Abstract
In a solution of HF with HNO3 as an oxidizing agent, silver-catalyzed etching of p-type silicon is made easier. Before immersing in the etchant solution, silver (Ag) was electroless deposited on the p-Si (100) surface. By stain etching in HF/HNO3, a porous silicon layer (PSL) was also produced on p-Si. Electrochemical impedance spectroscopy (EIS), scanning electron microscopy (SEM), energy dispersive X-ray (EDX), atomic force microscopy (AFM), and X-ray diffraction (XRD) were used to evaluate the properties of the produced PSL. According to the SEM, Ag+ ion at a concentration of 1 × 10−3 M is the optimal concentration for depositing on Si before chemical etching in HF/HNO3, resulting in PSL with uniformly distributed pores. The EIS data showed that coated Si dissolves faster in 22 M HF/0.5 M HNO3 than untreated Si, resulting in the formation of a homogenous PSL of regular round pores, as proven by SEM micrographs. An acceptable electrical circuit model with two-time constants was used to fit the experimental impedance values. Increased concentrations of the etchant HF or the oxidizer HNO3 aid in the dissolution of Si and the rapid development of PS. The AFM analysis revealed that when the etching time increases, the pore width and roughness of the Si surface increase. X-ray spectra diffraction was used to determine the crystallinity of the PSL after various etching times.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
Koshida N, Koyama H (1992) Visible Electro- and Photoluminescence from Porous Silicon and its Related Optoelectronic Properties. Mater Res Soc Symp Proc 256:219
Anderson RC, Muller RS, Tobias CW (1990) Investigations of porous silicon for vapor sensing. Sens Actuator A 23:835–839
Talierico T, Dihan M, Massone E, Foucaran A, Gué AM, Bretagnon T, Fraisse B, Montès L (1995) Porous silicon membranes for gas-sensor applications. Sens Actuator A 46:43–46
Zangooie S, Bjorkland R, Arwin H (1997) Vapor sensitivity of thin porous silicon layers. Sensors Actuators B Chem 43:168–174
Létant SE, Content S, Tan TT, Zenhausen F, Sailor MJ (2000) Integration of porous silicon chips in an electronic artificial nose. Sensors Actuators B Chem 69:193–198
Lètant SE, Sailor MJ (2000) Detection of HF Gas with a Porous Silicon Interferometer. Adv Mater 12:355–359
Lin VSY, Dancil KPS, Sailor MJ, Ghadiri MR (1997) A Porous Silicon-Based Optical Interferometric Biosensor. Science 278:840–843
Starodub VM, Fedorenko LL, Sisetskiy AP, Starodub NF (1999) Control of myoglobin level in a solution by an immune sensor based on the photoluminescence of porous silicon. Sensors Actuators B Chem 58:409–414
Dancil KPS, Greiner DP, Sailor MJ (1999) A Porous Silicon Optical Biosensor: Detection of Reversible Binding of IgG to a Protein A-Modified Surface. J Am Chem 121:7925–7930
Searson PC, Macaulay JM, Prokes SM (1992) The Formation, Morphology, and Optical Properties of Porous Silicon Structures. J Electrochem Soc 139:3373–3377
Tian B, Zheng X, Kempa T (2007) Coaxial silicon nanowires as solar cells and nanoelectronic power sources. Nature 449:885–889
Beale MIJ, BenJamin JD, Uren MJ, Chew NG, Cullis AG (1986) The formation of porous silicon by chemical stain etches. J Cryst Growth 75:408–414
Fathauer RW, George T, Ksendzov A, Vasquez RP (1992) Visible luminescence from silicon wafers subjected to stain etches. Appl Phys Lett 60:995–997
Vázsonyi É, Szilágyi E, Petrik P, Horváth ZE, Lohner T, Fried M, Jalsovszky G (2001) Porous silicon formation by stain etching. Thin Solid Films 388:295–302
Starostina EA, Starkov VV, Vyatkin AF (2002). Mikroelektronika 31:104–196
Lehmann V (2002) Electrochemistry of silicon. Wiley-VCH, Germany, p 162
González-Diaz B, Guerrero-Lemus R, Marrero N, Hernández-Rodriguez C, Ben-Hander FA, Martinez-Duart JM (2006) Anisotropic textured silicon obtained by stain-etching at low etching rates. J Appl Phys 39:361–634
Steinert M, Acker J, Oswald S, Wetzig K (2007) Study on the Mechanism of Silicon Etching in HNO3-Rich HF/HNO3Mixtures. J Phys Chem C 111:2133–2140
Mogoda AS, Ahmad YH, Badawy WA (2011) Characterization of stain etched p-type silicon in aqueous HF solutions containing HNO3 or KMnO4. Mater Chem & Phys 126:676–684
Acker J, Rietig A, Steinert M, Hoffmann V (2012) Mass and Electron Balance for the Oxidation of Silicon during the Wet Chemical Etching in HF/HNO3Mixtures. J Phys Chem C 116:20380–20388
Rietig A, Langner T, Acker J (2019) A revised model of silicon oxidation during the dissolution of silicon in HF/HNO3mixtures. Phys Chem Chem Phys 21:22002–22013
Kooij ES, Butter K, Kelly JJ (1999) Silicon Etching in HNO3/HF Solution: Charge Balance for the Oxidation Reaction. Electrochem & Solid-State Lett 2:178
Malinovska DD, Vassileva MS, Tzenov N, Kamenova M (1997) Preparation of thin porous silicon layers by stain etching. Thin Solid Films 297:9–12
