Abstract
Thin wire, subcooled boiling experiments were performed onboard an aircraft flying a parabolic trajectory to provide microgravity conditions for improved observation of jet flow phenomena and their behavior in the absence of buoyant forces. A new type of nucleation jet flow was observed in microgravity. This new micro-bubble jet flow is seen at medium to high heat fluxes and is characterized by a region of the wire that forms multiple jet columns which contain micro-bubbles. These columns flow together and penetrate tens of millimeters into the bulk fluid. Bubble behavior on the wire was observed to progress from a dominance of larger isolated bubbles on the wire to a dominance of micro-bubble jet flows on the wire as heat flux was increased. There was also a transient transition from a few large isolated bubbles to micro-bubble jet flow dominance for a set heat flux. A cross correlation calculation provided velocities of micro-bubbles in the flow, which were in the range of 4-14 mm/s. These velocities were used with convection correlations to show that fluid flows induced by jet flows are a significant contributor to the subcooled boiling heat transfer in microgravity, but are not the primary contributor. Additionally, a relative bubble area analysis approximates the direct contribution of these jet flows to the overall heat dissipation. These micro-bubble jet flows, which are only observed on thin wires (not flat surfaces), and the convection currents they induce, have the potential to allow for sustained fluid motion to occur in microgravity.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Christopher, D.M., Wang, H., Peng, X.: Dynamics of bubble motion and bubble top jet flows from moving vapor bubbles on microwires. J. of Heat Tran. 127, 1260–1268 (2005)
Christopher, D.M., Wang, H., Peng, X.: Numerical analysis of the dynamics of moving vapor bubbles. Int. J. of Heat and Mass Tran. 49, 3626–3633 (2006)
Christopher, D.M., Wang, H., Peng, X., Garimella, S.V.: Closure to discussion: Dynamics of bubble motion and bubble top jet flows from moving vapor bubbles on microwires. (Christopher, D.M., Wang, H., and Peng, X., 2005, Journal of Heat 13 Transfer, 127, 1260-1268. J. Heat Tran. 128, 1344–1345 (2006)
Christopher, D.M., Wang, H.: Mechanism for nucleation jet enhancement of nucleate pool boiling. J. Enhanced Heat Tran. 14, 209–221 (2007)
Churchill, S.W., Bernstein, M.: A correlating equation for forced convection from gases and liquids to a circular cylinder in crossflow. J. Heat Tran. 99, 300–306 (1977)
Chyu, M.-C., Mghamis, A.: Nucleate boiling on two cylinders in line contact. Int. J. Heat and Mass Tran. 34, 1783–1790 (1991)
Cieslinski, J.T., Polewski, J., Szymczyk, J.A.: Flow field around growing and rising vapour bubble by PIV measurement. J. Visualization 8, 209–216 (2005)
Dong, L., Quan, X., Cheng, P.: An analysis of surface-microstructures effects on heterogeneous nucleation in pool boiling. Int. J. Heat and Mass Tran. 55, 4376–4384 (2012)
Henry, C.D., Kim, J., McQuillen, J.: Dissolved gas effects on thermocapillary convection during boiling in reduced gravity environments. Heat and Mass Tran. 42, 919–928 (2006)
Incropera, F.P., Dewitt, D.P., Bergman, T.L., Lavine, A.S.: Fundamentals of Heat and Mass Transfer, sixth ed., pp. 433-434,625-631, Chaps. 7 and 10. John Wiley & Sons, Hoboken, New Jersey (2007)
Koeln, J.P., Boulware, J.C., Ban, H., Dennison, J.: Observations on braided thin wire nucleate boiling in microgravity. Int. J. Heat and Fluid Flow 32, 973–981 (2011)
Lu, J.F., Peng, X.F., Bourouga, B.: Nucleate boiling modes of subcooled water on fine wires submerged in a pool. Exp. Heat Tran. 19, 95–111 (2006)
Lu, J.F., Peng, X.F.: Bubble jet flow formation during boiling of subcooled water on fine wires. Int. J. Heat and Mass Tran. 50, 3966–3976 (2007)
