Abstract
This paper examines the evolution process of the freezing curtain and the transition process of unfrozen water in an Artificial Ground Freezing (AGF) project used for a cross-passage tunnel in the Suzhou Metro, China. The focus of this study was on confirmation of the rationality of the freezing design on a weak silty clay layer, using a prognosis of the temperature development by numerical simulation and field monitoring. For the above purposes, basic mathematical techniques were employed to address the nonlinear transient thermal conduction problem considering the release of latent heat. The comparison analysis of the temperatures gained by field testing versus numerical simulation was performed to verify the accuracy of the numerical model. The results indicated that the formation of a stable freezing curtain with the design thickness required more time than the estimated active freezing period. The variation of unfrozen water volumetric content within the frozen fringe is normally exhibited as a process of increase and then decline until it vanishes, whereas there was a gradual and continuous increase near the frozen fringe. Although there was a deviation in the results between field monitoring and the numerical simulation, the general temperature curves from both methods were essentially consistent.
Similar content being viewed by others
References
Batenipour, H., Alfaro, M., Kurz, D., and Graham, J. (2014). “Deformations and ground temperatures at a road embankment in northern Canada.” Canadian Geotechnical Journal, Vol. 51, No. 3, pp. 260–271, DOI: 10.1139/cgj-2012-0425.
Chapin, J., Pernia, J., and Kjartanson, B. (2009). “An approach to applying spring thaw load restrictions for low volume roads based on thermal numerical modelling,” Conference on Cold Regions Engineering, pp. 496–505, DOI: 10.1061/41072(359)48.
China National Coal Construction Association (2011). “Coal mine technical specification for vertical shaft sinking by freezing method (MT/T 1124-2011).” China Coal Industry Publishing Home.
CAREERI, CAS (Cold and Arid Regions Environmental and Engineering Research Institute, Chinese Academy of Sciences) (2009). The test report of frozen soil of the cross-passage between the Xinggangjie Station and the Exhibition Center Station in Suzhou Metro No.1 Line, China.
Comini, G., Giudice, S. D., Lewis, R. W., and Zienkiewicz, O. C. (1974). “Finite element solution of non-linear heat conduction problems with special reference to phase change.” International Journal for Numerical Methods in Engineering, Vol. 8, No. 3, pp. 613–624, DOI: 10.1002/nme.1620080314.
Cui, Z. D., He, P. P., and Yang, W. H. (2014). “Mechanical properties of a silty clay subjected to freezing–thawing.” Cold Regions Science and Technology, Vol. 98, pp. 26–34, DOI: 10.1016/j.coldregions.2013.10.009.
Gens, A., Nishimura, S., Jardine, R. J., and Olivella, S. (2009). “THMcoupled finite element analysis of frozen soil:formulation and application,” Géotechnique, Vol. 59, No. 3, pp. 159–171, DOI: 10.1680/geot.2009.59.3.159.
GEO-SLOPE International Ltd. (2002). TEMP/W user’s guide for finite element geothermal analysis, Canada, GEO-SLOPE International Ltd.
Giudice, S. D., Comini, G., and Lewis, R. W. (1978). “Finite element simulation of freezing processes in soils.” International Journal for Numerical and Analytical Methods in Geomechanics, Vol. 2, No. 3, pp. 223–235, DOI: 10.1002/nag.1610020304.
Han, L., Guanlin, Y. E., Yuan-Hai, L. I., Xiao-he, X., and Jian-hua, W. (2015). “In-situ monitoring of frost heave pressure during cross passage construction using ground freezing method.” Canadian Geotechnical Journal, Vol. 53, No. 3, pp. 530–539, DOI: 10.1139/cgj-2014-0486.
Hu, X. and Zhao, F. (2009). “Artificial ground freezing in cross passage construction in the Shanghai Yangtze river tunnel.” Recent Development of Research on Permafrost Engineering and Cold Region Environment—Proceedings of the Eighth International Symposium on Permafrost Engineering, pp. 174–180, DOI: 10.13140/RG.2.1.3360.7521.
Jessberger, H. L. and Makowski, E. (1981). “Optimization of the freeze pipe arrangement and the necessary refrigeration plant capacity by a femcomputer program.” Engineering Geology, Vol. 18, Issues 1-4, pp. 175–188. DOI: 10.1016/0013-7952(81)90057-0.
Jones, J. S. and Brown, R. E. (1979). “Design of tunnel support systems using ground freezing.” Engineering Geology, Vol. 13, No. 1, pp. 375–395, DOI: 10.1016/0013-7952(79)90044-9.
Li, S., Lai, Y., Zhang, M., and Zhang, S. (2006). “Minimum ground prefreezing time before excavation of Guangzhou subway tunnel.” Cold Regions Science and Technology, Vol. 46, Issues 3, pp. 181–191, DOI: 10.1016/j.coldregions.2006.09.001.
