Skip to main content
SpringerLink
Log in

Ultrasound Assisted Ash and Sulphur Removal from Bitumen Using Column Flotation Technique: Experimental, RSM and ANN Methods in Modelling and Optimization of Process

  • Research Paper
  • Published:
Iranian Journal of Science and Technology, Transactions A: Science Aims and scope Submit manuscript

Abstract

To remove ash and pyritic sulphur from bitumen an experimental study was performed to investigate the use of low frequency ultrasound wave in column flotation. For this purpose, a column flotation rig was equipped with a low frequency 24 kHz ultrasound transducer. The bitumen samples had sulphur content of 9.6 % (6.81 % in the pyritic sulphur form) and 26.4 % ash. All the experiments were carried out under pulp containing 5 % of solid, particle size of 100mesh and aeration rate of 4L/min using pine oil and kerosene as frother and collector agents, respectively. The effects of four parameters including the amounts of collector and frother agents, ultrasound power and ultrasound times were investigated. The optimum conditions for column flotation process with assisted ultrasound were; 1.5 kg/tbitumen of collector, 0.4 ppm of frother, ultrasound power equal to 300 W and ultrasound time of 3 min under flotation time of 5 min. In these conditions, 87.72 % of pyritic sulphur (i.e., 68.03 % of total sulphur) and 83.29 % of ash were removed. Accordingly, the enhancement of column flotation yield with ultrasound mode was approximately 11.9 and 10.3 % more than without ultrasound for ash and pyritic sulphur removal, respectively. The effect of process factors including amounts of collector and frother agents, ultrasound power and ultrasound time on ash and pyritic sulphur removal was investigated by central composite design (CCD) of RSM and multilayer feed forward back propagation neural network with the topology of 4-6-1.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11

Similar content being viewed by others

References

  • Aldrich C, Feng D (1999) Effect of ultrasonic preconditioning of pulp on the flotation of sulphide ores. Miner Eng 12(6):701–707

    Article  Google Scholar 

  • Angadi SI, Ho-Seok J, Nikkam S (2011) Experimental analysis of solids and water flow to the coal flotation froths. Int J Miner Proces 110–111:62–70

    Google Scholar 

  • Badkar DS, Pandey KS, Buvanashekaran G (2013) Development of RSM and ANN based models to predict and analyze the effects of process parameters of laser hardened commercially pure titanium on heat input and tensile strength. Int J Adv Manuf Technol 65(9):1319–1338

    Article  Google Scholar 

  • Boylu F, Laskowski SJ (2007) Rate of water transfer to flotation froth in the flotation of low-rank coal that also requires the use of oily collector. Int J Miner Proces 83(3–4):125–131

    Article  Google Scholar 

  • Capote PF, Luque de Castro MD (2007) Analytical applications of ultrasound. 1st edi., Elsevier Ltd., Amsterdam

  • Celik MS (1989) Effect of ultrasonic treatment on the floatability of coal and galena. Sep Sci Technol 24(14):1159–1166

    Article  Google Scholar 

  • Cross SS, Harrison RF, Kennedy RL (1995) Introduction to neural networks. The Lancet 346(8982):1075–1079

    Article  Google Scholar 

  • Ghoreishi SM, Hedari E (2013) Extraction of Epigallocatechin-3-gallate from green tea via supercritical fluid technology: neural network modeling and response surface optimization. J Supercrit Fluids 74:128–136

    Article  Google Scholar 

  • Jena MS, Biswal SK, Rudramuniyappa MV (2008) Study on flotation characteristics of oxidised Indian high ash sub-bituminous coal. Int J Miner Proces 87(1–2):42–50

    Article  Google Scholar 

  • Kang W, Xun H, Hu J, Jun-Tao C (2007) Study of enhanced fine coal de-sulphurization and de-ashing by ultrasonic flotation. J China Univ Min Technol 17(3):358–362

    Article  Google Scholar 

  • Kang W, Xun H, Hu J (2008) Study of the effect of ultrasonic treatment on the surface composition and the flotation performance of high-sulphur coal. Fuel Process Technol 89(12):1337–1344

    Article  Google Scholar 

  • Laborde JL, Hita A, Caltagirone JP, Gerard A (2000) Fluid dynamics phenomena induced by power ultrasounds. Ultrasonics 38(1–8):297–300

    Article  Google Scholar 

  • Manasseh R, Tho P, Ooi A, Petkovic-Duran K, Zhu Y (2010) Cavitation microstreaming and material transport around microbubbles. Phys Procedia 3(1):427–432

    Article  Google Scholar 

  • Maran JP, Priya B (2014) Ultrasound-assisted extraction of polysaccharide from Nephelium lappaceum L. fruit peel. Int J Biol Macromol 70:530–536

    Article  Google Scholar 

  • Maran JP, Priya B (2015) Ultrasound-assisted extraction of pectin from sisal waste. Carbohydr Polym 115:732–738

