Abstract
The purpose of this research is to solve the problem of unpredictable coal and rock dynamic disasters that frequently occur near extraction boreholes during the extraction of underground coal bed methane (CBM). The development laws of pores with different diameters inside the coal masses and the internal mechanisms during the low-temperature oxidation were studied using methods such as nuclear magnetic resonance, P wave tests, and gas chromatographs. Using the experimental result as a theoretical basis, a hole-sealing technique for the sealing–isolation integration was proposed to prevent the oxidation of the coal around the extraction borehole by combining the distribution of stresses around the borehole and fissure zones. The result showed that the pores with different diameters inside of the coal masses synchronously developed during the low-temperature oxidation; the micropores developed first, followed by the mesopores, and finally, the macropores. Furthermore, the development of the pores damaged the coal integrity and structural strength, which resulted in a higher risk of coal and rock dynamic disasters. Compared with the ordinary hole-sealing technique using cement mortar, the extraction concentration increased by 3.28 times when using the proposed hole-sealing technique for the sealing–isolation integration within 90 days of the test period for the extraction. Moreover, the borehole temperature decreased by \(121\,{^{\circ }}\hbox {C}\). The technique not only improves the extraction efficiency of the CBM but also inhibits the spontaneous combustion of the coal around the boreholes, which guarantees the safe and efficient extraction of the No. \(8_{2}\) CBM reservoir of the coal mine.
Similar content being viewed by others
References
Yan, F.; Lin, B.; Zhu, C.; Shen, C.; Zou, Q.; Guo, C.; Liu, T.: A novel ECBM extraction technology based on the integration of hydraulic slotting and hydraulic fracturing. J. Nat. Gas Sci. Eng. 22, 571–579 (2015)
Li, C.; Fu, S.; Cui, Y.; Sun, X.; Xie, B.; Yang, W.: Study of the migration rule of high-concentration gas and spatial-temporal feature of gas hazard in the tunnel. J. China Univ. Min. Technol. 01, 27–32 (2017)
Liu, W.; Qin, Y.; Qiao, T.; Ma, B.: Experimental demonstration on calculation of oxygen consumption rate and CO generation rate in coal spontaneous combustion. J. China Univ. Min. Technol. 06, 1141–1147 (2016)
Qi, G.; Wang, D.; Zheng, K.; Xu, J.; Qi, X.; Zhong, X.: Kinetics characteristics of coal low-temperature oxidation in oxygen-depleted air. J. Loss Prev. Process Ind. 35, 224–231 (2015)
Qi, X.; Xin, H.; Wang, D.; Qi, G.: A rapid method for determining the R70 self-heating rate of coal. Thermochim. Acta 571, 21–27 (2013)
Qin, B.; Wang, H.; Yang, J.; Liu, L.: Large-area goaf fires: a numerical method for locating high-temperature zones and assessing the effect of liquid nitrogen fire control. Environ. Earth Sci. 75, 139–151 (2016)
Babaei Khorzoughi, M.; Hall, R.: Processing of measurement while drilling data for rock mass characterization. Int. J. Min. Sci. Technol. 26, 989–994 (2016)
Chen, P.; Huang, F.; Fu, Y.: Performance of water-based foams affected by chemical inhibitors to retard spontaneous combustion of coal. Int. J. Min. Sci. Technol. 26, 443–448 (2016)
Adamus, A.; Šancer, J.; Guřanová, P.; Zubiček, V.: An investigation of the factors associated with interpretation of mine atmosphere for spontaneous combustion in coal mines. Fuel Process. Technol. 92, 663–670 (2011)
Ni, G.; Cheng, W.; Lin, B.; Zhai, C.: Experimental study on removing water blocking effect (WBE) from two aspects of the pore negative pressure and surfactants. J. Nat. Gas Sci. Eng. 31, 596–602 (2016)
Tang, Z.; Yang, S.; Wu, G.: Occurrence mechanism and risk assessment of dynamic of coal and rock disasters in the low-temperature oxidation process of a coal-bed methane reservoir. Energy Fuels 31, 3602–3609 (2017)
Davletbaev, A.Y.; Kovaleva, L.A.; Nasyrov, N.M.; Babadagli, T.: Multi-stage hydraulic fracturing and radio-frequency electromagnetic radiation for heavy-oil production. J. Unconv. Oil Gas Resour. 12, 15–22 (2015)
Engle, M.A.; Rowan, E.L.: Geochemical evolution of produced waters from hydraulic fracturing of the Marcellus Shale, northern appalachian basin: a multivariate compositional data analysis approach. Int. J. Coal Geol. 126, 45–56 (2014)
