Skip to main content

Advertisement

SpringerLink
Log in

Numerical optimization of a transcritical CO 2 /propylene cascaded refrigeration-heat pump system with economizer in HT cycle

  • Published:
Sadhana Aims and scope Submit manuscript

Abstract

Use of organic refrigerants such as Hydrochlorofluorocarbons and Chlorofluorocarbons have been criticized for their adverse impact on the Earth’s protective ozone layer and for their significant global warming potential (GWP). CO2 has been receiving great concern as an alternative refrigerant. Cascade refrigeration systems employing CO2 are used for low temperature applications. Being a low critical temperature fluid CO2 transcritical cascade systems offer low COP for a given application. Parallel compression economization is one of the promising cycle modifications to improve the COP of transcritical CO2 cascaded systems. In this paper, transcritical CO2/propylene cascade system with parallel compression economization in the HT cycle has been analysed for cooling/heating applications. An enhancement in COP of 9% has been predicted. Thermodynamic analysis on R744-R1270 cascade refrigeration system has been performed to determine the optimal value of the various design parameters of the system. The design parameters included are: gas cooler outlet temperature and intermediate temperature in the high temperature circuit and evaporator temperature and temperature difference in the cascade condenser in the low temperature circuit.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Figure 1
Figure 2
Figure 3
Figure 4
Figure 5
Figure 6
Figure 7
Figure 8
Figure 9
Figure 10
Figure 11

Similar content being viewed by others

References

  • Baek J S, Groll E A and Lawless P B 2005 Piston–cylinder work producing expansion device in a carbon dioxide cycle. Part II: Theoretical investigation. Int. J. Refrig. 28: 152–64

  • Bhattacharyya S, Garai A and Sarkar J 2009 Thermodynamic analysis and optimization of a novel N2O–CO2 cascade system for refrigeration and heating. Int. J. Refrig. 32: 1077–84

  • Bhattacharyya S, Mukhopadhyay S, Kumar A, Khurana R K and Sarkar J 2005 Optimization of a CO2–C3H8 cascade system for refrigeration and heating. Int. J. Refrig. 28: 1284–92

  • Bingming W, Huagen W, Jianfeng L and Ziwen X 2009 Experimental investigation on the performance of NH3/CO2 cascade refrigeration system with twin-screw compressor. Int. J. Refrig. 32(135865)

  • Carolina C 2012 Energy Optimization for Transcritical CO 2 Heat Pumps for Combined Heating and Cooling and Thermal Storage Applications, International Refrigeration and Air Conditioning Conference, Paper 1168, Purdue, USA

  • Cecchinato L and Corradi M 2011 Transcritical carbon dioxide small commercial cooling applications analysis. Int. J. Refrigeration 34(1): 50–62

  • Cho H, Ryu C, Kim Y and Kim H Y 2005 Effects of refrigerant charge amount on the performance of a transcritical CO2 heat pump. Int. J. Refrig. 28: 1266–73

  • Dopazo J A and Seara J F 2011 Experimental evaluation of a cascade refrigeration system prototype with CO2 and NH3 for freezing process applications. Int. J. Refrig. 34: 257–267

  • Dopazo J A, Seara J F, Sieres J and Uhía F J 2009 Theoretical analysis of a CO2–NH3 cascade refrigeration system for cooling applications at low temperatures. Appl. Therm. Eng. 29: 1577–83

  • Getu H M and Bansal P K 2008 Thermodynamic analysis of an R744–R717 cascade refrigeration system. Int. J. Refrig. 31: 45–54

  • Groll E A, Baek J S and Lawless P B 2002 Effect of pressure ratios across compressors on the performance of the transcritical CO2 cycle with two-stage compression and intercooling. Proceedings of compressor engineering conference, Purdue. USA: 11–7

  • Gu J and Chen Y 2005 The optimum high pressure for CO2 transcritical refrigeration systems with internal heat exchangers. Int. J. Refrigeration 28: 1238–1249

  • Kim M, Pettersen J and Bullard C W 2004 Fundamental process and system design issues in CO2 vapor compression systems. Prog. Energy Combust. Sci. 30: 119–74

