Abstract
The present study was focused on the bioenergy potential of Madhuca longifolia (mahua, MH) seeds to produce renewable fuel via thermocatalytic conversion. The physicochemical characterization of MH seed confirmed its bioenergy potential. Three model-free models were used to predict the pyrolysis kinetics of MH. The thermodynamic and kinetic analysis showed that MH has complex reaction kinetics which depends on the reaction rate as well as reaction order. Mahua seed was pyrolyzed in a semi-batch cylindrical shaped reactor with (CuO, Al2O3, and NaOH) and without catalysts. The yield of pyrolytic liquid during thermal pyrolysis was 51.2 wt%, whereas the use of catalysts decreased the liquid yield slightly at various biomass to catalyst ratios. Further, characterization results revealed that the use of catalysts improved the properties of pyrolytic oil by reducing viscosity, oxygenated compounds and with increasing heating value and acidity. FTIR spectra of pyrolytic oil confirmed the existence of phenols, aromatics, water, and acids which was also supported by the 1H NMR analysis. Further, GC-MS analysis confirmed reduction in oxygenated compounds and increase in alcohol.
Similar content being viewed by others
References
Kumar A, Kumar N, Baredar P, Shukla A (2015) A review on biomass energy resources, potential, conversion and policy in India. Renew Sust Energ Rev 45:530–539
Mishra RK, Mohanty K (2018) Characterization of non-edible lignocellulosic biomass in terms of their candidacy towards alternative renewable fuels. Biomass Conversion Biorefinery:1–14
Edrisi SA, Abhilash P (2016) Exploring marginal and degraded lands for biomass and bioenergy production: an Indian scenario. Renew Sust Energ Rev 54:1537–1551
Shadangi KP, Mohanty K (2014) Comparison of yield and fuel properties of thermal and catalytic Mahua seed pyrolytic oil. Fuel 117:372–380
Dauenhauer PJ (2010) Handbook of plant-based biofuels. Edited by Ashok Pandey. ChemSusChem: Chemistry & Sustainability Energy & Materials 3(3):386–387
Mishra RK, Mohanty K (2018) Pyrolysis characteristics and kinetic parameters assessment of three waste biomass. J Renew Sust Energy 10(1):013102
Mishra RK, Iyer JS, Mohanty K (2019) Conversion of waste biomass and waste nitrile gloves into renewable fuel. Waste Manag 89:397–407
Mishra RK, Mohanty K (2018) Thermocatalytic conversion of non-edible Neem seeds towards clean fuel and chemicals. J Anal Appl Pyrolysis 134:83–92
Mishra RK, Sahoo A, Mohanty K (2019) Pyrolysis kinetics and synergistic effect in co-pyrolysis of Samanea saman seeds and polyethylene terephthalate using thermogravimetric analyser. Bioresour Technol 289:121608
Saddawi A et al (2009) Kinetics of the thermal decomposition of biomass. Energy Fuel 24(2):1274–1282
Opfermann J, Kaisersberger E, Flammersheim H (2002) Model-free analysis of thermoanalytical data-advantages and limitations. Thermochim Acta 391(1–2):119–127
Mishra RK, Mohanty K (2019) Thermal and catalytic pyrolysis of pine sawdust (Pinus ponderosa) and Gulmohar seed (Delonix regia) towards production of fuel and chemicals. Mater Sci Energy Technol 2(2):139–149
Kabir G, Hameed B (2017) Recent progress on catalytic pyrolysis of lignocellulosic biomass to high-grade bio-oil and bio-chemicals. Renew Sust Energ Rev 70:945–967
Gautam R, Vinu R (2018) Non-catalytic fast pyrolysis and catalytic fast pyrolysis of Nannochloropsis oculata using Co-Mo/γ-Al2O3 catalyst for valuable chemicals. Algal Res 34:12–24
