Skip to main content
Log in

Computational study on wind turbine airfoils based on active control for deformable flaps

  • Published:
Journal of Mechanical Science and Technology Aims and scope Submit manuscript

Abstract

This study numerically investigates the aerodynamic performance of Deformable trailing edge flaps (DTEFs) to reduce the fatigue and ultimate loads of wind turbine blades. A parametric design is adopted to ensure the flexible deformation of the DTEFs. Based on experimental data, a simulation of a baseline airfoil is performed with two methods: A fully coupled viscous/inviscid method employed by the XFOIL program and a Reynolds-averaged Navier–Stokes solver with a Transition SST (T-SST) turbulence model. The static and dynamic performances of DTEFs are then investigated under different flow conditions by using T-SST and maximizing its numerous advantages. Results indicate that under steady conditions, the effects of flap deflection on the integral forces and flow field structures of airfoils vary from attached flow conditions to separated conditions. The gaps between unsteady aerodynamic responses and static values are greater in attached flow and light stall conditions than in deep stall conditions. The ability of DTEFs to control the fatigue loads on wind turbine blades is verified. Specifically, DTEFs effectively alleviate the force fluctuations on blades under gust-induced swinging when wind speed measurements are considered.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Power-technology.com, The world's 10 biggest wind turbines, Features (2014).

  2. P. S. Veers, Trends in the design, manufacture and evaluation of wind turbine blades, Wind Energy, 6 (3) (2003) 245–259.

    Article  Google Scholar 

  3. S. J. Johnson, C. P. Case van Dam and D. E. Berg, Active load control techniques for wind turbines, Sandia National Laboratories, California, USA (2008).

    Google Scholar 

  4. M. M. Munk, General theory of thin wing sections, National Advisory Committee for Aeronutics, Report no. 142 (1922).

    Google Scholar 

  5. T. K. Barlas and G. A. M. Van Kuik, Trol Research for Wind Turbines, Progress in Aerospace Sciences, 46 (1) (2010) 1–27.

    Article  Google Scholar 

  6. D. Berg et al., System ID modern control algorithms for active aerodynamic load control and impact on gearbox loading, The Science of Making Toruqe From Wind, Crete, Greece (2010).

    Google Scholar 

  7. T. K. Barlas and G. A. M. Van Kuik, State of the art and prospectives of smart rotor control for wind turbines, The Science of Making Torque from Wind, Delft, NL (2007).

    Google Scholar 

  8. M. A. Lackner and G. Van Kuik, A comparison of smart rotor for control approaches using tailing edge flaps and individual pitch control, Wind Energy, 13 (2/3) (2010) 117–134.

    Article  Google Scholar 

  9. P. B. Andersen, Advanced load alleviation for wind turbines using adaptive trailing edge flaps: Sensoring and control, Technical University of Denmark, Roskilde, Denmark (2010).

    Google Scholar 

  10. W. Yu, M. M. Zhang and J. Z. Xu, Effect of smart rotor control using a deformable trailing edge flap on load reduction under normal and extreme turbulence, Energies, 5 (9) (2012) 3608–3626.

    Article  Google Scholar 

  11. L. Bergami, V. A. Riziotis and M. Gaunaa, Aerodynamic response of an airfoil section undergoing pitch motion and trailing edge flap deflection: A comparison of simulation methods, Wind Energy, 18 (7) (2015) 1273–1290.

    Article  Google Scholar 

  12. N. Troldborg, Computational study of the Risk-B1-18 airfoil with a hinged flap providing variable nailing edge geometry, Wind Engineering, 29 (2) (2005) 89–113.

    Article  Google Scholar 

  13. M. A. Lackner and G. A. M. Van Kuik, The performance of wind turbine smart rotor control approaches during exteme loads, J. Sol. Energy Eng. Trans-ASME, 132 (1) (2010) 1–8.

    Article  Google Scholar 

  14. D. M. Somers, Design and experimental results for the S809 airfoil, National Renewable Energy Laboratory, Golden CO, USA (1997).

    Google Scholar 

  15. M. Drela, An analysis and design system for low Reynolds number airfoil aerodynamics, Conference on Low Reynolds Number Airfoil Aerodynamics, University of Notre Dame, Indiana, USA (1989).

    Google Scholar 

  16. F. R. Menter, Two-equation eddy-viscosity turbulence models for engineering applications, Aiaa J., 32 (8) (1994) 1598–605.

    Article  Google Scholar 

  17. T. Burton, D. Sharpe and N. Jenkins, Wind energy handbook, John Wiley & Sons, New York, USA (2001).

    Book  Google Scholar 

Download references

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Zhou Ye.

Additional information

Recommended by Associate Editor Cheolung Cheong

Wenxing Hao is a Ph.D. candidate in the University of Shanghai for Science and Technology. His research area is wind turbine aerodynamics.

Zhou Ye is a Ph.D. Associate Professor in the University of Shanghai for Science and Technology. His research fields include the flow control of fluid machinery.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Hao, W., Li, C., Ye, Z. et al. Computational study on wind turbine airfoils based on active control for deformable flaps. J Mech Sci Technol 31, 565–575 (2017). https://doi.org/10.1007/s12206-017-0109-1

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s12206-017-0109-1

Keywords

Navigation