Abstract
The fermentation of the sweet sorghum sugars, glucose, fructose, and sucrose to ethanol was studied in the presence of aconitic acid. In the past, aconitic acid has been identified as potential fermentation inhibitor, but very limited information exists about its inhibitory effects. As aconitic acid is naturally present in sweet sorghum (and its juice) and the fact that this plant has been proposed as a bioenergy crop, it was necessary to quantify the inhibition. Distiller’s yeast was used to produce ethanol from 83 g/L of total sugars in the presence of 0 to 13 g/L of aconitic acid. In some experiments, the pH of the fermentation was initially adjusted and allowed to drop as the fermentation progressed. In other experiments, the level of aconitic acid was held constant, while the pH was controlled at different set points between 2 and 4.5. In a final set of experiments, the pH was controlled to 2.9 and the initial concentration of aconitic acid was varied. It was conclusively shown that aconitic acid negatively impacts fermentation rate of distiller’s yeast and that the impact was pH dependent. At below pH 3.5, the impact was clearly observed and it became more influential at lower pH. The impact of aconitic acid on the fermentation rate was linked to the presence of undissociated aconitic acid which occurs at below pH 4.5. The level of undissociated aconitic acid that can be tolerated by the yeast depends on the pH. Thus, the most reasonable approach to improve fermentation rates in the presence of aconitic acid is to increase the pH of the fermentation. Both the ethanol yield (on sugar) and the final ethanol concentration (titer) were higher in the presence of aconitic acid but at a very small level (i.e., 4 and 3%, respectively). Thus, if the pH of the fermentation is increased, the presence of aconitic acid can be seen as advantageous.
Similar content being viewed by others
References
Amorim, H.V. 2015. Challenges to produce ethanol from sweet sorghum in Brazil. Paper presented at the Sweet Sorghum Association 2015 Annual Conference, Orlando, FL, January 27–29.
Atkinson, B., and F. Mavituna. 1991. Biochemical engineering and biotechnology handbook, 2nd ed. New York, NY: Stockton Press.
Clarke, M.A., and M.A. Brannan. 1983. Rapid analyses of lactic acid, an indicator of sugar cane deterioration, and aconitic acid, an indicator of sugar cane maturity, by high performance liquid chromatography. Journal American Society of Sugar Cane Technologists 2: 88.
Collier, D.W. 1953. Concentration of aqueous aconitic acid solutions. U.S. Patent 2,650,248.
Day, D.F., and D. Sarkar. 1982. Fuel alcohol from sweet sorghum: microbial aspects. Developments in Industrial Microbiology 23: 361–366.
Dean, J.A. 1999. Lange’s handbook of chemistry. New York: McGraw-Hill Inc.
Eggleston, G., M. Cole, and B. Andrzejewski. 2013. New commercially viable processing technologies for the production of sugar feedstocks from sweet sorghum (Sorghum bicolor L. Moench) for manufacture of biofuels and bioproducts. Sugar Tech 15 (3): 232–249.
Gibbons, W.R., and C.A. Westby. 1989. Cofermentation of sweet sorghum juice and grain for production of fuel ethanol and distillers’ wet grain. Biomass 18 (1): 43–57.
Graves, T., N.V. Narendranath, K. Dawson, and R. Power. 2006. Effect of pH and lactic or acetic acid on ethanol productivity by Saccharomyces cerevisiae in corn mash. Journal of Industrial Microbiology and Biotechnology 33 (6): 469–474.
Jönsson, L.J., and C. Martín. 2016. Pretreatment of lignocellulose: Formation of inhibitory by-products and strategies for minimizing their effects. Bioresource Technology 199: 103–112.
Kanitkar, A., G. Aita, and L. Madsen. 2013. The recovery of polymerization grade aconitic acid from sugarcane molasses. Journal of Chemical Technology and Biotechnology 88 (12): 2188–2192.
Kim, M., and D.F. Day. 2011. Composition of sugar cane, energy cane, and sweet sorghum suitable for ethanol production at Louisiana sugar mills. Journal of Industrial Microbiology and Biotechnology 38 (7): 803–807.
Kim, M., K.J. Han, Y. Jeong, and D.F. Day. 2012. Utilization of whole sweet sorghum containing juice, leaves, and bagasse for bio-ethanol production. Food Science and Biotechnology 21 (4): 1075–1080.
King, W.D., and D.R. Kester. 1990. A general approach for calculating polyprotic acid speciation and buffer capacity. Journal of Chemical Education 67 (11): 932–933.
Klasson, K.T. 2016. Impact of potential fermentation inhibitors present in sweet sorghum sugar solutions. Sugar Tech 1–7.
Maiorella, B., H.W. Blanch, and C.R. Wilke. 1983. By-product inhibition effects on ethanolic fermentation by Saccharomyces cerevisiae. Biotechnology and Bioengineering 25 (1): 103–121.