  • Kim S G and Kim M S 2002 Experiment and simulation on the performance of an autocascade refrigeration system using carbon dioxide as a refrigerant. Int. J. Refrig. 25: 1093–101

  • Kruse H and Russmann H 2006 The natural fluid nitrous oxide –an option as substitute for low temperature synthetic refrigerants. Int. J. Refrig. 29(5): 799–806

  • Lee T S, Liu C H and Chen T W 2006 Thermodynamic analysis of optimal condensing temperature of cascade-condenser in CO2/NH3 cascade refrigeration systems. Int. J. Refrig. 29: 1100–1108

  • Li D and Groll E A 2005 Transcritical CO2 refrigeration cycle with ejector-expansion device. Int. J. Refrig. 28: 766–73

  • Ma Y T, Ning J H, Chen Q and Ma L R 2005 Study on replacement and energy-saving of natural refrigerant CO2/NH3 cascade refrigeration cycle Proceedings of the International Conference on Compressor and Refrigeration, Dalian, China

  • Refrigerant Reference Guide, Fourth Edition, National Refrigerants, Inc.

  • Rivera W, Colorado D and Hernández J A 2011 Comparative study of a cascade cycle for simultaneous refrigeration and heating operating with ammonia, R134a, butane, propane, and CO2 as working fluids. Int. J. Sustainable Energy 31(6): 365–381

  • Robinson D M and Groll E A 1998 Efficiencies of transcritical CO2 cycles with and without an expansion turbine. Int. J. Refrig. 21(7): 577–89

  • Sarkar J, Bhattacharyya S and Ramgopal M 2004 Carbon dioxide based cascade systems for simultaneous refrigeration and heating applications. Proceedings of 6th IIR-Gustav Lorentzen natural working fluid conference, Galsgow 2004

  • Sarkar J and Agrawal N 2010 Performance optimization of transcritical CO2 cycle with parallel compression economization. Int. J. Thermal Sci. 49: 838–843

  • Sarkar J 2009 A transcritical CO2 heat pump for simultaneous water cooling and heating: Test results and model validation. Int. J. Energy Research 33(1): 100–109

  • Wang S, He Y, Tuo H, Cao F and Xing Z 2013a Effect of heat transfer area and refrigerant mass flux in a gas cooler on heating performance of air-source transcritical CO2 heat pump water heater system. Energy and Buildings 67: 1–10

  • Wang S, Tuo H, Cao F and Xing Z 2013b Experimental investigation on air-source transcritical CO2 heat pump water heater system at a fixed water inlet temperature. Int. J. Refrigeration 36(3): 701–716

  • Yari M and Mahmoudi S M S 2011 Thermodynamic analysis and optimization of novel ejector-expansion TRCC (transcritical CO2) cascade refrigeration cycles (Novel transcritical CO2 cycle). Energy 36(12): 6839–6850

  • Yu J, Ma M, Yu J and Wang X 2014 Performance evaluation and optimal configuration analysis of a CO2/NH3 cascade refrigeration system with falling film evaporator–condenser. Energy Conversion and Management 79: 224–231

  • Zhang X P, Fan X W, Wang F K and Shen H G 2010 Theoretical and experimental studies on optimum heat rejection pressure for a CO2 heat pump system. Appl. Thermal Eng. 30(16): 2537–2544

Download references

Author information

Authors and Affiliations

  1. Department of Mechanical Engineering, Malviya National Institute of Technology, Jaipur, 302 017, India

    ALOK MANAS DUBEY & GHANSHYAM DAS AGRAWAL

  2. Department of Mechanical Engineering, University of Petroleum & Energy Studies, Dehradun, 248 007, India

    SURESH KUMAR

Authors
  1. ALOK MANAS DUBEY
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. SURESH KUMAR
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. GHANSHYAM DAS AGRAWAL
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to ALOK MANAS DUBEY.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

DUBEY, A.M., KUMAR, S. & AGRAWAL, G.D. Numerical optimization of a transcritical CO 2 /propylene cascaded refrigeration-heat pump system with economizer in HT cycle. Sadhana 40, 437–454 (2015). https://doi.org/10.1007/s12046-014-0319-5

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s12046-014-0319-5

Keywords

Search

Navigation