A (2017) Implementing waste oils with reclaimed asphalt pavement. In: Proceedings of the 2nd World congress on civil, structural and environmental engineering (CSEE’17), pp 1–12. https://doi.org/10.11159/icsenm17.142. https://avestia.com/CSEE2017_Proceedings/files/paper/ICSENM/ICSENM_142.pdf
Dominguez-Rosado E, Pichtel J, Coughlin M (2004) Phytoremediation of soil contaminated with used motor oil: I. Enhanced microbial activities from laboratory and growth chamber studies. Environ Eng Sci 21:157–168. https://doi.org/10.1089/109287504773087336
Eriskin E, Karahancer S, Terzi S, Saltan M (2017) Waste frying oil modified bitumen usage for sustainable hot mix asphalt pavement. Arch Civ Mech Eng 17:863–870. https://doi.org/10.1016/j.acme.2017.03.006
Farooq MA, Mir MS, Sharma A (2018) Laboratory study on use of RAP in WMA pavements using 693 rejuvenator. Constr Build Mater 168:61–72
García Á, Schlangen E, Van de Ven M (2011) Properties of capsules containing rejuvenators for their use in asphalt concrete. Fuel 90:583–591. https://doi.org/10.1016/j.fuel.2010.09.033
Golchin B, Mansourian A (2017) Evaluation of fatigue properties of asphalt mixtures containing reclaimed asphalt using response surface method. Int J Transp Eng 4:335–350. https://doi.org/10.22119/ijte.2017.44435
Haghshenas H, Khodaii A, Khedmati M, Tapkin S (2015) A mathematical model for predicting stripping potential of hot mix asphalt. Constr Build Mater 75:488–495. https://doi.org/10.1016/j.conbuildmat.2014.11.041
Hamzah MO, Omranian SR, Golchin B, Hainin MR (2015) Evaluation of effects of extended short-term aging on the rheological properties of asphalt binders at intermediate temperatures using respond surface method. J Teknol 73:133–139. https://doi.org/10.11113/jt.v73.4306
Hansen KR, Copeland A (2017) Annual asphalt pavement industry survey on recycled materials and warm-Mix asphalt usage: 2016. 7th annual survey. National asphalt pavement association
Herrington P, Hamilton P (1998) Recycling of waste oil distillation bottoms in asphalt, vol 102, P.R.
IHAP Code (2012) Iran Management and Planning Organization, Tehran, Iran, No. 234
Jahanbakhsh H, Karimi MM, Naseri H, Nejad FM (2020) Sustainable asphalt concrete containing high reclaimed asphalt pavements and recycling agents: performance assessment, cost analysis, and environmental impact. J Clean Prod 244:118837. https://doi.org/10.1016/j.jclepro.2019.118837
Jia X, Huang B, Moore JA, Zhao S (2015) Influence of waste engine oil on asphalt mixtures containing reclaimed asphalt pavement. J Mater Civ Eng 27:04015042. https://doi.org/10.1061/(ASCE)MT.1943-5533.0001292
Joni HH, Al-Rubaee RH, Al-zerkani MA (2019) Rejuvenation of aged asphalt binder extracted from reclaimed asphalt pavement using waste vegetable and engine oils. Case Stud Constr Mater 11:e00279
Kaseer F, Cucalon LG, Arámbula-Mercado EDITH, Martin AE, Epps J (2018) Practical tools for optimizing recycled materials content and recycling agent dosage for improved short-and long-term performance of rejuvenated binder blends and mixtures. J Associ Asphalt PavingTechnol 87:513–550
Kaseer F, Bajaj A, Martin AE, Arámbula-Mercado E, Hajj E (2019a) Strategies for producing asphalt mixtures with high RAP content. J Mater Civ Eng 31(11):05019002
Kaseer F, Martin AE, Arámbula-Mercado E (2019b) Use of recycling agents in asphalt mixtures with high recycled materials contents in the United States: a literature review. Constr Build Mater 211:974–987. https://doi.org/10.1016/j.conbuildmat.2019.03.286
Körbahti BK, Rauf M (2008) Response surface methodology (RSM) analysis of photoinduced decoloration of toludine blue. Chem Eng J 136:25–30. https://doi.org/10.1016/j.cej.2007.03.007
