Skip to main content
SpringerLink
Log in

Synthesis of polyethylene terephthalate/multi-walled carbon nanotubes adsorbent for methylene blue adsorption

  • Original Paper
  • Published:
International Journal of Environmental Science and Technology Aims and scope Submit manuscript

Abstract

Dye pollution is a typical undesirable environmental problem and requires effective solutions. This study aims to synthesize polyethylene terephthalate (PET) and polyethylene terephthalate/multi-walled carbon nanotube (PET/MWCNT) to adsorb methylene blue (MB). Both adsorbents are synthesized via the phase inversion method. It was found that the optimal contact time for the adsorption was 2880 min. At the initial concentration of 6 mg/L, PET/MWCNTs produced higher MB uptakes and percentage removal of 51.53% and 0.3162 mg/g, respectively, as compared to PET with 23.05 and 0.1421 mg/g, respectively. The adsorption capacity for both adsorbents decreased, while the MB dye removal percentage increased with increasing adsorbent dosage. When the initial concentration rose from 2 to 10 mg/L, the adsorption capacity increased but the removal percentage decreased for both adsorbents. The data obtained were well-fitted with the Langmuir (Type II) adsorption isotherm model with monolayer adsorption capacity, Qm, of 0.2215 and 0.7264 mg/g for MB-PET and MB-PET/MWCNTs systems, respectively. The Langmuir dimensionless factor, RL, values were in the range of 0 to 1 at all concentrations studied, which signified a favorable adsorption. In kinetic study, both the linear and nonlinear methods were conducted, and their results were tested with the F-test. The F-test divulged that the F-value obtained for all kinetic models studied (both linear and nonlinear methods) was greater than their respective F critical value, therefore, rejecting the null hypothesis. For all the systems studied, the P values obtained were below 0.05, which indicated a significant result of the F-test.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14
Fig. 15
Fig. 16
Fig. 17
Fig. 18
Fig. 19
Fig. 20
Fig. 21
Fig. 22

Similar content being viewed by others

Availability of data and materials

All the data and materials have been included in the main text. There is no supplementary information-Missed as per MS.

References

  • Abkenar SD, Hassannezhad M, Hosseini M, Ganjali MR (2019) Efficient removal of Malachite green from aqueous solution by adsorption on carbon nanotubes modified with ZnFe2O4 nanoparticles. J Serb Chem Soc 84:701–712

    Article  CAS  Google Scholar 

  • Aderemi HB, Nasri NS, Zainia MAA (2018) Physicochemical properties of char derived from palm fatty acid distillate. Malays J Fundam Appl Sci 14:403–406

    Article  Google Scholar 

  • Ahammad N, Yusop M, Din A, Ahmad MJSM (2021) Preparation of Alpinia galanga stem based activated carbon via single-step microwave irradiation for cationic dye removal. Sains Malays 50:2251–2269

    Article  CAS  Google Scholar 

  • Ahmad MA, Hamid SRA, Yusop MFM, Aziz HA (2017) Optimization of microwave-assisted durian seed based activated carbon preparation conditions for methylene blue dye removal. In: AIP conference proceedings, AIP Publishing LLC, p 040019

  • Ahmad M, Yusop M, Awang S, Yahaya NE, Rasyid M, Hassan H (2021a) Carbonization of sludge biomass of water treatment plant using continuous screw type conveyer pyrolyzer for methylene blue removal. In: IOP conference series: earth and environmental science, IOP Publishing, p 012112

  • Ahmad MA, Yusop MFM, Zakaria R, Karim J, Yahaya NKEM, Yusoff MAM, Hashim NHF, Abdullah NS (2021b) Adsorption of methylene blue from aqueous solution by peanut shell based activated carbon. Mater Today Proc 47:1246–1251

    Article  CAS  Google Scholar 

  • Ashraf MW, Abulibdeh N, Salam A (2019) Adsorption studies of textile dye (chrysoidine) from aqueous solutions using activated sawdust. Int J Chem Eng. https://doi.org/10.1155/2019/9728156

    Article  Google Scholar 

  • Aziz A, Nasehir Khan MN, Mohamad Yusop MF, Jaya MJE, Tamar Jaya MA, Ahmad MA (2021) Single-stage microwave-assisted coconut-shell-based activated carbon for removal of dichlorodiphenyltrichloroethane (DDT) from aqueous solution: optimization and batch studies. Int J Chem Eng. https://doi.org/10.1155/2021/9331386

