Abstract
It is an important task of people connected with the textiles and clothing sector to work on the feasible ways to trim down the carbon footprint in each phase of a textile product’s life cycle. One of the possible ways to decipher the reduction of carbon footprint of textiles and clothing sector is to recycle the textile process waste and also to recycle at the end-of-life of textile products and these aspects are exemplified in this paper in detail. Detailed investigation of the possibilities, barriers, challenges to recycle textile waste materials are discussed in this paper with relevant case studies. For recycling of process waste, an example was modelled by recycling the process waste and the carbon footprint results were demonstrated with the aid of 7.3 version of SIMAPRO LCA (Life cycle assessment) software. From the results of this case study, it was understood that recycling of process waste would contribute to the direct reduction of carbon footprint. For the second case of recycling at the end-of-life, there are many barriers and challenges to the textile products to be recycled, which are discussed in detail. For this case, two hypothetical situations were defined and the carbon footprint results of them were modeled and demonstrated with the aid of 7.3 version of SIMAPRO software to illustrate the benefits of recycling to reduce the carbon footprint. Designers need to conisder, “Ecological Design” in design phase to address most of the difficulties faced by recycling of textile products at the end-of-life, which will of certain help to reduce the carbon footprint of the textile products.
Similar content being viewed by others
References
Carbon Footprint, Retrieved from: http://www.carbonfootprint.com/carbonfootprint.html
E. G. Hertwich and G. P. Peters, Environ. Sci. Technol., 43, 6414 (2009).
Documentation for Emissions of Greenhouse Gases in the United States 2003, Retrieved from: http://www.eia.doe.gov/emeu/aer/txt/ptb1204.html
Carbon Footprint of Textiles, Dev Vivek, April 3, 2009, Retrieved from: http://www.domain-b.com/environment/20090403_carbon_footprint.html.
S. S. Muthu, Y. Li, J. Y. Hu, and P. Y. Mok, Atmospheric Environment, 45, 469 (2011).
S. S. Muthu, Y. Li, J. Y. Hu, and P. Y. Mok, Ecological Indicators, 18, 58 (2012).
J. Michaud, L. Farrant, O. Jan, B. Kjær, and I. Bakas, Environmental Benefits of Recycling-2010 Update, Final Report, WRAP, UK, March 2010.
Global Warming, Retrieved from: http://en.wikipedia.org/wiki/Globalwarming.
Global Warming Potential, Retrieved from: http://en.wikipedia.org/wiki/Globalwarmingpotential.
IPCC, “Intergovernmental Panel on Climate Change” (T. Houghton et al. Eds.), Climate Change 2001: the Scientific Basis. Contribution of Working Group I to the 3rd Assessment Report of the Intergovernmental Panel on Climate Change. Cambridge University Press, Cambridge, 2001.
J. B. Guinée, M. Gorrée, A. R. Heijungs, A G. Huppes, A R. Kleijn, A A. de Koning, A. Lv. Oers, A. A. Wegener Sleeswijk, S. Suh, A. H. A. Udo de Haes, H. de Bruijn, A. R. van Duin, and M. A. J. Huijbregts, “Handbook on Life Cycle Assessment. Operational Guide to the ISO Standards. I: LCA in Perspective. IIa: Guide. IIb: Operational Annex. Iii: Scientific Background”, p.692, Kluwer Academic Publishers, ISBN 1-4020-0228-9, Dordrecht, 2002.
ISO 14040, Environmental Management-Life Cycle Assessment-Principles and Frame Work. International Organisation for Standardisation, Geneva, 2006.
ISO 14044, Environmental Management -Life Cycle Assessment e. International Organisation for Standardisation, Geneva, 2006.
PAS 2050, Guide to PAS 2050: How to Assess the Carbon Footprint of Goods and Services, British Standards Institution, UK.
Y. Wang, Y. Zhang, M. Polk, S. Kumar, and J. Muzzy, “Recycling of Carpet and Textile Fibers” in “Plastics and the Environment: A Handbook” (A. L. Andrady Ed.), pp.697–725, John Wiley & Sons, New York, 2003.
IPCC Method, Retrieved from: http://www.pre.nl/simapro/impact_assessment_methods.htm#IPCC
Y. Li, S. S. Muthu, J. Y. Hu, P. Y. Mok, X. Ding, L. Wang, and W. Chen, Journal of Sustainable Development, 3, 71 (2010).