Munro, T.R., Koeln, J.P., Fassmann, A.W., Barnett, R.J., Ban, H.: Phase change heat transfer and bubble behavior observed on twisted wire heater geometries in microgravity. Int. J. Heat and Fluid Flow 47, 21–30 (2014)
Peng, X.F., Wang, Z., Lee, D.J.: Dynamic behavior of vapor interface during nucleate boiling,”. J. Chin. Inst. Chem. Engrs. 35, 467–475 (2004)
Peng, X.: Micro Transport Phenomena during Boiling. first ed., pp. 60-91, Chap. 4. Tsinghua University Press, Beijing. Springer, Heidelberg (2011)
Petrovic, S., Robinson, T., Judd, R.L.: Marangoni heat transfer in subcooled nucleate pool boiling. Int. J. Heat and Mass Tran. 47, 5115–5128 (2004)
Ryu, Y., Chang, K.A., Lim, H.J.: Use of bubble image velocimetry for measurement of plunging wave impinging on structure and associated greenwater, meas. Sci. Tech. 16, 1945–1953 (2005)
Shekriladze, I.G.: On the mechanism of nucleate boiling. Bulletin Acad. Sci. Georgian SSR 41, 392–396 (1966). (English version: Technical Report NASA TM X-59398, 9967, pp. 1–10)
Shekriladze, I.G.: On the role of the “pumping effect” of a vapor bubble growing at the wall during nucleate boiling. In: Ratiani, V.G (ed.) Problems of Convective Heat Transfer and Steam Purity, pp 90–97. Metsniereba Press, Tbilisi (1970)
Shekriladze, I.G.: Comment on the paper by H. Wang, X.F. Peng, B.X. Wang, and D. J. Lee “Jet flow phenomena during nucleate boiling’ IJHMT 45 (6) (2002) 1359-1363,” Int. J. of Heat and Mass Tran. 46, 2711–2712 (2003)
Shekriladze, I.G.: Discussion: “Dynamics of bubble motion and bubble top jet flows from moving vapor bubbles on microwires”. J. of Heat Tran. 128, 1343–1344 (2006). (Christopher, D.M., Wang, H., and Peng, X., 2005, Journal of Heat Transfer, 127, 1260-1268)
Straub, J.: Microscale boiling heat transfer under 0g and 1g conditions. Int. J. Thermal Science 39, 490–497 (2000)
Straub, J.: Origin and effect of thermocapillary convection in subcooled boiling: observations and conclusions from experiments performed at microgravity. Ann. N. Y. Acad. Sci. 974, 348–363 (2002)
Wang, H., Peng, X.F., Wang, B.X., Lee, D.J.: Jet flow phenomena during nucleate boiling. Int. J. Heat and Mass Tran. 45, 1359–1363 (2002)
Wang, H., Peng, X.F., Wang, B.X., Lee, D.J.: Bubble sweeping and jet flows during nucleate boiling of subcooled liquids. Int. J. Heat and Mass Tran. 46, 863–869 (2003)
Wang, H., Peng, X.F., Lin, W.K., Pan, C., Wang, B.X.: Bubble-top jet flow on microwires. Int. J. Heat and Mass Tran. 47, 2891–2900 (2004)
Wang, H., Peng, X.F., Christopher, D.M., Lin, W.K., Pan, C.: Investigation of bubble-top jet flow during subcooled boiling on wires. Int. J. Heat and Fluid Flow 26, 485–494 (2005)
Wang, H., Peng, X.F., Christopher, D.M.: Dynamic bubble behavior during microscale subcooled boiling. Chinese Phys. Lett. 22, 2881–2884 (2005)
Whitaker, S.: Forced convection heat transfer correlations for flow in pipes, past flat plates, single cylinders, single spheres, and for flow in packed beds and tube bundles. AIChE J. 18, 361–371 (1972)
Zhukov, S.A., Afanas’ev, S.Y., Echmaev, S.B.: Concerning the magnitude of the maximum heat flux and the mechanisms of superintensive bubble boiling. Int. J. Heat and Mass Tran. 26, 3411–3427 (2003)
Acknowledgments
This work received support from the NASA Reduced Gravity Student Flight Opportunities Program, and the Rocky Mountain NASA Space Grant Consortium. The author would like to acknowledge the Experimental Fluid Dynamics Laboratory at Utah State University for PIV analysis and the GAS team at Utah State University for experimental operation.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Munro, T.R., Ban, H. Flow and Heat Flux Behavior of Micro-bubble Jet Flows Observed in Thin, Twisted-Wire, Subcooled Boiling in Microgravity. Microgravity Sci. Technol. 27, 49–60 (2015). https://doi.org/10.1007/s12217-014-9409-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12217-014-9409-6