Venkatesan K, He S, Seshan K, Selvam P, Vinu R (2018) Selective production of aromatic hydrocarbons from lignocellulosic biomass via catalytic fast-hydropyrolysis using W2C/γ-Al2O3. Catal Commun 110:68–73
Chen G (2003) Catalytic application to biomass pyrolysis in a fixed bed reactor. Energy Sources 25(3):223–228
Chen X, Li S, Liu Z, Chen Y, Yang H, Wang X, Che Q, Chen W, Chen H (2019) Pyrolysis characteristics of lignocellulosic biomass components in the presence of CaO. Bioresour Technol 287:121493
Aysu T Pyrolysis of isochrysis microalgae with metal oxide catalysts for bio-oil production. J Turk Chem Soc Sect A: Chem 4(1):395–414
Shadangi KP, Mohanty K (2014) Thermal and catalytic pyrolysis of Karanja seed to produce liquid fuel. Fuel 115:434–442
Shadangi KP, Mohanty K (2014) Production and characterization of pyrolytic oil by catalytic pyrolysis of Niger seed. Fuel 126:109–115
Koul M, Shadangi KP, Mohanty K (2016) Effect of catalytic vapour cracking on fuel properties and composition of castor seed pyrolytic oil. J Anal Appl Pyrolysis 120:103–109
Stefanidis S et al (2011) In-situ upgrading of biomass pyrolysis vapors: catalyst screening on a fixed bed reactor. Bioresour Technol 102(17):8261–8267
Kim SW, Koo BS, Lee DH (2014) A comparative study of bio-oils from pyrolysis of microalgae and oil seed waste in a fluidized bed. Bioresour Technol 162:96–102
Ly HV, Choi JH, Woo HC, Kim SS, Kim J (2019) Upgrading bio-oil by catalytic fast pyrolysis of acid-washed Saccharina japonica alga in a fluidized-bed reactor. Renew Energy 133:11–22
Pütün E (2010) Catalytic pyrolysis of biomass: effects of pyrolysis temperature, sweeping gas flow rate and MgO catalyst. Energy 35(7):2761–2766
Mishra RK, Mohanty K (2019) Pyrolysis of three waste biomass: effect of biomass bed thickness and distance between successive beds on pyrolytic products yield and properties. Renew Energy 141:549–558
Santos NA et al (2015) Kinetic study of pyrolysis of castor beans (Ricinus communis L.) presscake: an alternative use for solid waste arising from the biodiesel production. Energy Fuel 29(4):2351–2357
Raj T, Kapoor M, Gaur R, Christopher J, Lamba B, Tuli DK, Kumar R (2015) Physical and chemical characterization of various Indian agriculture residues for biofuels production. Energy Fuel 29(5):3111–3118
Doshi P, Srivastava G, Pathak G, Dikshit M (2014) Physicochemical and thermal characterization of nonedible oilseed residual waste as sustainable solid biofuel. Waste Manag 34(10):1836–1846
Jüntgen H (1984) Review of the kinetics of pyrolysis and hydropyrolysis in relation to the chemical constitution of coal. Fuel 63(6):731–737
Ali SAM, Razzak SA, Hossain MM (2015) Apparent kinetics of high temperature oxidative decomposition of microalgal biomass. Bioresour Technol 175:569–577
Gai C, Zhang Y, Chen WT, Zhang P, Dong Y (2013) Thermogravimetric and kinetic analysis of thermal decomposition characteristics of low-lipid microalgae. Bioresour Technol 150:139–148
Maiti S, Purakayastha S, Ghosh B (2007) Thermal characterization of mustard straw and stalk in nitrogen at different heating rates. Fuel 86(10–11):1513–1518
Ashraf A, Sattar H, Munir S (2019) Thermal decomposition study and pyrolysis kinetics of coal and agricultural residues under non-isothermal conditions. Fuel 235:504–514
