Abstract
The superior maneuverability of insect flight is enabled by rapid and significant changes in aerodynamic forces, a result of subtle and precise change of wing kinematics. The high sensitivity of aerodynamic force to wing kinematic change demands precise and instantaneous feedback control of the wing motion trajectory, especially in the presence of various parameter uncertainties and environmental disturbances. Current work on flapping wing robots was limited to open-loop averaged wing kinematics control. Here we present instantaneous closed-loop wing trajectory tracking of a DC motor direct driven wing-thorax system under resonant flapping. A dynamic model with parameter uncertainties and disturbances was developed and validated through system identification. For wing trajectory generation, we designed a Hopf oscillator based central pattern generator with smooth convergence. Using the linearized model while treating the nonlinearity as disturbance, we designed a proportional-integral-derivative (PID) controller and a linear quadratic regulator (LQR) for instantaneous wing trajectory tracking at 24 Hz; Using the original nonlinear model, we designed a nonlinear controller to achieve robust performance at over 30 Hz. The control algorithms were implemented and compared experimentally on a 7.5 g Flapping Wing Micro Air Vehicle (MAV). The experiments showed that the PID and nonlinear controls resulted in precise trajectory tracking; while LQR controller tracked with less precision but with smaller input effort. In addition, the nonlinear control algorithm achieved better tracking of wing trajectories with varying amplitude, bias, frequency, and split-cycles while adapting to the variations on wing morphological parameters such as wing geometry and stiffness. Furthermore, the lift force measurements of the nonlinear control results were compared with those of open-loop average wing kinematics control commonly adopted in current designs.
Similar content being viewed by others
References
Dickinson MH, Lehmann FO, Sane SP (1999) Science 284(5422):1954
Bergou AJ, Ristroph L, Guckenheimer J, Cohen I, Wang Z J (2010) Phys Rev Lett 104(14):148101
Hedrick TL, Cheng B, Deng X (2009) Science 324(5924):252
Wilson DM (1961) J Exp Biol 38(47):l
Cheng B, Deng X, Hedrick TL (2011) J Exp Biol 214(24):4092
Hines L, Campolo D, Sitti M (2014) IEEE Trans Robot 30(1):220
Baek SS, Ma KY, Fearing RS (2009) In: IEEE/RSJ international conference on intelligent robots and systems, 2009. IROS 2009. IEEE, pp 2854–2860
Keennon M, Klingebiel K, Won H, Andriukov A (2012) In: AIAA aerospace sciences meeting
De Croon G, Groen M, De Wagter C, Remes B, Ruijsink R, Van Oudheusden B (2012) Bioinspir Biomim 7(2):025003
Lau G-K, Chin Y-W, Goh JT-W, Wood RJ (2014) Dipteraninsect-inspired thoracic mechanism with nonlinear stiffness to save inertial power of flapping-wing flight. IEEE Trans Robot 30(5):1187–1197
Wood R J (2008) IEEE Trans Robot 24(2):341
Arabagi V, Hines L, Sitti M (2012) Int J Robot Res 0278364911434368
Ma KY, Chirarattananon P, Fuller SB, Wood RJ (2013) Science 340(6132):603
Pérez-Arancibia NO, Whitney JP, Wood RJ (2013) IEEE/ASME Trans Mechatron 18(1):155
Chirarattananon P, Pérez-Arancibia NO, Wood RJ (2012) In: American control conference (ACC), 2012. IEEE, pp 3831–3838
Zhang J, Cheng B, Roll J A, Deng X, Yao B (2013) In: 2013 IEEE international conference on robotics and automation (ICRA), pp 4029–4034
Azhar M, Campolo D, Lau G K, Hines L, Sitti M (2013) In: 2013 IEEE international conference on robotics and automation (ICRA). IEEE, pp 1397–1402
Zhang J, Cheng B, Yao B, Deng X (2015) In: 2015 IEEE international conference on robotics and automation (ICRA). IEEE, pp 5852–5857
Greenewalt C H (1960) Proc Am Philos Soc 605–611
Bergou AJ, Xu S, Wang Z (2007) J Fluid Mech 591:321
Khan Z, Steelman K, Agrawal S (2009) In: IEEE international conference on robotics and automation, 2009. ICRA’09. IEEE, pp 3651–3656
Phan HV, Nguyen QV, Truong QT, Van Truong T, Park HC, Goo NS, Byun D, Kim MJ (2012) J Bionic Eng 9(4):391
Finio BM, Pérez-Arancibia NO, Wood RJ (2011) In: 2011 IEEE/RSJ international conference on intelligent robots and systems (IROS). IEEE, pp 1107–1114
Whitney J, Wood R (2012) Bioinspir Biomim 7(3):036001
Ellington C (1984) Philos Trans R Soc Lond B Biol Sci 305(1122):1
Ljung L (1987) System identification: theory for the user, vol 198. PTR Prentice Hall Information and System Sciences Series
Cheng B, Deng X (2011) IEEE Trans Robot 27(5):849
Doman DB, Oppenheimer MW, Sigthorsson DO (2010) 48th AIAA aerospace sciences meeting including the new horizons forum and aerospace exposition 1024
Goodwin GC, Graebe SF, Salgado ME (2001) Control system design, vol 240. Prentice Hall, New Jersey
Yao B, Jiang C (2010) In: 2010 11th IEEE international workshop on advanced motion control. IEEE, pp 815–829
Hedrick TL (2008) Bioinspir Biomim 3(3):034001
Seo K, Chung SJ, Slotine JJE (2010) Auton Robot 28(3):247
Author information
Authors and Affiliations
Corresponding author
Additional information
Research supported by Air Force Research Lab (AFRL) under Grant 105758
Rights and permissions
About this article
Cite this article
Zhang, J., Cheng, B. & Deng, X. Instantaneous wing kinematics tracking and force control of a high-frequency flapping wing insect MAV. J Micro-Bio Robot 11, 67–84 (2016). https://doi.org/10.1007/s12213-015-0085-4
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12213-015-0085-4