Körbahti BK, Rauf MA (2009) Determination of optimum operating conditions of carmine decoloration by UV/H2O2 using response surface methodology. J Hazard Mater 161:281–286. https://doi.org/10.1016/j.jhazmat.2008.03.118
Kushwaha JP, Srivastava VC, Mall ID (2010) Organics removal from dairy wastewater by electrochemical treatment and residue disposal. Sep Purif Technol 76:198–205. https://doi.org/10.1016/j.seppur.2010.10.008
Lesueur D (2009) The colloidal structure of bitumen: consequences on the rheology and on the mechanisms of bitumen modification. Adv Coll Interface Sci 145:42–82. https://doi.org/10.1016/j.cis.2008.08.011
Li J, Fujian N, Qingqing L (2018) Experimental investigation into the multiscale performance of asphalt mixtures with high contents of reclaimed asphalt pavement. J Mater Civ Eng 30(6):04018105. https://doi.org/10.1061/(ASCE)MT.1943-5533.0002269
Liu S, Peng A, Wu J, Zhou SB (2018) Waste engine oil influences on chemical and rheological properties of different asphalt binders. Constr Build Mater 191:1210–1220. https://doi.org/10.1016/j.conbuildmat.2018.10.126
Li Y, Shen A, Lyu Z, Wang S, Formela K (2019) Zhang G (2019) Ground tire rubber thermo-mechanically devulcanized in the presence of waste engine oil as asphalt modifier. Constr Build Mater 222:588–600. https://doi.org/10.1016/j.conbuildmat.2019.06.162
Mamun AA, Wahhab HIAA (2018) Comparative laboratory evaluation of waste cooking oil rejuvenated asphalt concrete mixtures for high contents of reclaimed asphalt pavement. Int J Pavement Eng. https://doi.org/10.1080/10298436.2018.1539486
Mamun A, Wahhab HIAA, Dalhat MA (2020) Comparative evaluation of waste cooking oil andwaste engine oil rejuvenated asphalt concrete mixtures. Arab J Sci Eng. https://doi.org/10.1007/s13369-020-04523-5
Mangiafico S, Di Benedetto H, Sauzéat C, Olard F, Pouget S, Planque L (2016) Effect of colloidal structure of bituminous binder blends on linear viscoelastic behaviour of mixtures containing Reclaimed Asphalt Pavement. Mater Des 111:126–139. https://doi.org/10.1016/j.matdes.2016.07.124
Mogawer W, Austerman A, Mohammad L, Kutay ME (2013) Evaluation of high RAP-WMA asphalt rubber mixtures. Road Mater Pavement Des 14:129–147. https://doi.org/10.1080/14680629.2013.812846
Moghaddam TB, Soltani M, Karim MR (2015a) Stiffness modulus of polyethylene terephthalate modified asphalt mixture: a statistical analysis of the laboratory testing results. Mater Des 68:88–96. https://doi.org/10.1016/j.matdes.2014.11.044
Moghaddam TB, Soltani M, Karim MR, Baaj H (2015b) Optimization of asphalt and modifier contents for polyethylene terephthalate modified asphalt mixtures using response surface methodology. Measurement 74:159–169. https://doi.org/10.1016/j.measurement.2015.07.012
Moniri A, Ziari H, Aliha MRM, Saghafi Y (2019) Laboratory study of the effect of oil-based recycling agents on high RAP asphalt mixtures. Int J Pavement Eng. https://doi.org/10.1080/10298436.2019.1696461
Montgomery DC (2017) Design and analysis of experiments John Wiley, New York
Nassar AI, Thom N, Parry T (2016) Optimizing the mix design of cold bitumen emulsion mixtures using response surface methodology. Constr Build Mater 104:216–229. https://doi.org/10.1016/j.conbuildmat.2015.12.073
Presti DL, del Barco Carrión AJ, Airey G, Hajj E (2016) Towards 100% recycling of reclaimed asphalt in road surface courses: binder design methodology and case studies. J Clean Prod 131:43–51. https://doi.org/10.1016/j.jclepro.2016.05.093