A. Jeihanipour, PhD Dissertation, Department of Chemical and Biological Engineering, Chalmers University of Technology, Gothenburg, Sweden, 2011.
Y. Wang, “Recycling in Textiles” Woodhead Publishing, UK, 2006.
Y. Wang, Waste and Biomass Valorization, 1, 135 (2010).
M. I. Tobler-Rohr, “Handbook of Sustainable Textile Production”, Woodhead Publishing Series in Textiles No. 124, Woodhead Publishing, UK, 2011.
D. Palm, “Improved Waste Management of Textiles, Project 9 Environmentally Improved Recycling”, IVL Swedish Environmental Research Institute Ltd., SE-400 14, Göteborg.
G. M. EI-Nouby, H. A. Azzam, S. T. Mohamed, and M. N. El-Sheikh, “Textile Waste-Material Recycling, Part I: Ways and Means, Textile Processing: State of the Art & Future Developments”, Vol. 2, pp.394–407, 2nd International Conference of Textile Research Division, NRC, Cairo, Egypt, April 11–13, 2005.
M. Jacob, H. Bryan, P. Shahila, S. Sarah, and A. Simon, “Mapping of Evidence on Sustainable Development Impacts that Occur in Life Cycles of Clothing: A Report to the Department for Environment, Food and Rural Affairs”, Environmental Resources Management [ERM] Ltd. Defra, London, 2007.
DEPA, Environmental Assessment of Textiles, Environmental Project No. 369. Danish Environmental Protection Agency, 1997.
K. J. Kooistra, R. Pyburn, and A. J. Termorshuizen, “The Sustainability of Cotton: Consequences for Man and Environment”, Science Shop Wageningen University & Research Centre, Report 223, ISBN: 90-6754-90-8585-000-2, 2006.
N. J. Morley, C. Bartlett, and I. McGill, “Maximising Reuse and Recycling of UK Clothing and Textiles: A Report to the Department for Environment, Food and Rural Affairs”, Oakdene Hollins Ltd., 2009.
N. Morley, S. Slater, S. Russel, M. Tipper, and G. D. Ward, “Recycling of Low Grade Clothing Waste”, Oakdene Hollins Ltd., Salvation Army Trading Company Ltd., Nonwovens Innovation and Research Institute Ltd., 2006.
J. M. Hawley, Cloth. Text. Res. J., 24, 262 (2006).
M. Collins and S. Gandy, “Streamlined Life Cycle Assessment of Textile Recycling”, Salvation Army Trading Company Ltd., 2002.
M. Larney and A. M. van Aardt, Journal of Family Ecology and Consumer Sciences, 32, 60 (2004).
N. Bhalla, “Market Transformation Programme — Waste Clothing Textiles”, Environmental Resources Management, October, 2005.
S. Sahni, A. Boustani, T. Gutowski, and S. Graves, Textile Manufacturing and Energy Savings, MITEI-1-g-2010, January 28th, 2010, Environmentally Benign Laboratory, Laboratory for Manufacturing and Productivity, Sloan School of Management.
A. C. Woolridge, G. D. Ward, P. S. Phillips, M. Collins, and S. Gandy, Resources, Conservation and Recycling, 46, 94 (2005).
K. Laitala and I. G. Klepp, “Environmental Improvement by Prolonging Clothing Use Period, Towards Sustainability in the Textile and Fashion Industry”, Copenhagen, 26–27 April, 2011.
N. Daneshvary, R. Daneshvary, and R. K. Schwer, Environment and Behaviour, 30, 144 (1998).
T. Domina and K. Koch, Journal of Fashion Marketing and Management, 3, 346 (1999).
M.-R. Korhonen and H. Dahlbo, The Finnish Environment, 30, 1 (2007).
J. M. Allwood, S. E. Laursen, C. M. de Rodríguez, and N. M. P. Bocken, “Well Dressed?”, University of Cambridge, 2006.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Muthu, S.S., Li, Y., Hu, J.Y. et al. Carbon footprint reduction in the textile process chain: Recycling of textile materials. Fibers Polym 13, 1065–1070 (2012). https://doi.org/10.1007/s12221-012-1065-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12221-012-1065-0