Abstract
Composite structures consisting of two-dimensional (2D) materials deposited on elastic substrates have a wide range of potential applications in flexible electronics. For such devices, robust 2D film/substrate interfacial adhesion is essential for their reliable performance when subjected to external thermal and mechanical loads. To better understand the strength and failure behavior of the 2D film/substrate interfaces, two types of graphene/polymer samples with distinct interfacial adhesion properties are fabricated and tested by uniaxially stretching the substrates. Depending on the interfacial adhesion, two drastically different debonding rates are observed, i.e., rapid snap-through debonding and more progressive crack propagation. Motivated by the experimental observation, we propose an improved shear-lag model with a trapezoidal-shaped cohesive zone to derive an analytical solution for the decohesion behavior. The theoretical model reveals that the decohesion behavior of the frictional adhesive interface is governed by three dimensionless parameters. Particularly, the dimensionless length of the film essentially determines the decohesion rate; while the other two parameters affect the critical substrate strain to initiate debonding. By fitting the experimental data with the theoretical model, the intrinsic adhesion properties of the two samples are obtained with physically meaningful values. This work offers an analytical solution to describing the decohesion behavior of general thin film/substrate systems with a frictional adhesive interface, which is beneficial for characterizing and optimizing the mechanical properties of various thin film/polymer devices.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Zhang S, Ma T B, Erdemir A, Li Q Y. Tribology of two-dimensional materials: From mechanisms to modulating strategies. Mater Today 26: 67–86 (2019)
Kim S J, Choi K, Lee B, Kim Y, Hong B H. Materials for flexible, stretchable electronics: Graphene and 2D materials. Annu Rev Mater Res 45: 63–84 (2015)
Kanahashi K, Pu J A, Takenobu T. 2D materials for large-area flexible thermoelectric devices. Adv Energy Mater 10(11): 1902842 (2020)
Glavin N R, Chabak K D, Heller E R, Moore E A, Prusnick T A, Maruyama B, Walker D E Jr, Dorsey D L, Paduano Q, Snure M. Flexible gallium nitride for high-performance, strainable radio-frequency devices. Adv Mater 29(47): 1701838 (2017)
Gong L, Kinloch I A, Young R J, Riaz I, Jalil R, Novoselov K S. Interfacial stress transfer in a graphene monolayer nanocomposite. Adv Mater 22(24): 2694–2697 (2010)
Anagnostopoulos G, Androulidakis C, Koukaras E N, Tsoukleri G, Polyzos I, Parthenios J, Papagelis K, Galiotis C. Stress transfer mechanisms at the submicron level for graphene/polymer systems. ACS Appl Mater Interfaces 7(7): 4216–4223 (2015)
Xu C C, Xue T, Guo J G, Kang Y L, Qiu W, Song H B, Xie H M. An experimental investigation on the tangential interfacial properties of graphene: Size effect. Mater Lett 161: 755–758 (2015)
Xu C C, Xue T, Guo J G, Qin Q H, Wu S, Song H B, Xie H M. An experimental investigation on the mechanical properties of the interface between large-sized graphene and a flexible substrate. J Appl Phys 117(16): 164301 (2015)
Wang G R, Dai Z H, Liu L Q, Hu H, Dai Q, Zhang Z. Tuning the interfacial mechanical behaviors of monolayer graphene/PMMA nanocomposites. ACS Appl Mater Interfaces 8(34): 22554–22562 (2016)
Xu C C, Xue T, Qiu W, Kang Y L. Size effect of the interfacial mechanical behavior of graphene on a stretchable substrate. ACS Appl Mater Interfaces 8(40): 27099–27106 (2016)
Erdem Alaca B, Saif M T A, Sehitoglu H. On the interface debond at the edge of a thin film on a thick substrate. Acta Mater 50(5): 1197–1209 (2002)
Jiang T, Huang R, Zhu Y. Interfacial sliding and buckling of monolayer graphene on a stretchable substrate. Adv Funct Mater 24(3): 396–402 (2014)
Guo G D, Zhu Y. Cohesive-shear-lag modeling of interfacial stress transfer between a monolayer graphene and a polymer substrate. J Appl Mech 82(3): 031005 (2015)
Dai Z H, Wang G R, Liu L Q, Hou Y, Wei Y G, Zhang Z. Mechanical behavior and properties of hydrogen bonded graphene/polymer nano-interfaces. Compos Sci Technol 136: 1–9 (2016)
Cui T, Yip K, Hassan A, Wang G R, Liu X J, Sun Y, Filleter T. Graphene fatigue through van der Waals interactions. Sci Adv 6(42): eabb1335 (2020)
Wang Y L, Wang Y, Xu C, Zhang X W, Mei L, Wang M, Xia Y, Zhao P, Wang H T. Domain-boundary independency of Raman spectra for strained graphene at strong interfaces. Carbon 134: 37–42 (2018)
Mohiuddin T M G, Lombardo A, Nair R R, Bonetti A, Savini G, Jalil R, Bonini N, Basko D M, Galiotis C, Marzari N, et al. Uniaxial strain in graphene by Raman spectroscopy: G peak splitting, Grüneisen parameters, and sample orientation. Phys Rev B 79(20): 205433 (2009)
Tsoukleri G, Parthenios J, Papagelis K, Jalil R, Ferrari A C, Geim A K, Novoselov K S, Galiotis C. Subjecting a graphene monolayer to tension and compression. Small 5(21): 2397–2402 (2009)
Shen C, Oyadiji S O. The processing and analysis of graphene and the strength enhancement effect of graphene-based filler materials: A review. Mater Today Phys 15: 100257 (2020)
Jin Y, Ren Q, Liu J, Zhang Y, Zheng H, Zhao P. Stretching graphene to 3.3% strain using formvar-reinforced flexible substrate. Exp Mech 62(5): 761–767 (2022)
Acknowledgements
We gratefully acknowledge the support from the National Natural Science Foundation of China (Nos. 12025203, 11921002, and 11890671), the National Key R&D Program of China (No. 2022YFF0706100), and the Initiative Program of State Key Laboratory of Tribology in Advanced Equipment (No. SKLT2022A01). We thank Dr. Changyi Hong (Tianjin University) for preparing the graphene/PDMS and graphene/formvar-PDMS samples used in the experiments.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
The authors have no competing interests to declare that are relevant to the content of this article.
Additional information
Bo PENG. He is a senior engineer in Huawei Technologies Co., Ltd. He received his Ph.D. degree in engineering mechanics in 2021 from Tsinghua University, Beijng, China and B.E. degree in aircraft design in 2016 from Beihang University, Beijng, China. His current research aims at the theoretical analysis and experimental characterization of solid adhesive contact interfaces.
Qunyang LI. He is a professor in the Department of Engineering Mechanics at Tsinghua University. Before taking this position, he worked as a postdoctoral researcher and research scientist at the University of Pennsylvania, Philadelphia, USA from 2008 to 2012. He received his Ph.D. degree from the Brown University, Providence, USA in 2008 and B.S. and M.S. degrees in engineering mechanics from Tsinghua University in 2001 and 2003, respectively. His current research aims at understanding how surfaces interact at small scales and bridging nanoscale intrinsic properties to macroscale behaviors through experiments and mechanics modeling.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made.
The images or other third party material in this article are included in the article’s Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder.
To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Peng, B., Xu, C., Wang, Q. et al. Decohesion of graphene from a uniaxially-stretched substrate: Failure analysis of a frictional adhesive interface. Friction 12, 510–521 (2024). https://doi.org/10.1007/s40544-023-0779-x
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40544-023-0779-x