Qurashi IA, Swamy AK (2018) Viscoelastic properties of recycled asphalt binder containing waste engine oil. J Cleaner Prod 182:992–1000. https://doi.org/10.1016/j.jclepro.2018.01.237
Romera R, Santamaría A, Peña JJ, Muñoz ME, Barral M, García E, Jañez V (2006) Rheological aspects of the rejuvenation of aged bitumen. Rheol Acta 45:474–478. https://doi.org/10.1007/s00397-005-0078-7
Samsuri NS, Hassan NA, Kamaruddin NHM, Hainin MR, Abdullah ME, Mohd Yunus MKN (2020) Physical and rheological characterization of waste engine oil in aged asphalt binder. J Comput Theor Nanosci 17(2):1040–1043. https://doi.org/10.1166/jctn.2020.8765
Somé SC, Pavoine A, Chailleux E (2016) Evaluation of the potential use of waste sunflower and rapeseed oils-modified natural bitumen as binders for asphalt pavement design. Int J Pavement Res Technol 9:368. https://doi.org/10.1016/j.ijprt.2016.09.001
Su J-F, Qiu J, Schlangen E, Wang Y-Y (2015) Investigation the possibility of a new approach of using microcapsules containing waste cooking oil: in situ rejuvenation for aged bitumen. Constr Build Mater 74:83–92. https://doi.org/10.1016/j.conbuildmat.2014.10.018
Taherkhani H, Noorian F (2019) Laboratory investigation on the properties of asphalt concrete containing reclaimed asphalt pavement and waste cooking oil as recycling agent. Int J Pavement Eng. https://doi.org/10.1080/10298436.2019.1626387
Vazquez-Duhalt R (1989) Environmental impact of used motor oil. Sci Total Environ 79:1–23. https://doi.org/10.1016/0048-9697(89)90049-1
Villanueva A, Ho S, Zanzotto L (2008) Asphalt modification with used lubricating oil. Can J Civ Eng 35:148–157. https://doi.org/10.1139/L07-092
Wen H, Bhusal S, Wen B (2012) Laboratory evaluation of waste cooking oil-based bioasphalt as an alternative binder for hot mix asphalt. J Mater Civ Eng 25:1432–1437. https://doi.org/10.1061/(ASCE)MT.1943-5533.0000713
Xingyu Y, Ruikun D, Naipeng T (2020) Development of a novel binder rejuvenator composed by waste cooking oil and crumb tire rubber. Constr Build Mater 236:117621. https://doi.org/10.1016/j.conbuildmat.2019.117621
You Z, Mills-Beale J, Fini E, Goh SW, Colbert B (2011) Evaluation of low-temperature binder properties of warm-mix asphalt, extracted and recovered RAP and RAS, and bioasphalt. J Mater Civ Eng 23:1569–1574. https://doi.org/10.1061/(ASCE)MT.1943-5533.0000295
Zargar M, Ahmadinia E, Asli H, Karim MR (2012) Investigation of the possibility of using waste cooking oil as a rejuvenating agent for aged bitumen. J Hazard Mater 233:254–258. https://doi.org/10.1016/j.jhazmat.2012.06.021
Zhang J, Zhang X, Liang M, Jiang H, Wei J, Yao Z (2020) Influence of different rejuvenating agents on rheological behavior and dynamic response of recycled asphalt mixtures incorporating 60% RAP dosage. Constr Build Mater 238:117778
Zhao S, Liu J (2018) Using recycled asphalt pavement in construction of transportation infrastructure: alaska experience. J Clean Prod 177:155–168. https://doi.org/10.1016/j.jclepro.2017.12.104
Ziari H, Moniri A, Norouzi N (2019) The effect of nanoclay as bitumen modifier on rutting performance of asphalt mixtures containing high content of rejuvenated reclaimed asphalt pavement. Pet Sci Technol 37(17):1946–1951. https://doi.org/10.1080/10916466.2018.1471489
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Rights and permissions
About this article
Cite this article
Taherkhani, H., Noorian, F. Investigating Permanent Deformation of Recycled Asphalt Concrete Containing Waste Oils as Rejuvenator Using Response Surface Methodology (RSM). Iran J Sci Technol Trans Civ Eng 45, 1989–2001 (2021). https://doi.org/10.1007/s40996-020-00485-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40996-020-00485-8