Abstract
The aim of this study was to examine the risk of heavy metal, ammonia and sulfate transition from underground coal gasification (UCG) chars and process water of Malkara lignite to the groundwater around the UCG cavity. The residues were collected during laboratory-scale underground coal gasification studies of Malkara lignite in ex situ gasification simulator. In order to compare gasification with combustion in terms of water pollution, ash samples were obtained by combustion of Malkara lignite. To determine the leaching behavior of the char and ash samples, two leaching tests (EPA TCLP and EN 12457-2 methods) were applied. The concentration of heavy metals in char, ash and process water samples was determined by ICP-OES. Additionally, ammonia and sulfate analyses were conducted for process water. Based on the results of this study, it has been found that the concentration of some elements, such as B, Sb and Al in char and ash eluates exceeded the maximum level of drinking water standards. However, there is no landfill concern about char samples according to EU Landfill Directive. A significant increase in B concentration was observed in ash samples. Considering B and some other elements combustion residues were identified with much higher water contamination ability, compared to gasification residues. Ammonia concentration was observed extremely high in process water of the gasification tests. UCG technique may be more environmentally applicable technology compared to combustion for Malkara lignite reserves. However, further detailed studies are necessary in the early stage of the UCG field test design and application.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
APHA 4500-SO4 (1992) Standard methods for the examination of water and wastewater. American Public Health Association, Washington, DC, USA
Bhutto AW, Bazmi AA, Zahedi G (2013) Underground coal gasification: from fundamentals to applications. Prog Energy Combust Sci 39:189–214
Burton E et al (2004) Practices in underground coal gasification (performed under the auspices of the U.S. Department of Energy by the University of California, Lawrence Livermore National Laboratory under contract No. W-7405-Eng-48.)
Council of the European Union (2003) 2003/33/EC – Council decision establishing criteria and procedures for the acceptance of waste at landfills pursuant to article 16 of and Annex II to directive 1999/31/EC. Off J Eur Communities, pp 27–49
Environment and Natural Resources (2004) Guideline for industrial waste discharges in the North Western Teritory, Canada, pp 1–15
Gregg DW, Edgar TF (1978) Underground coal gasification. AIChE J 24:753–781
Humenick MJ (1984) Water pollution control for underground coal gasification. J Energy Eng 110:100–112
Imran M, Kumar D, Kumar N et al (2014) Environmental concerns of underground coal gasification. Renew Sustain Energy Rev 31:600–610
Kapusta K, Stańczyk K (2010) Pollution of water during underground coal gasification of hard coal and lignite. Fuel 90:1927–1934
Kapusta K, Stańczyk K (2015) Chemical and toxicological evaluation of underground coal gasification (UCG) effluents. The coal rank effect. Ecotoxicol Environ Saf 112:105–113
Kapusta K, Stańczyk K, Wiatowski M et al (2013) Environmental aspects of a field-scale underground coal gasification trial in a shallow coal seam at the experimental mine Barbara in Poland. Fuel 113:196–208
Littlewood K (1977) Gasification: theory and application. Prog Energy Combust Sci 3:35–71
Liu S, Li J, Mei M, Dong D (2007) Groundwater pollution from underground coal gasification. J China Univ Min Technol 17:467–472
Pana C (2009) Review of underground coal gasification with reference to Alberta’s Potential, Energy Resources Conservation Board Report, 2009-10 AGS, Canada
Pei P, Nasah J, Solc J et al (2016) Investigation of the feasibility of underground coal gasification in North Dakota, United States. Energy Convers Manag 113:95–103
Shafirovich E, Varma A (2009) Underground coal gasification: a brief review of current status. Ind Eng Chem Res 48:7865–7875
Strugała-Wilczek A, Stańczyk K (2015) Comparison of metal elution from cavern residue after underground coal gasification and from ash obtained during coal combustion. Fuel 158:733–743
Strugała-wilczek A, Stańczyk K (2016) Leaching behaviour of metals from post-underground coal gasification cavity residues in water differing in mineralization. Fuel 173:106–114
Sury M, White M, Kirton J et al (2004) Review of environmental issues of underground coal gasification. Report No. COAL R273 DTI/Pub URN 04/1881, UK
Verma RP, Mandal R, Chaulya SK et al (2014) Contamination of groundwater due to underground coal gasification. Int J Water Resour Environ Eng 6:303–311
Acknowledgements
Acknowledgement is made to the TÜBİTAK (The Scientific and Technological Research Council of Turkey) Project No: 113M038 for their financial support. Authors also thank Dr. Cemile Yerlikaya and Esra Engin for their suggestions and technical supports in conducting this research.
Author information
Authors and Affiliations
Corresponding author
Additional information
Editorial responsibiility: Necip Atar.
Electronic supplementary material
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Fallahi, Y., Aydın, A.A., Gür, M. et al. Investigation of the pollution risk of residues from a laboratory-scale underground coal gasification of Malkara (Turkey) lignite. Int. J. Environ. Sci. Technol. 16, 1093–1102 (2019). https://doi.org/10.1007/s13762-018-1746-3
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13762-018-1746-3