    Article  Google Scholar 

  • Balarak D, Mostafapour F, Joghataei A (2016) Adsorption of acid blue 225 dye by multi walled carbon nanotubes: determination of equilibrium and kinetics parameters. Der Pharma Chemica 8:138–145

    CAS  Google Scholar 

  • Bazrafshan E, Kord Mostafapour F, Rahdar S, Mahvi AH (2015) Equilibrium and thermodynamics studies for decolorization of reactive black 5 (RB5) by adsorption onto MWCNTs. Desalin Water Treat 54:2241–2251

    Article  CAS  Google Scholar 

  • Cano I, Martin C, Fernandes JA, Lodge RW, Dupont J, Casado-Carmona FA, Lucena R, Cardenas S, Sans V, De Pedro I (2020) Paramagnetic ionic liquid-coated SiO2@ Fe3O4 nanoparticles—the next generation of magnetically recoverable nanocatalysts applied in the glycolysis of PET. Appl Catal b: Environ 260:118110

    Article  CAS  Google Scholar 

  • Chen X (2015) Modeling of experimental adsorption isotherm data. Information 6:14–22

    Article  Google Scholar 

  • Du H, Zhang Y, Jiang H, Wang H (2022) Adsorption of rhodamine B on polyvinyl chloride, polystyrene, and polyethylene terephthalate microplastics in aqueous environments. Environ Technol Innov 27:102495

    Article  CAS  Google Scholar 

  • El Essawy NA, Ali SM, Farag HA, Konsowa AH, Elnouby M, Hamad HA (2017) Green synthesis of graphene from recycled PET bottle wastes for use in the adsorption of dyes in aqueous solution. Ecotoxicol Environ Saf 145:57–68

    Article  Google Scholar 

  • Elvir-Padilla LG, Mendoza-Castillo DI, Reynel-Ávila HE, Bonilla-Petriciolet A (2022) Adsorption of dental clinic pollutants using bone char: adsorbent preparation, assessment and mechanism analysis. Chem Eng Res Des 183:192–202

    Article  CAS  Google Scholar 

  • Essa W, Yasin S, Abdullah A, Thalji M, Saeed I, Assiri M, Chong KF, Ali G (2022) Taguchi L25 (54) approach for methylene blue removal by polyethylene terephthalate nanofiber-multi-walled carbon nanotube composite. Water 14:1–16

    Article  Google Scholar 

  • Farghali AA, Bahgat M, Elrouby WM, Khedr MH (2013) Decoration of multi-walled carbon nanotubes (MWCNTs) with different ferrite nanoparticles and its use as an adsorbent. J Nanostructure Chem 3:1–12

    Article  Google Scholar 

  • Freundlich HMF (1906) Over the adsorption in solution. J Phys Chem 57:385–471

    CAS  Google Scholar 

  • Haciosmanoğlu GG, Mejías C, Martín J, Santos JL, Aparicio I, Alonso E (2022) Antibiotic adsorption by natural and modified clay minerals as designer adsorbents for wastewater treatment: a comprehensive review. J Environ Manag 317:115397

    Article  Google Scholar 

  • Hairom NHH, Soon CF, Mohamed RMSR, Morsin M, Zainal N, Nayan N, Zulkifli CZ, Harun NH (2021) A review of nanotechnological applications to detect and control surface water pollution. Environ Technol Innov 24:102032

    Article  CAS  Google Scholar 

  • Ho Y-S, McKay G (1998) Sorption of dye from aqueous solution by peat. Chem Eng J 70:115–124

    Article  CAS  Google Scholar 

  • Hu X, Alsaikhan F, Majdi HS, Bokov DO, Mohamed A, Sadeghi A (2022) Predictive modeling and computational machine learning simulation of adsorption separation using advanced nanocomposite materials. Arab J Chem 15:104062

    Article  CAS  Google Scholar 

  • Konicki W, Pełech I (2018) Removing cationic dye from aqueous solutions using as-grown and modified multi-walled carbon nanotubes. Pol J Environ Stud 28:717

    Article  Google Scholar 

  • Lagergren S, Svenska K (1898) About the theory of so-called adsorption of soluble substances. Sven Vetenskapsakad Handingarl 24:1–39

    Google Scholar 

  • Langmuir I (1918) The adsorption of gases on plane surfaces of glass, mica and platinum. J Am Chem Soc 40:1361–1403