Liu, Z. and Yu, X. (2011). “Coupled thermo-hydro-mechanical model for porous materials under frost action: Theory and implementation.” Acta Geotech, Vol. 6, No. 2, pp. 51–65, DOI: 10.1007/s11440-011-0135-6.
Ming, Z., Lingmin, W., Baowen, W., and Hongbao, L. (2011). “Horizontal freezing study for cross passage of river-crossing tunnel.” Sciences in Cold and Arid Regions, Vol. 3, No. 4, pp. 314–318, DOI: 10.3724/SP.J.1226.2011. 00314.
Miyoshi, M., Tsukamoto, T., and Kiriyama, S. (1979). “Large-scale freezing work for subway construction in Japan.” Engineering Geology, Vol. 13, Issues 1-4, pp. 397–415, DOI: 10.1016/0013-7952(79)90045-0.
Morgan, K., Lewis, R. W., and Zienkiewicz, O. C. (1978). “An improved algorithm for heat conduction problems with phase change.” International Journal for Numerical Methods in Engineering, Vol. 12, No. 7, pp.1191–1195. DOI: 10.1002/nme.1620120710.
Neaupane, K. M., Yamabe, T., and Yoshinaka, R. (1999). “Simulation of a fully coupled thermo-hydro-mechanical system in freezing and thawing rock.” International Journal of Rock Mechanics and Mining Sciences, Vol. 36, No. 5, pp. 563–580, DOI: 10.1016/S0148-9062 (99)00026-1.
Neaupanea, K. M. and Yamabeb, T. (2001). “A fully coupled thermohydro-mechanical nonlinear model for a frozen medium.” Computers and Geotechnics, Vol. 28, No. 8, pp. 613–637, DOI: 10.1016/S0266-352X(01)00015-5.
Papakonstantinou, S., Pimentel, E., and Anagnostou, G., (2013). “Evaluation of ground freezing data from the Naples Subway.” Proceedings of the Institution of Civil Engineers, Vol. 166, No. 3, pp. 280–298, DOI: 10.1680/geng.10.00099.
Pimentel, E., Papakonstantinou, S., and Anagnostou, G. (2012). “Numerical interpretation of temperature distributions from three ground freezing applications in urban tunneling.” Tunnelling and Underground Space Technology, Vol. 28, pp. 57–69, DOI: 10.1016/j.tust.2011.09.005.
Russo, G., Corbo, A., Cavuoto, F., and Autuori, S. (2015). “Artificial ground freezing to excavate a tunnel in sandy soil measurements and back analysis.” Tunnelling and Underground Space Technology, Vol. 50, pp. 226–238, DOI: 10.1016/j.tust.2015.07.008.
Shoop, S. A. and Bigl, S. R. (1997). “Moisture migration during freeze and thaw of unsaturated soils: Modeling and large scale experiments.” Cold Regions Science and Technology, Vol. 25, No. 1, pp. 33–45, DOI: 10.1016/S0165-232X (96)00015-8.
Vitel, M., Rouabhi, A., Tijani, M., and Guérin, F. (2015). “Modeling heat transfer between a freeze pipe and the surrounding ground during artificial ground freezing activities.” Computers & Geotechnics, Vol. 63, pp. 99–111, DOI: 10.1016/j.compgeo.2014.08.004.
Vyalov, S. S., Zaretsky, Y. K., and Gorodetsky, S. E. (1979). “Stability of mine workings in frozen soils,” Engineering Geology, Vol. 13, Issues 1-4, pp. 339–351, DOI: 10.1016/0013-7952(79)90041-3.
Wind, H. (1979), “The soil-freezing method for large tunnel constructions.” Engineering Geology, Vol. 13, Issues 1-4, pp. 417–423, DOI: 10.1016/0013-7952(79)90046-2.
Yang, P., Ke, J. M., Wang, J. G., Chow, Y. K., and Zhu, F. (2006). “Numerical simulation of frost heave with coupled water freezing, temperature and stress fields in tunnel excavation.” Computers & Geotechnics, Vol. 33, No. 6, pp. 330–340, DOI: 10.1016/j.compgeo.2006.07.006.
Zhao, X. and Zhou, G. (2013). “Experimental study on the creep behavior of frozen clay with thermal gradient.” Cold Regions Science and Technology, Vol. 86, pp. 127–132, DOI: 10.1016/j.coldregions.2012.10.012.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Yan, Q., Xu, Y., Yang, W. et al. Nonlinear Transient Analysis of Temperature Fields in an AGF Project used for a Cross-Passage Tunnel in the Suzhou Metro. KSCE J Civ Eng 22, 1473–1483 (2018). https://doi.org/10.1007/s12205-017-1118-4
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12205-017-1118-4