    Article  Google Scholar 

  • Maran JP, Manikandan S, Priya B, Gurumoorthi P (2015) Box-Behnken design based multi-response analysis and optimization of supercritical carbon dioxide extraction of bioactive flavonoid compounds from tea (Camellia sinensis L.) leaves. J Food Sci Technol 52(1):92–104

    Article  Google Scholar 

  • Melo F, Laskowski JS (2007) Effect of frothers and solid particles on the rate of water transfer to froth. Int J Miner Process 84(1–4):33–40

    Article  Google Scholar 

  • Ozkan SG (2002) Beneficiation of magnesite slimes with ultrasonic treatment. Miner Eng 15(1–2):99–101

    Article  Google Scholar 

  • Ozkan SG (2012) Effects of simultaneous ultrasonic treatment on flotation of hard coal slimes. Fuel 93:576–580

    Article  Google Scholar 

  • Ozkan SG, Kuyumcu HZ (2006) Investigation of mechanism of ultrasound on coal flotation. Int J Miner Proces 81(3):201–203

    Article  Google Scholar 

  • Ozkan SG, Kuyumcu HZ (2007) Design of a flotation cell equipped with ultrasound transducers to enhance coal flotation. Ultrason Sonochem 14(5):639–645

    Article  Google Scholar 

  • Parvizian F, Rahimi M, Azimi N (2012a) Macro- and micromixing studies on a high frequency continuous tubular sonoreactor. Chem Eng Process Process Intensif 57–58:8–15

    Article  Google Scholar 

  • Parvizian F, Rahimi M, Hosseini SM, Madaeni SS, Alsairafi AA (2012b) The effect of high frequency ultrasound on diffusion boundary layer resistance in ion-exchange membrane transport. Desalination 286:155–165

    Article  Google Scholar 

  • Pradyumna KN, Reddy PSR, Vibhuti NM (2005) Interpretation of interaction effects and optimization of reagent dosages for fine coal flotation. Int J Miner Proces 75(1–2):83–90

    Google Scholar 

  • Rajasekaran S, Vijayalakshmi-Pai GA (2004) Neural networks, fuzzy logic and genetic algorithms: synthesis and applications. PHI Learning Pvt. Ltd., Delhi, Chapter 2, pp 11–33

  • Saikia BK, Dutta AM, Saikia L, Ahmed S, Baruah BP (2013) Ultrasonic assisted cleaning of high sulphur Indian coals in water and mixed alkali. Fuel Process Technol 123:107–113

    Article  Google Scholar 

  • Saikia BK, Dutta AM, Baruah BP (2014) Feasibility studies of de-sulphurization and de-ashing of low grade medium to high sulphur coals by low energy ultrasonication. Fuel 123:12–18

    Article  Google Scholar 

  • Stamenković OS, Rajković K, Veličković AV, Milić PS, Veljković VB (2013) Optimization of base-catalyzed ethanolysis of sunflower oil by regression and artificial neural network models. Fuel Process Technol 114:101–108

    Article  Google Scholar 

  • Stoev SM, Kuzev L, Metodiev M, Djendova S (1992) Vibroacoustic improvements of froth flotation. In: Mavros P, Matis KA (eds) Innovations in flotation technology. NATO ASI Series, Kluwer Academic Publishers, Dordrecht, New York, 208:383–407

  • Vasseghian Y, Heidari N, Ahmadi M, Zahedi GR, Mohsenipour AA (2014) Simultaneous ash and sulphur removal from bitumen: experiments and neural network modeling. Fuel Process Technol 125:79–85

    Article  Google Scholar 

  • Wu J, Nyborg WL (2008) Ultrasound cavitation bubbles and their interaction with cells. Adv Drug Deliv Rev 60(10):1103–1116

    Article  Google Scholar 

  • The MathWorks Inc. (2012) The MathWorks Inc., Natick, MA. www.mathworks.com. Accessed 10 Aug 2014

Download references

Author information

Authors and Affiliations

  1. Chemical Engineering Department, Faculty of Engineering, Razi University, Kermanshah, Iran

    Yasser Vasseghian & Mojtaba Ahmadi

  2. Faculty of Chemistry, Razi University, 67149, Kermanshah, Iran

    Mohammad Joshaghani

Authors
  1. Yasser Vasseghian
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Mojtaba Ahmadi
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Mohammad Joshaghani
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Yasser Vasseghian.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Vasseghian, Y., Ahmadi, M. & Joshaghani, M. Ultrasound Assisted Ash and Sulphur Removal from Bitumen Using Column Flotation Technique: Experimental, RSM and ANN Methods in Modelling and Optimization of Process. Iran J Sci Technol Trans Sci 41, 1149–1163 (2017). https://doi.org/10.1007/s40995-016-0068-x

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s40995-016-0068-x

Keywords

Search

Navigation