Skip to main content

A Novel Device Addressing Design Challenges for Passive Fluid Phase Separations Aboard Spacecraft

Abstract

Capillary solutions have long existed for the control of liquid inventories in spacecraft fluid systems such as liquid propellants, cryogens and thermal fluids for temperature control. Such large length scale, ‘low-gravity,’ capillary systems exploit container geometry and fluid properties—primarily wetting—to passively locate or transport fluids to desired positions for a variety of purposes. Such methods have only been confidently established if the wetting conditions are known and favorable. In this paper, several of the significant challenges for ‘capillary solutions’ to low-gravity multiphase fluids management aboard spacecraft are briefly reviewed in light of applications common to life support systems that emphasize the impact of the widely varying wetting properties typical of aqueous systems. A restrictive though no less typifying example of passive phase separation in a urine collection system is highlighted that identifies key design considerations potentially met by predominately capillary solutions. Sample results from novel scale model prototype testing aboard a NASA low-g aircraft are presented that support the various design considerations.

This is a preview of subscription content, access via your institution.

References

  1. Amarouchene, Y., Cristobal, G., Kellay, H.: Noncoalescing drops. Phys. Rev. Lett. 87(20), November (2001)

  2. Bach, G.A., Koch, D.L., Gopinath, A.: Coalescence and bouncing of small aerosol droplets. J. Fluid. Mech. 518, 157–185, November (2004)

    MATH  Article  Google Scholar 

  3. Barajas, A.M., Panton, R.L.: The effects of contact angle on two-phase flow in capillary tubes. Int. J. Multiph. Flow 19(2), 337–346 (1993)

    MATH  Article  Google Scholar 

  4. Best, F., Ellis, M.: Experimental and analytical results of a liquid-gas separator in microgravity. In: AIP Conference Proceedings, Space Technology and Applications International Forum, vol. 458, pp. 779–784, January 22 (1999)

  5. Blanchette, F., Bigioni, T.P.: Partial coalescence of drops at liquid interfaces. Nat. Phys. 2, 254 (2006)

    Article  Google Scholar 

  6. Chato, D.J., Martin, T.A.: Vented tank resupply experiment: flight test results. AIAA J Spacecraft Rockets 43(5), 1124–1130, September–October (2006)

    Article  Google Scholar 

  7. Concus, P., Finn, R.: Capillary surface in microgravity, in low-gravity fluid dynamics and transport phenomena. In: Progress in Astronautics and Aeronautics, vol. 130, pp. 183–204. AIAA, Washington (1990)

    Google Scholar 

  8. Gilet, T., Mulleners, K., Lecomte, J.P., Vandewalle, N., Dorbolo, S.: Critical parameters for the partial coalescence of a droplet. Phys. Rev. E 75(3), 036303, March (2007)

    Article  Google Scholar 

  9. Hamilton-Sundstrand: Hamilton Sundstrand System Solutions—Gas/Liquid Separation. Retrieved September 23, 2007, from: http://www.snds.com/ssi/ssi/SystemSolutions/gasliquidsep.html. (2003)

  10. Hasan, M.M., Balasubramaniam, R.: Thermocapillary migration of a large gas slug in a tube. J. Thermophys. Heat Transf. 3(1), 87–89, January (1989)

    Article  Google Scholar 

  11. Jaekle, D.E. Jr.: Propellant management device conceptual design and analysis: vanes. In: AIAA/SAE/ASME/ASEE 27th Joint Propulsion Conference, AIAA-91-2172, June 24–26, Sacramento, CA (1991)

  12. Jayawardena, S.S., Balakotaiah, V.: Flow pattern transition maps for microgravity two-phase flows. AIChE J. 43(6), 1637–1640, June (1997)

    Article  Google Scholar 

  13. Klatte, J., Haake, D., Weislogel, M.M., Dreyer, M.: A fast numerical procedure for steady capillary flow in open channel. J Acta Mechanica (2008, in press)

  14. Marchetta, J., Winter, A., Hochstein, J.: Simulation and prediction of realistic magnetic positive positioning for space based fluid management systems. In: AIAA-2004-1151, 42nd AIAA Aerospace Sciences Meeting and Exhibit, Reno, Nevada, January 5–8 (2004)

  15. Oeftering, R.C., Chato, D.J., Mann, A. III: Liquid propellant manipulated acoustically, research and technology. NASA/TM-2003-211990 (2002)