Christophersen M, Carstensen J, Foll H (2000) Crystal Orientation Dependence of Macropore Formation in p-Type Silicon Using Organic Electrolytes. Phys Status Solidi 182:103–107
Saadeldin MM, Mogoda AS, Abdelhaleem Soraya, Shalaby MS (2021) J Surf Invest 15:738
Stach S, Ţălu Ş, Dallaev R, Arman A, Sobola D, Salerno M (2020) Evaluation of the Topographical Surface Changes of Silicon Wafers after Annealing and Plasma Cleaning. Silicon 12:2563–2570
Peng K, Fang H, Hu J, Wu Y, Zhu J, Yan Y, Lee ST (2006). Chem Eur J 12:7942
Chartier C, Bastide S, Lévy-Clément C (2008) Metal-assisted chemical etching of silicon in HF–H2O2. Electrochim Acta 53:5509–5516
Chattopadhyay S, Li X, Bohn PW (2002) In-plane control of morphology and tunable photoluminescence in porous silicon produced by metal-assisted electroless chemical etching. J Appl Phys 91:6134–6140
Mogoda AS, Ahmad YH (2019) Electrochemical Impedance Study of Porous Silicon Prepared by Metal-Assisted Chemical Etching. Silicon 11:2837–2844
Hadjersi T, Gabouze N, Kooij ES, Zinine A, Ababou A, Chergui W, Chedraga H, Belhousse S, Djeghri A (2004) Metal-assisted chemical etching in HF/Na2S2O8 OR HF/KMnO4 produces porous silicon. Thin Solid Films 459:271–275
Hadjersi T, Gabouze N, Ababou A, Boumaour M, Chergui W, Cheraga H, Belhouse S, Djeghri A (2005) Metal-Assisted Chemical Etching of Multicrystalline Silicon in HF/ Na2S2O8 Produces Porous Silicon. Mater Sci Forum 480:139–144
Hadjersi T, Gabouze N, Yamamoto N, Sakamaki K, Takai H, Ababou A, Kooij ES (2005) Photoluminescence from undoped silicon after chemical etching combined with metal plating. Phys Status Solidi C 2:3384–3388
Zeng FG, Zhu CC, Fu XN, Wang WW, Zhao ZM (2005) Preparation of Co-passivated porous silicon by stain etching. Mater Chem & Phys 90:310–314
Ben Saad K, Saadoun M, Hamzaoui H, Bessais B (2008) AC impedance spectroscopy of porous silicon thin films containing metallic cations. Mater Sci Eng C 28:623–627
Vanmaekelbergh D, Searson PC (1994) On the Electrical Impedance Due to the Anodic Dissolution of Silicon in HF Solutions. J Electrochem Soc 141:697–702
Badawy WA, El-Sherif RM, Khalil SA (2010) Porous Si layers—Preparation, characterization and morphology. Electrochim Acta 55:8563–8569
El-Sherif RM, Khalil SA, Badawy WA (2011) Metal-assisted etching of p-silicon—Pore formation and characterization. J Alloys Compd 509:4122–4126
Nahm KS, Seo YH, Lee HJ (1997) Formation mechanism of stains during Si etching reaction in HF–oxidizing agent–H2O solutions. J Appl Phys 81:2418–2424
Bertagna V, Erre R, Rouelle F, Lèvy D, Petitdidier S, Chemla M (2001) Electrochemical impedance spectroscopy as a probe for wet chemical silicon oxide characterization. J Solid State Electrochem 5:306–312
Serantoni M, Cunnane VJ (2003) Time dependence study of the anisotropic etching of silicon by electrochemical impedance spectroscopy and atomic force microscopy. J Electroanal Chem 548:49–67
Mogoda AS, Zohdy KM (2022) Corrosion behavior of bismuth in concentrated sulphuric acid solution and stability of its surface oxide film. Int J Electrochem Sci https://doi.org/10.20964/2022.01.23
Safi M, Chazalviel JN, Cherkaoui M, Belaidi A, Gorochov O (2002) Etching of n-type silicon in (HF+oxidant) solutions: in situ characterization of surface chemistry. Electrochim. Acta 47:2573
Wan DH, Chen HL, Yu CC, Lee YC (2008) Using self-assembled nanoparticles to fabricate and optimize subwavelength textured structures in solar cells. Proc SPIE 7002:70020X-9
Lipinski M, Cichoszewski J, Socha RP, Piotrowski T (2009) Porous silicon formation by metal-assisted chemical etching. Acta Phys pol A 116:S-117
Acknowledgments
That section is not applicable.
Data and Material Accessibility
This article contains the data and materials from our research.
Funding
Open access funding provided by The Science, Technology & Innovation Funding Authority (STDF) in cooperation with The Egyptian Knowledge Bank (EKB).
Author information
Authors and Affiliations
Contributions
The authors of the current document contributed to every aspect of it, and their contributions are acknowledged by the order in which their names appear in the publication.
Corresponding author
Ethics declarations
Research Involving Human Participants and/or Animals
The writers did not conduct any studies with animals or human subjects for this publication.
Consent to Participate
We agree to participate in all the Journal suggests.
Consent for Publication
All of the writers whose names appear in this manuscript have agreed to have their work published in the silicon Journal.
Conflict of Interest
There are no conflicts of interest among the authors.
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Mogoda, A.S., Farag, A.R. The Effects of a Few Formation Parameters on Porous Silicon Production in HF/HNO3 Using Ag-Assisted Etching and a Comparison with a Stain Etching Method. Silicon 14, 11405–11415 (2022). https://doi.org/10.1007/s12633-022-01861-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12633-022-01861-x