Skip to main content
SpringerLink
Log in

Crystals Array via Oriented Nucleation and Growth Induced by Smectic E Mesophase of C7-T-BTBT

  • Article
  • Published:
Chemical Research in Chinese Universities Aims and scope

Abstract

Long-range order crystalline thin films of organic semiconductors have attracted wide attention owing to their high charge carrier mobility. However, uncontrolled crystal nucleation and growth during the thin film drying process cause the formation of grain boundaries, thereby limiting the long-range order. Herein, we achieved the oriented nucleation and growth of organic semiconductors by off-centre spin-coating at the temperature of the smectic E(SmE) liquid crystal mesophase, and then followed by Ostwald ripening during solvent vapour annealing. The thin film of 2-(5-heptylthiophen-2-yl)[1]benzothieno[3,2-b][1]benzothiophne (C7-T-BTBT) blended with 40%(mass fraction) poly(methyl methacrylate)(PMMA) was prepared by off-centrespin-coating at SmE mesophase(170 °C), followed by solvent vapour annealing in chloroform for 24 h(chloroform is a good solvent for C7-T-BTBT and PMMA). The C7-T-BTBT molecules grew to rod-like crystals, which were mostly arranged parallel to each other. The crystal growth was perfect and resulted in a single crystal. The average length of the crystals was approximately 87 µm. Moreover, the highest charge carrier mobility is 1.62 cm2·V−1·s−1 as against that of the film prepared at 25 °C(0.06 cm2·V−1·s−1).

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Kim A., Jang K. S., Kim J., Won J. C., Yi M. H., Kim H., Yoon D. K., Shin T. J., Lee M. H., Ka J. W., Kim Y. H., Adv. Mater., 2013, 25, 6219

    Article  CAS  Google Scholar 

  2. Iino H., Usui T., Hanna J., Nat. Commun., 2015, 6, 6828

    Article  CAS  Google Scholar 

  3. Janneck R., Vercesi F., Heremans P., Genoe J., Rolin C., Adv. Mater., 2016, 28, 8007

    Article  CAS  Google Scholar 

  4. Kafle P., Zhang F. J., Schorr N. B., Huang K. Y., Rodríguez-López J., Diao Y., Adv. Funct. Mater., 2020, 30, 1909787

    Article  CAS  Google Scholar 

  5. Su Y. J., Gao X., Liu J. G., Xing R. B., Han Y. C., Phys. Chem. Chem. Phys., 2013, 15, 14396

    Article  CAS  Google Scholar 

  6. Li H. Y., Tee B. C., Cha J. J., Cui Y., Chung J. W., Lee S. Y., Bao Z. N., J. Am. Chem. Soc., 2012, 134, 2760

    Article  CAS  Google Scholar 

  7. Zheng L. D., Liu J. G., Sun Y. J., Ding Y., Han Y. C., Macromol. Chem. Phys., 2012, 213, 2081

    Article  CAS  Google Scholar 

  8. Su Y. J., Zheng L. D., Liu J. G., Han Y. C., RSC Adv., 2013, 3, 5529

    Article  CAS  Google Scholar 

  9. Zheng L. D., Liu J. G., Han Y. C., Phys. Chem. Chem. Phys., 2013, 15, 1208

    Article  CAS  Google Scholar 

  10. Kumatani A., Liu C., Li Y., Darmawan P., Takimiya K., Minari T., Tsukagoshi K., Sci. Rep., 2012, 2, 393

    Article  Google Scholar 

  11. Zhang K., Marszalek T., Wucher P., Wang Z., Veith L., Lu H., Räder H. J., Beaujuge P. M., Blom P. W. M., Pisula W., Adv. Funct. Mater., 2018, 28, 1805594

    Article  Google Scholar 

  12. Minemawari H., Yamada T., Matsui H., Tsutsumi J., Haas S., Chiba R., Kumai R., Hasegawa T., Nature, 2011, 475, 364

    Article  CAS  Google Scholar 

  13. Li H. Mei J. G., Ayzner A. L., Toney M. F., Tok J. B. H., Bao Z. N., Org. Electron., 2012, 13, 2450

    Article  CAS  Google Scholar 

  14. Fan C. C., Zoombelt A. P., Jiang H., Fu W. F., Wu J. K., Yuan W. T., Wang Y., Li H. Y., Chen H. Z., Bao Z. N., Adv. Mater., 2013, 25, 5762

    Article  CAS  Google Scholar 

  15. Zheng L. D., Han Y. C., J. Phys. Chem. B, 2012, 116, 1598

    Article  CAS  Google Scholar 

  16. Zhang Q., Liu J. G., Yu X. H., Han Y. C., Chin. Chem. Lett., 2019, 30, 1405

    Article  CAS  Google Scholar 

  17. Liu Y. D., Zhang Q., Yu X. H., Liu J. G., Han Y. C., Chin. J. Polym. Sci., 2019, 37, 664

    Article  CAS  Google Scholar 

  18. Zheng L. D., Liu J. G., Ding Y., Han Y. C., J. Phys. Chem. B, 2011, 115, 8071

    Article  CAS  Google Scholar 

  19. Li Y., Wan J., Smilgies D. M., Bouffard N., Sun R., Headrick R. L., Sci. Rep., 2016, 6, 32620

    Article  CAS  Google Scholar 

  20. Jia B. P., Gao L., Cryst. Growth Des., 2008, 8, 5

    Google Scholar 

  21. Deniz E., Lee A. Y., Myerson A. S., Acc. Chem. Res., 2009, 42, 621

    Article  Google Scholar 

  22. Zhang Q., Liu S. J., Yu S. H., J. Mater. Chem., 2009, 19, 191

    Article  CAS  Google Scholar 

  23. Liu C., Minari T., Lu X., Kumatani A., Takimiya K., Tsukagoshi K., Adv. Mater., 2011, 23, 523

    Article  CAS  Google Scholar 

  24. Liu C., Minari T., Li Y., Kumatani A., Lee M. V., Athena Pan S. H., Takimiya K., Tsukagoshi K., J. Mater. Chem., 2012, 22, 8462