Mook, W.G. 2001. Environmental isotopes in the hydrological cycle: Principes and applications, Volume 1: Theory, methods, review. Vienna: International Atomic Energy Agency and United Nations Educational, Scientific and Cultural Organization.
Mussatto, S.I., and I.C. Roberto. 2004. Alternatives for detoxification of diluted-acid lignocellulosic hydrolyzates for use in fermentative processes: A review. Bioresource Technology 93 (1): 1–10.
Narendranath, N.V., K.C. Thomas, and W.M. Ingledew. 2001. Effects of acetic acid and lactic acid on the growth of Saccharomyces cerevisiae in a minimal medium. Journal of Industrial Microbiology and Biotechnology 26 (3): 171–177.
Nelson, E.K. 1929. Some organic acids of sugar cane molasses. Journal of the American Chemical Society 51 (9): 2808–2810.
Palmqvist, E., H. Grage, N.Q. Meinander, and B. Hahn-Hägerdal. 1999. Main and interaction effects of acetic acid, furfural, and p-hydroxybenzoic acid on growth and ethanol productivity of yeasts. Biotechnology and Bioengineering 63 (1): 46–55.
Pfendt, L., B. Drazic, G. Popovic, B. Drakulic, Z. Vitnik, and I. Juranic. 2003. Determination of all pKa values of some di- and tri-carboxylic unsaturated and epoxy acids and their polylinear correlation with the carboxylic group atomic charges. Journal of Chemical Research (M) 2003 (5): 0501–0514.
Piper, P., C.O. Calderon, K. Hatzixanthis, and M. Mollapour. 2001. Weak acid adaptation: The stress response that confers yeasts with resistance to organic acid food preservatives. Microbiology 147 (10): 2635–2642.
Polack, J.A., and D.F. Day. 1982. Ethanol for sweet sorghum. Journal American Society of Sugar Cane Technologists 1: 52–56.
Rao, P.S., K.S. Vinutha, G.S.A. Kumar, T. Chiranjeevi, A. Uma, P. Lal, R.S. Prakasham et al. 2016. Sorghum: A multipurpose bioenergy crop. In Sorghum: State of the art and future perspectives, eds. I. Ciampitti, and V. Prasad. Agronomy Monographs, vol. 58. Madison, WI: American Society of Agronomy and Crop Science Society of America, Inc.
Russell, J.B. 1992. Another explanation for the toxicity of fermentation acids at low pH: Anion accumulation versus uncoupling. Journal of Applied Bacteriology 73 (5): 363–370.
Savard, T., C. Beaulieu, N.J. Gardner, and C.P. Champagne. 2002. Characterization of spoilage yeasts isolated from fermented vegetables and inhibition by lactic, acetic and propionic acids. Food Microbiology 19 (4): 363–373.
Serna-Saldivar, S.O., and W.L. Rooney. 2014. Production and supply logistics of sweet sorghum as an energy feedstock. In Sustainable bioenergy production, ed. L. Wang, 193–212. Boca Raton: CRC Press.
Taherzadeh, M.J., C. Niklasson, and G. Lidén. 1997. Acetic acid—friend or foe in anaerobic batch conversion of glucose to ethanol by Saccharomyces cerevisiae? Chemical Engineering Science 52 (15): 2653–2659.
Thomas, K.C., S.H. Hynes, and W.M. Ingledew. 2002. Influence of medium buffering capacity on inhibition of Saccharomyces cerevisiae growth by acetic and lactic acids. Applied and Environmental Microbiology 68 (4): 1616–1623.
Ventre, E.K. 1955. Method for extracting aconitic acid from sugarcane and sorgo juices, sirups, and molasses. U.S. Patent 2,712,552.
Verduyn, C., E. Postma, W.A. Scheffers, and J.P. Van Dijken. 1990. Energetics of Saccharomyces cerevisiae in anaerobic glucose-limited chemostat cultures. Journal of General Microbiology 136 (3): 405–412.
Wu, X., S. Staggenborg, J.L. Propheter, W.L. Rooney, J. Yu, and D. Wang. 2010. Features of sweet sorghum juice and their performance in ethanol fermentation. Industrial Crops and Products 31 (1): 164–170.
Acknowledgements
The author would like to thank Mr. Larry Boihem, Jr., for assistance with chemical analysis. Mention of trade names or commercial products in this publication is solely for the purpose of providing specific information and does not imply recommendation or endorsement by the U.S. Department of Agriculture. USDA is an equal opportunity provider and employer.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Klasson, K.T. The Inhibitory Effects of Aconitic Acid on Bioethanol Production. Sugar Tech 20, 88–94 (2018). https://doi.org/10.1007/s12355-017-0525-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12355-017-0525-7