Gwenzi, W.; Mupatsi, N.M.: Evaluation of heavy metal leaching from coal ash-versus conventional concrete monoliths and debris. Waste Manag. 49, 114–123 (2016)
Zhai, C.; Yu, X.; Xiang, X.; Li, Q.; Wu, S.; Xu, J.: Experimental study of pulsating water pressure propagation in CBM reservoirs during pulse hydraulic fracturing. J. Nat. Gas Sci. Eng. 25, 15–22 (2015)
Zou, Q.; Lin, B.; Zheng, C.; Hao, Z.; Zhai, C.; Liu, T.; Liang, J.; Yan, F.; Yang, W.; Zhu, C.: Novel integrated techniques of drilling-slotting-separation-sealing for enhanced coal bed methane recovery in underground coal mines. J. Nat. Gas Sci. Eng. 26, 960–973 (2015)
Tang, Z.; Zhai, C.; Zou, Q.; Qin, L.: Changes to coal pores and fracture development by ultrasonic wave excitation using nuclear magnetic resonance. Fuel 186, 571–578 (2016)
Salmi, E.F.; Nazem, M.; Karakus, M.: The effect of rock mass gradual deterioration on the mechanism of post-mining subsidence over shallow abandoned coal mines. Int. J. Rock Mech. Min. Sci. 91, 59–71 (2017)
Shirzadegan, S.; Nordlund, E.; Zhang, P.: Large scale dynamic testing of rock support system at kiirunavaara underground mine. Rock Mech. Rock Eng. 49, 2773–2794 (2016)
Singh, R.V.K.: Spontaneous heating and fire in coal mines. Procedia Eng. 62, 78–90 (2013)
Krooss, B.M.; Bergen, F.V.; Gensterblum, Y.; Siemons, N.; Pagnier, H.: High-pressure methane and carbon dioxide adsorption on dry and moisture-equilibrated Pennsylvanian coals. Int. J. Coal Geol. 51, 69–92 (2002)
Park, J.; Oh, H.; Lee, Y.I.; Min, K.; Lee, E.; Jyoung, J.: Effect of the pore size variation in the substrate of the gas diffusion layer on water management and fuel cell performance. Appl. Energy 171, 200–212 (2016)
Xiao, F.; Liu, G.; Zhang, Z.; Shen, Z.; Zhang, F.; Wang, Y.: Acoustic emission characteristics and stress release rate of coal samples in different dynamic destruction time. Int. J. Min. Sci. Technol. 26, 981–988 (2016)
Jiang, L.; Sainoki, A.; Mitri, H.S.; Ma, N.; Liu, H.; Hao, Z.: Influence of fracture-induced weakening on coal mine gateroad stability. Int. J. Rock Mech. Min. Sci. 88, 307–317 (2016)
Yao, Y.; Liu, D.; Che, Y.; Tang, D.; Tang, S.; Huang, W.: Petrophysical characterization of coals by low-field nuclear magnetic resonance (NMR). Fuel 89, 1371–1380 (2010)
Ban, Y.; Tang, Y.; Wang, J.; Han, M.; Te, G.; Wang, Y.; He, R.; Zhi, K.; Liu, Q.: Effect of inorganic acid elution on microcrystalline structure and spontaneous combustion tendency of Shengli lignite. J. Fuel Chem. Technol. 44, 1059–1065 (2016)
Carras, J.N.; Day, S.J.; Saghafi, A.; Williams, D.J.: Greenhouse gas emissions from low-temperature oxidation and spontaneous combustion at open-cut coal mines in Australia. Int. J. Coal Geol. 78, 161–168 (2009)
LeDoux, S.T.M.; Szynkiewicz, A.; Faiia, A.M.; Mayes, M.A.; McKinney, M.L.; Dean, W.G.: Chemical and isotope compositions of shallow groundwater in areas impacted by hydraulic fracturing and surface mining in the Central Appalachian Basin, Eastern United States. Appl. Geochem. 71, 73–85 (2016)
Carette, J.; Staquet, S.: Monitoring the setting process of eco-binders by ultrasonic P-wave and S-wave transmission velocity measurement: mortar vs concrete. Constr. Build. Mater. 110, 32–41 (2016)
Grybas, I.; Bansevicius, R.; Jurenas, V.; Bubulis, A.; Janutenaite, J.; Kulvietis, G.: Ultrasonic standing waves-driven high resolution rotary table. Precis. Eng. 45, 396–402 (2016)
Hamidi, H.; Mohammadian, E.; Rafati, R.; Azdarpour, A.; Ing, J.: The effect of ultrasonic waves on the phase behavior of a surfactant-brine-oil system. Colloids Surf. A Physicochem. Eng. Asp. 482, 27–33 (2015)
Acknowledgements
This work was supported by the Fundamental Research Funds for the Central Universities (2017BSCXA02)
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Zheng, W., Yang, S., Tang, Z. et al. Evolutionary Laws and Preventative Measures for the Coal and Rock Dynamic Disasters Around the Boreholes During Coal Bed Methane Extraction in Low-Temperature Oxidation Conditions: A Case Study of the No. \(8_{2}\) Reservoir of the Yangliu Coal Mine. Arab J Sci Eng 43, 3647–3657 (2018). https://doi.org/10.1007/s13369-017-2919-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13369-017-2919-y