    Article  CAS  Google Scholar 

  • Li S, Cho M-K, Lee K, Deng S, Zhao L, Yuan X, Wang J (2022) Diamond in the rough: polishing waste polyethylene terephthalate into activated carbon for CO2 capture. Sci Total Environ 834:155262

    Article  CAS  Google Scholar 

  • Liu Y, Hu X (2019) Kinetics and thermodynamics of efficient phosphorus removal by a composite fiber. Appl Sci 9:2220

    Article  CAS  Google Scholar 

  • Liu Z, Qin Q, Hu Z, Yan L, Ieong U-I, Xu Y (2020) Adsorption of chlorophenols on polyethylene terephthalate microplastics from aqueous environments: kinetics, mechanisms and influencing factors. Environ Pollut 265:114926

    Article  CAS  Google Scholar 

  • Madrakian T, Afkhami A, Ahmadi M, Bagheri H (2011) Removal of some cationic dyes from aqueous solutions using magnetic-modified multi-walled carbon nanotubes. J Hazard Mater 196:109–114

    Article  CAS  Google Scholar 

  • Mallakpour S, Behranvand V (2018) Synthesis of mesoporous recycled poly(ethylene terephthalate)/MWNT/carbon quantum dot nanocomposite from sustainable materials using ultrasonic waves: application for methylene blue removal. J Clean Prod 190:525–537

    Article  CAS  Google Scholar 

  • Nait-Merzoug A, Guellati O, Benjaballah A, Janowska I, Begin D, Manyala NI, Guerioune M (2017) Tartrazine removal from water using functionalized multiwall carbon nanotubes. Desalin Water Treat 67:397–405

    Article  CAS  Google Scholar 

  • Ngulube T, Gumbo JR, Masindi V, Maity A (2018) Calcined magnesite as an adsorbent for cationic and anionic dyes: characterization, adsorption parameters, isotherms and kinetics study. Heliyon 4:e00838

    Article  CAS  Google Scholar 

  • Pereao O, Laatikainen K, Bode-Aluko C, Fatoba O, Omoniyi E, Kochnev Y, Nechaev AN, Apel P, Petrik L (2021) Synthesis and characterisation of diglycolic acid functionalised polyethylene terephthalate nanofibers for rare earth elements recovery. J Environ Chem Eng 9:105902

    Article  CAS  Google Scholar 

  • Sasakova N, Gregova G, Takacova D, Mojzisova J, Papajova I, Venglovsky J, Szaboova T, Kovacova S (2018) Pollution of surface and ground water by sources related to agricultural activities. Waste Manag Agroecosystems 2:42

    Google Scholar 

  • Selen V, Güler Ö, Özer D, Evin E (2016) Synthesized multi-walled carbon nanotubes as a potential adsorbent for the removal of methylene blue dye: kinetics, isotherms, and thermodynamics. Desalin Water Treat 57:8826–8838

    Article  CAS  Google Scholar 

  • Soh EYS, Lim SS, Chew KW, Phuang XW, Ho VMV, Chu KYH, Wong RR, Lee LY, Tiong TJ (2022) Valorization of spent brewery yeast biosorbent with sonication-assisted adsorption for dye removal in wastewater treatment. Environ Res 204:112385

    Article  CAS  Google Scholar 

  • Temkin M, Pyzhev V (1940) Kinetics of ammonia synthesis on promoted iron catalysts. Acta Physicochim URSS 12:217–222

    Google Scholar 

  • Totito TC, Laatikainen K, Pereao O, Bode-Aluko C, Petrik L (2021) Adsorptive recovery of Cu2+ from aqueous solution by polyethylene terephthalate nanofibres modified with 2-(aminomethyl)pyridine. Appl Sci 11:11912

    Article  CAS  Google Scholar 

  • Vega-Negron AL, Alamo-Nole L, Perales-Perez O, Gonzalez-Mederos AM, Jusino-Olivencia C, Roman-Velazquez FR (2018) Simultaneous adsorption of cationic and anionic dyes by chitosan/cellulose beads for wastewaters treatment. Int J Environ Res 12:59–65

    Article  CAS  Google Scholar 

  • Vikrant K, Cho M, Khan A, Kim K-H, Ahn W-S, Kwon EE (2019) Adsorption properties of advanced functional materials against gaseous formaldehyde. Environ Res 178:108672

    Article  CAS  Google Scholar 

  • Vuono D, Catizzone E, Aloise A, Policicchio A, Agostino RG, Migliori M, Giordano G (2017) Modelling of adsorption of textile dyes over multi-walled carbon nanotubes: equilibrium and kinetic. Chin J Chem Eng 25:523–532

