Abstract
There are still cases of millers returning poor quality red wheat to the Zimbabwe Grain Marketing Board (GMB) and this has been an ongoing problem over the past few years. A larger amount of this wheat has discoloured and damaged embryos and it is discounted by millers because the germs are brittle and they crumble easily. There have been also many rejections of the red wheat particularly by major traders. Therefore there was an urgent need to investigate the causes and effects of storage conditions on the quality of silo-stored red wheat, since red wheat is one of human beings’ main food supplies. A representative sample of 2.25 kg of red winter wheat was randomly collected from the common red winter wheat incoming to the Grain Marketing Board Depot for storage. This representative sample of 2.25 kg was used as the control sample and its test density was determined. The control sample was then finely ground and analysed for protein, moisture, ash, aflatoxins and falling number. The red winter wheat was then stored in six different silos for a period of 5 months, with each silo having different humidity and temperature conditions. Representative samples of 4.5 kg were randomly collected monthly from each silo during the storage period. The test densities of the representative samples were determined. These representative samples were then finely ground and analysed for protein, moisture, ash, aflatoxins, and falling number. The results of the red wheat in storage were then compared with those of the control sample and analysed by analysis of variance (ANOVA) at the 5% level of significance. Results obtained after data analysis suggest that there were significant differences in the protein content, moisture content and falling number of the wheat before and after storage. However, differences in test density, aflatoxin and ash contents of the wheat before and after storage were not statistically significant at the 5% level of significance. The deterioration in wheat quality was attributed to the high storage temperature and humidity conditions. It was also concluded that the optimum conditions for wheat storage are a temperature of 15 oC and a humidity of 60%. 
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Farrel, G.; Hodges, R. Crop Post Harvest: Science and Technology; Blackwell Publishers: USA, 2002; Vol. 2, 2nd Edition, Chapter 3, p 18–21.
Bakker-Arkema, F. W.; Brooker, D.; Hall, C. Drying and Storage of Cereal Grains and Oilseeds; Chapman and Hall, New York, 2007, p 56.
Perten, H. Application of Falling Number Method for Evaluating Alpha-Amylase Activity: Cereal Chemistry. 2nd Edition. IBH Publishing Co., Pvt. Ltd., and New Delhi, 1964, p 23–24.
Farrel, G.; Hodges, R. Crop Post Harvest: Science and Technology; Blackwell Publishers: USA, 2004; Vol. 2, 3nd Edition, Chapter 3, p 20–23.
The Role of Fungi in Quality Loss; University of Minnesota Press. Minneapolis, USA, 1969; Vol. 11, 2nd Edition, p 16–19.
Hall, E. P.; Olcoh, H.; Mecham, D. K. Storage and Preservation of Cereal Grains; Kharagpur Publishers: India, 1995; p 76.
Sinha, R. N. Interrelations of Physical, Chemical and Biological Variables in Grain Storage. AVI Publishing Co. Inc.: Connecticut, 1973; p 45.
Christensen, C. M. Storage of Cereal Grains and their Products. 2nd Edition; AACC: St Paul 549, USA, 1974; p 18–24.
McKenzie, B. A.; Van Fossen, L.; Stockdale, H. J. Managing Dry Grain in Storage: Agricultural Engineering Digest; Iowa State University USA, 1980, Vol. 9, p 12–14.
American Association of Cereal Chemists. Storage of Cereal Grains. 5th Edition. AACC, St Paul 549: USA, 1983, p 33.
Pence, J. W.; Mecham, D. K.; Olcoh, H. S. Storage of Cereal Grains. 1st Edition. Western Utilisation Research Branch, Department of Agriculture Calif.: USA, 1988, p 46–52.
Kang, M. S. Crop Improvement: Challenges in the First Century; Holworth Press, Inc., New York, 2004, 2nd Edition, p 19.
Bothast, G. Post Harvest Technology of Cereals, Pulses and Oilseeds; Oxford and IBH Publishing Co., Pvt. Ltd.: New Delhi, 1978, 3rd Edition, p24–27.
Majumdar, S. Drying Technology in Agriculture and Food Science. 3rd Edition; IBH Publishing Co., New Delhi, 2000, p 47.
GMB Manual for Wheat Grading; GMB, Harare, Zimbabwe, 2002, p 2–18.
Association of Official Chemists. Useful State-of-The-Art Methodology for Chemical and Biological Processing; Vol. 83. AOCC, Newark DE, 19702: USA, 2000, p 92.
Fisher, H.J, Robertson, A.H, Rynolds, H.Association of Official Agricultural Chemists, AOAC, Newark DE, 19702: USA, 1939, 1st Edition, p 20.
Pomeranz, E. A; Meloan. Storage and Preservation of Cereal Grains. Kharagpur Publishers: India, 1994, Vol. 4, p31.
Author information
Authors and Affiliations
Corresponding author
Additional information
This article is published with open access at Springerlink.com
Rights and permissions
Open Access This article is distributed under the terms of the Creative Commons Attribution 2.0 International License (https://creativecommons.org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
About this article
Cite this article
Mhiko, T.A. Determination of the causes and the effects of storage conditions on the quality of silo stored wheat (Triticum aestivum) in Zimbabwe. Nat. Prod. Bioprospect. 2, 21–28 (2012). https://doi.org/10.1007/s13659-012-0004-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13659-012-0004-5