Liew RK, Nam WL, Chong MY, Phang XY, Su MH, Yek PNY, Ma NL, Cheng CK, Chong CT, Lam SS (2018) Oil palm waste: an abundant and promising feedstock for microwave pyrolysis conversion into good quality biochar with potential multi-applications. Process Saf Environ Prot 115:57–69
Mishra RK, Mohanty K (2018) Pyrolysis kinetics and thermal behavior of waste sawdust biomass using thermogravimetric analysis. Bioresour Technol 251:63–74
Chintala V, Kumar S, Pandey JK, Sharma AK, Kumar S (2017) Solar thermal pyrolysis of non-edible seeds to biofuels and their feasibility assessment. Energy Convers Manag 153:482–492
Biagini E, Fantei A, Tognotti L (2008) Effect of the heating rate on the devolatilization of biomass residues. Thermochim Acta 472(1):55–63
Ceylan S, Topçu Y (2014) Pyrolysis kinetics of hazelnut husk using thermogravimetric analysis. Bioresour Technol 156:182–188
Slopiecka K, Bartocci P, Fantozzi F (2012) Thermogravimetric analysis and kinetic study of poplar wood pyrolysis. Appl Energy 97:491–497
Varma AK, Mondal P (2016) Physicochemical characterization and kinetic study of pine needle for pyrolysis process. J Therm Anal Calorim 124(1):487–497
Yahiaoui M, Hadoun H, Toumert I, Hassani A (2015) Determination of kinetic parameters of Phlomis bovei de Noé using thermogravimetric analysis. Bioresour Technol 196:441–447
Morais L et al (2017) Pyrolysis and combustion of sugarcane bagasse. J Therm Anal Calorim 129(3):1813–1822
Radhakumari M, Prakash DJ, Satyavathi B (2016) Pyrolysis characteristics and kinetics of algal biomass using tga analysis based on ICTAC recommendations. Biomass Conversion Biorefinery 6(2):189–195
Biagini E, Fantei A, Tognotti L (2008) Effect of the heating rate on the devolatilization of biomass residues. Thermochim Acta 472(1–2):55–63
Vlaev L, Georgieva V, Genieva S (2007) Products and kinetics of non-isothermal decomposition of vanadium (IV) oxide compounds. J Therm Anal Calorim 88(3):805–812
Turmanova SC, Genieva SD, Dimitrova AS, Vlaev LT (2008) Non-isothermal degradation kinetics of filled with rise husk ash polypropene composites. Express Polym Lett 2(2):133–146
Wang Q, Zhao W, Liu H, Jia C, Li S (2011) Interactions and kinetic analysis of oil shale semi-coke with cornstalk during co-combustion. Appl Energy 88(6):2080–2087
Xu Y, Chen B (2013) Investigation of thermodynamic parameters in the pyrolysis conversion of biomass and manure to biochars using thermogravimetric analysis. Bioresour Technol 146:485–493
Ertaş M, Alma MH (2010) Pyrolysis of laurel (Laurus nobilis L.) extraction residues in a fixed-bed reactor: characterization of bio-oil and bio-char. J Anal Appl Pyrolysis 88(1):22–29
Demiral İ, Ayan EA (2011) Pyrolysis of grape bagasse: effect of pyrolysis conditions on the product yields and characterization of the liquid product. Bioresour Technol 102(4):3946–3951
Onay O, Kockar OM (2003) Slow, fast and flash pyrolysis of rapeseed. Renew Energy 28(15):2417–2433
Acknowledgments
The author would like to thank the Analytical Laboratory of Department of Chemical Engineering, Indian Institute of Technology Guwahati, India, for providing the necessary analytical facilities.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Mishra, R.K., Mohanty, K. Pyrolysis characteristics, fuel properties, and compositional study of Madhuca longifolia seeds over metal oxide catalysts. Biomass Conv. Bioref. 10, 621–637 (2020). https://doi.org/10.1007/s13399-019-00469-3
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13399-019-00469-3