  16. Ozbolt, T.A.: US Lab Architecture Control Document, Vol. 7: Temperature and Humidity Control, Revision New, D683-14719-1-7, Boeing Defense and Space Group, Missile & Space Division, Huntsville, Alabama, December 20 (1996)

  17. Pettit, D.R.: Waves in a large free sphere of water on the International Space Station. Phys. Fluids. In: 22nd Annual Gallery of Fluid Motion, September, (2005). (see also http://exploration.grc.nasa.gov/balloon/blob.htm)

  18. Phillips, A.L., Fale, J.E., Gernert, N.J., Sarraf, D.B., Bienert, W.J.: Loop heat pipe qualification for high vibration and high-g environments. In: AIAA-1998-885, Aerospace Sciences Meeting and Exhibit, 36th, Reno, NV, January 12–15 (1998)

  19. Prins, M.W.J., Welters, W.J.J., Weekamp, J.W.: Fluid control in multichannel structures by electrocapillary pressure. Science 291(5502), 277–280, January 12 (2001)

    Article  Google Scholar 

  20. Rollins, J.R., Grove, R.K., Jaekle, D.E. Jr.: Twenty three years of surface tension propellant management system design, development, manufacture, test, and operation. In: AIAA/SAE/ASME/ASEE 21st Joint Propulsion Conference, AIAA-85-1199, Monterey, CA, July 8–10, (1985)

  21. Rongy, L., De Wit, A.: Steady marangoni flow traveling with chemical fronts. J. Chem. Phys. 124, 164705 (2006)

    Article  Google Scholar 

  22. Satterlee, H.M., Hollister, M.P.: Low-G liquid propellant behavior, engineers handbook. LMSC-A874831, NAS 9-5174, May (1967)

  23. Su, S.K., Lai, C.L.: Interfacial shear-stress effects on transient capillary wedge flow. Phys. Fluids. 16(6), 2033–2043 (2004)

    Article  Google Scholar 

  24. Tilton, D., Tilton, C.: Entrained droplet separator. US Pat. No. 5,314,529, May 24 (1994)

  25. Weislogel, M.M.: Survey of present and future challenges in low-g fluids transport processes. NASA contract report C-74461-N, TDA Research, Wheat Ridge, CO (2001)

  26. Weislogel, M.M.: Some analytical tools for fluids management in space: isothermal capillary flows along interior corners. Adv. Space Res. 32(2), 163–170 (2003)

    Article  Google Scholar 

  27. Weislogel, M.M., Collicott, S.H.: Capillary re-wetting of vaned containers: spacecraft tank rewetting following thrust resettling. AIAA J. 42(12), 2551–2607, December (2004)

    Article  Google Scholar 

  28. Weislogel, M.M., Lichter, S.: Capillary flow in interior corners. J. Fluid Mech. 373, 349–378, November (1998)

    MATH  Article  MathSciNet  Google Scholar 

  29. Weislogel, M.M., McQuillen, J.B.: Hydrodynamic dryout in two-phase flows: observations of low bond number systems, space technology and applications int. forum (STAIF-98). Albuquerque, NM, AIP Conf. Proc. 420(1), 413–421, January (1998)

    Article  Google Scholar 

  30. Weislogel, M.M., Weir, T., Dreyer, M.: Capillary solutions: passive containment and transport for low-g fluids systems, Habitation 2006. Int. J. for Human Support Research 10(3/4), 244 February (2006)

    Google Scholar 

  31. Weislogel, M., Jenson, R., Klatte, J., Dreyer, M.: Interim results from the capillary flow experiment aboard ISS: the moving contact line boundary condition. AIAA-2007–747, 45th AIAA Aerospace Sci. Meeting and Exhibit, Reno, Nevada, January 8–11 (2007)

Download references

Author information

Affiliations

Authors

Corresponding author

Correspondence to M. M. Weislogel.

Rights and permissions

Reprints and Permissions

About this article

Cite this article

Weislogel, M.M., Thomas, E.A. & Graf, J.C. A Novel Device Addressing Design Challenges for Passive Fluid Phase Separations Aboard Spacecraft. Microgravity Sci. Technol 21, 257 (2009). https://doi.org/10.1007/s12217-008-9091-7

Download citation

Keywords

  • Capillary flow
  • Microgravity
  • Partial wetting
  • Capillary vane structures
  • Passive phase separations
  • Two-phase flow
  • Aqueous systems
  • Life support systems
  • Urine Processing