    Article  CAS  Google Scholar 

  25. Tian H. K., Han Y., Bao C., Yan D. H., Geng Y. H., Wang F. S., Chem. Commun., 2012, 48, 3557

    Article  CAS  Google Scholar 

  26. Luca G. D., Liscio A., Maccagnani P., Nolde F., Palermo V., Müllen K., Samorì P., Adv. Funct. Mater., 2007, 17, 3791

    Article  Google Scholar 

  27. Mativetsky J. M., Kastler M., Savage R. C., Gentilini D., Palma M., Pisula W., Müllen K., Samorì P., Adv. Funct. Mater., 2009, 19, 2486

    Article  CAS  Google Scholar 

  28. Liu C., Khim D. Y., Noh Y. Y., J. Nanosci. Nanotechnol., 2014, 14, 1476

    Article  CAS  Google Scholar 

  29. Kim E., Park S., Han Y. S., Kim T. H., Polymer, 2018, 150, 214

    Article  CAS  Google Scholar 

  30. Ebata H., Izawa T., Miyazaki E., Takimiya K., Ikeda M., Kuwabara H., Yui T., J. Am. Chem. Soc., 2007, 129, 15732

    Article  CAS  Google Scholar 

  31. Xie W., Willa K., Wu Y. F., Hausermann R., Takimiya K., Batlogg B., Frisbie C. D., Adv. Mater., 2013, 25, 3478

    Article  CAS  Google Scholar 

  32. Yuan Y. B., Giri G., Ayzner A. L., Zoombelt A. P., Mannsfeld S. C., Chen J. H., Nordlund D., Toney M. F., Huang J. S., Bao Z. N., Nat. Commun., 2014, 5, 3005

    Article  Google Scholar 

  33. Janneck R., Pilet N., Bommanaboyena S. P., Watts B., Heremans P., Genoe J., Rolin C., Adv. Mater., 2017, 29, 1703864

    Article  Google Scholar 

  34. Minemawari H., Tsutsumi J. Y., Inoue S., Yamada T., Kumai R., Hasegawa T., Appl. Phys. Express, 2014, 7, 091601

    Article  CAS  Google Scholar 

  35. He K. Q., Li W. L., Tian H. K., Zhang J. D., Yan D. H., Geng Y. H., Wang F. S., ACS Appl. Mater. Interfaces, 2017, 9, 35427

    Article  CAS  Google Scholar 

  36. Li Y., Li M. G., Su Y. J., Liu J. G., Han Y. C., Zheng S. J., Wang L. X., Chin. Chem. Lett., 2016, 27, 475

    Article  CAS  Google Scholar 

  37. Funahashi M., Polym. J., 2009, 41, 459

    Article  CAS  Google Scholar 

  38. Fleischmann E. K., Zentel R., Angew. Chem. Int. Ed., 2013, 52, 8810

    Article  CAS  Google Scholar 

  39. Zhou T. L., Jia T., Zhao S. S., Guo J. H., Zhang H. Y., Wang Y., Cryst. Growth Des., 2012, 12, 179

    Article  CAS  Google Scholar 

  40. Burda C., Chen X. B., Narayanan R., El-Sayed M. A., Chem. Rev., 2005, 105, 78

    Article  Google Scholar 

Download references

Acknowledgements

This work was supported by the National Natural Science Foundation of China (Nos.51933010, 91833306, 52003269) and the Key Scientific and Technological Innovation Team Project of Shaanxi Province, China(No.2020TD-002).

Author information

Authors and Affiliations

  1. State Key Laboratory of Polymer Physics and Chemistry, Changchun Institute of Applied Chemistry, Chinese Academy of Sciences, Changchun, 130022, P. R. China

    Hongxiang Li, Sichun Wang, Xinyu Liu, Fan Wu, Qiang Zhang & Yanchun Han

  2. School of Applied Chemistry and Engineering, University of Science and Technology of China, Hefei, 230026, P. R. China

    Hongxiang Li, Sichun Wang, Xinyu Liu & Yanchun Han

  3. State Key Laboratory for Mechanical Behavior of Materials, Xi’an Jiaotong University, Xi’an, 710049, P. R. China

    Jian Yuan & Wei Ma

Authors
  1. Hongxiang Li
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Sichun Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Xinyu Liu
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Fan Wu
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Qiang Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Jian Yuan
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Wei Ma
    View author publications

    You can also search for this author in PubMed Google Scholar

  8. Yanchun Han
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Wei Ma or Yanchun Han.

Additional information

Conflicts of Interest

The authors declare no conflicts of interest.

Supporting Information

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Li, H., Wang, S., Liu, X. et al. Crystals Array via Oriented Nucleation and Growth Induced by Smectic E Mesophase of C7-T-BTBT. Chem. Res. Chin. Univ. 38, 1041–1049 (2022). https://doi.org/10.1007/s40242-021-1283-3

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s40242-021-1283-3

Keywords

Search

Navigation