    Article  CAS  Google Scholar 

  • Wang B, Gao B, Zimmerman AR, Lee X (2018) Impregnation of multiwall carbon nanotubes in alginate beads dramatically enhances their adsorptive ability to aqueous methylene blue. Chem Eng Res Des 133:235–242

    Article  CAS  Google Scholar 

  • Wang X, Zhang R, Li Z, Yan B (2022) Adsorption properties and influencing factors of Cu(II) on polystyrene and polyethylene terephthalate microplastics in seawater. Sci Total Environ 812:152573

    Article  CAS  Google Scholar 

  • Weber WJ, Morris JC (1963) Kinetics of adsorption on carbon from solution. J Sanit Eng Div 89:31–60

    Article  Google Scholar 

  • Yuan X, Li S, Jeon S, Deng S, Zhao L, Lee KB (2020) Valorization of waste polyethylene terephthalate plastic into N-doped microporous carbon for CO2 capture through a one-pot synthesis. J Hazard Mater 399:123010

    Article  CAS  Google Scholar 

  • Yusop M, Aziz H, Ahmad M (2017) Scavenging remazol brilliant blue R dye using microwave-assisted activated carbon from acacia sawdust: equilibrium and kinetics studies. In: AIP conference proceedings, AIP Publishing LLC, p 040018

  • Yusop MFM, Ahmad MA, Rosli NA, Gonawan FN, Abdullah SJ (2021a) Scavenging malachite green dye from aqueous solution using durian peel based activated carbon. Malays J Fundam Appl Sci 17:95–103

    Article  Google Scholar 

  • Yusop MFM, Ahmad MA, Rosli NA, Manaf MEA (2021b) Adsorption of cationic methylene blue dye using microwave-assisted activated carbon derived from acacia wood: optimization and batch studies. Arab J Chem 14:103122

    Article  CAS  Google Scholar 

  • Yusop MFM, Jaya EMJ, Ahmad MA (2022a) Single-stage microwave assisted coconut shell based activated carbon for removal of Zn(II) ions from aqueous solution—optimization and batch studies. Arab J Chem 15:104011

    Article  Google Scholar 

  • Yusop MFM, Jaya EMJ, Din ATM, Bello OS, Ahmad MA (2022b) Single-stage optimized microwave-induced activated carbon from coconut shell for cadmium adsorption. Chem Eng Technol. https://doi.org/10.1002/ceat.202200051

    Article  Google Scholar 

Download references

Funding

The financial support from Universiti Sains Malaysia, Research University Individual (RUI) Grant (Account Number: 1001/PJKIMIA/8014092) is gratefully acknowledged.

Author information

Authors and Affiliations

  1. School of Chemical Engineering, Engineering Campus, Universiti Sains Malaysia, 14300, Nibong Tebal, Penang, Malaysia

    S. M. Lee, M. F. M. Yusop, W. L. Ng, M. A. Ahmad & S. H. Tan

Authors
  1. S. M. Lee
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. M. F. M. Yusop
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. W. L. Ng
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. M. A. Ahmad
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. S. H. Tan
    View author publications

    You can also search for this author in PubMed Google Scholar

Contributions

All authors contributed to the study conception and design. Material preparation, data collection, and analysis were performed by S. M. Lee and  W. L. Ng. The first draft of the manuscript was written by  S. M. Lee and  M. F. Mohamad Yusop. Both  M. A. Ahmad and  S. H. Tan commented and edited on the first draft. All authors read and approved the final manuscript.

Corresponding author

Correspondence to S. H. Tan.

Ethics declarations

Conflict of interest

The authors have no relevant financial or non-financial interest to disclose.

Consent to participate

All authors have agreed and contributed to this work prior to the submission.

Consent to publish

All authors agreed to submit this manuscript to the International Journal of Environmental Science and Technology.

Ethical approval

Not applicable.

Additional information

Editorial responsibility: Q. Aguilar-Virgen.

Rights and permissions

Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Lee, S.M., Yusop, M.F.M., Ng, W.L. et al. Synthesis of polyethylene terephthalate/multi-walled carbon nanotubes adsorbent for methylene blue adsorption. Int. J. Environ. Sci. Technol. 20, 9111–9128 (2023). https://doi.org/10.1007/s13762-022-04583-0

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13762-022-04583-0

Keywords

Search

Navigation