Skip to main content
SpringerLink
Log in

Influences of Residence time of Fuel Vapor Transport on Sooting Behavior of Ethanol Droplet Flames in Microgravity

  • Original Article
  • Published:
Microgravity Science and Technology Aims and scope Submit manuscript

Abstract

A series of experiments were performed to elucidate the influence of residence time of fuel vapor transport on the sooting behavior of microgravity ethanol droplet flames using the 2.2 sec drop-tower facilities at the NASA Glenn Research Center (GRC). In these experiments, the residence time of fuel vapor transport was adjusted by means of changes in initial droplet diameters (1.6 mm versus 1.9 mm) and oxygen concentrations (ranging from 21 % to 33 % mole fraction in argon atmospheric environments). As the flame temperature is increased, the measured soot volume fraction initially increased and then began to decrease after reaching a maximum value. Experimental results clearly indicate that the residence time can control the sooting behavior for microgravity droplet flames by mediating the competition among the fuel pyrolysis reactions, fragmentation of formed soot precursors, and oxidation of soot precursors and particles which eventually result in an interesting non-monotonic sooting behavior at elevated flame temperatures.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10

Similar content being viewed by others

References

  • Bundy, M., Hamins, A., Lee, K.Y.: Suppression limits of low strain rate non-premixed methane flames. Combust.Flame 133, 299–310 (2003)

    Article  Google Scholar 

  • Dasch, C.J.: One-dimensional tomography: A comparison of Abel, onionpeeling, and filtered back projection methods. Appl. Opt. 31, 1146–1152 (1996)

    Article  Google Scholar 

  • Frenklach, M., Clary, D.W., Gardiner, W.C., Stein. S.E.: Detailed kinetic modeling of soot formation in shock-tube pyrolysis of acetylene. Proc. Combust. Inst. 20, 887–901 (1984)

    Article  Google Scholar 

  • Glassman, I.: Sooting laminar diffusion flames: Effect of dilution, additives, pressure, and microgravity. Proc. Combust. Inst. 27, 1589–1596 (1998)

    Article  Google Scholar 

  • Glassman, I.: Combustion. Academic Press, Orlando (1995)

    Google Scholar 

  • Gulder, O.L., Snelling, D.R.: Influence of nitrogen dilution and flame temperature on soot formation in diffusion. flames. Combust. Flame 92, 115–124 (1993)

    Article  Google Scholar 

  • Guo, H., Liu, F., Smallwood, G.J., Gulder, O.L.: Inter. J. Comput. Fluid Dynam. 18(2), 139–151 (2004)

  • Hara, H., Kumagai, S.: Experimental investigation of free droplet combustion under microgravity. Proc. Combust. Inst. 23, 1605–1610 (1991)

  • Jackson, G.S., Avedisian, C.T., Yang, J.C.: Observations of soot during droplet combustion at low gravity: Heptane and heptane/monochloroalkane mixtures. Int. J. Heat Mass Trans. 35, 2017–2033 (1992)

    Article  Google Scholar 

  • Kazakov, A., Conley, J., Dryer, F.L.: Detailed modeling of an isolated, ethanol droplet combustion under microgravity conditions. Combust. Flame 134, 301–314 (2003)

    Article  Google Scholar 

  • Kitamura, T., Ito, T., Senda, J., Fujimoto, H.: Extraction of the suppression effects of oxygenated fuels on soot formation using a detailed chemical kinetic model. JSAE Rev. 22, 139–145 (2001)

    Article  Google Scholar 

  • Koylu, U.O., Faeth, G.M.: Carbon-monoxide and soot emissions from liquid-fueled buoyant turbulent-diffusion flames. Combust. Flame 87, 61–76 (1991)

    Article  Google Scholar 

  • Lee, K.O., Choi, M.Y.: Observations on the sooting behavior of microgravity droplet flames under reduced pressures. Microgravity Sci. Technol. X/2, 86–94 (1997)

    Google Scholar 

  • Lee, K.O., Manzello, S.L., Choi, M.Y.: The effects of initial droplet diameter on sooting and burning behavior of isolated droplets under microgravity conditions. Combust. Sci. and Tech. 132, 139–156 (1998)

    Article  Google Scholar 

  • Marchese, M.A., Dryer, F.L.: The effect of non-luminous thermal radiation in microgravity droplet combustion. Combust. Sci. Technol. 124, 371–402 (1997)

    Article  Google Scholar 

  • Okajima, S., Kumagai, S.: Further investigations of combustion of free droplets in a freely falling chamber including moving droplets. Proc. Combust. Inst. 15, 401–407 (1975)

  • Park, S.H., Choi, S.C., Choi, M.Y., Yozgatligil, A.: New observations of isolated ethanol droplet flames in microgravity conditions. Combust. Sci. Technol. 180(4), 631–651 (2008)

    Article  Google Scholar 

  • Richter, H., Howard, H., Richter, J.B.: Formation of polycyclic aromatic hydrocarbons and their growth to soot—a review of chemical reaction pathways. Prog. Energy Combust. Sci. 26, 565–608 (2000)

    Article  Google Scholar 

  • Vilimpoc, V., Goss, L.: SiC-based thin-filament pyrometry: Theory and thermal properties. Proc. Combust. Inst. 22, 1907–1914 (1989)

    Article  Google Scholar 

  • Yozgatligil, A., Park, S.H., Choi, M.Y., Kazakov, A., Dryer, F.L.: Burning and sooting behavior of ethanol droplet combustion under microgravity condition. Combust. Sci. Tech. 176, 1–15 (2004)

    Article  Google Scholar 

  • Yozgatligil, A., Park, S.H., Choi, M.Y., Kazakov, A., Dryer, F.L.: Influence of oxygen concentration on the sooting behavior of ethanol droplet flames in microgravity conditions. Proc. Combust. Inst. 31, 2165–2173 (2007)

    Article  Google Scholar 

Download references

Acknowledgments

Support from NASA through Grant NCC3-822 is gratefully acknowledged. S.H. Park also would like to acknowledge the financial support from Basic Science Research Program through the National Research Foundation of Korea (NRF) funded by the Ministry of Science, ICT & Future Planning (2014R1A1A1002184).

Author information

Authors and Affiliations

  1. Department of Mechanical Systems Engineering, Chosun University, Gwangju, 501-759, Korea

    Seul-Hyun Park

  2. Department of Mechanical Engineering, University of Connecticut, Storrs, CT, 06269-3139, USA

    Mun Young Choi

Authors
  1. Seul-Hyun Park
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Mun Young Choi
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Seul-Hyun Park.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Park, SH., Choi, M.Y. Influences of Residence time of Fuel Vapor Transport on Sooting Behavior of Ethanol Droplet Flames in Microgravity. Microgravity Sci. Technol. 27, 337–344 (2015). https://doi.org/10.1007/s12217-015-9420-6

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s12217-015-9420-6

Keywords

Search

Navigation