Abstract
Whereas a myriad of possible factors have been reported which effect the formation of granules in a upflow anaerobic sludge blanket (UASB) reactor and influence their properties, there is no study on the effect of vitamins on the granulation of UASB reactor sludge. The present study was undertaken to bridge this gap. It was seen that vitamins helped in better granule formation—as reflected by favorable size distribution, sludge volume index, and settling velocity—compared to controls. The vitamin-spiked reactors also achieved >85 % COD removal efficiency in half the number of days the unspiked reactors took. The vitamin supplements were effective at concentrations ≤ 1 mg/l. Hence, their use in expediting granule formation as also in developing better-quality granules appears economically viable.
Similar content being viewed by others
References
Abbasi, T., & Abbasi, S. A. (2010). Production of clean energy by anaerobic digestion of phytomass-New prospects, for a global warming amelioration technology. Renewable and Sustainable Energy Reviews, 14(6), 1653–1659.
Abbasi, T., & Abbasi, S. A. (2012a). Formation and impact of granules during wastewater treatment with upflow anaerobic sludge blanket (UASB) reactor. Renewable and Sustainable Energy Reviews, 16, 1696–1708.
Abbasi, T., & Abbasi, S. A. (2012b). Anaerobic digestion for global warming control and energy generation-An overview. Renewable and Sustainable Energy Reviews, 16(5), 3228–3242.
Gomec, C. Y. (2010). High-rate anaerobic treatment of domestic wastewater at ambient operating temperatures: a review on benefits and drawbacks. Journal of Environmental Science and Health-Part A Toxic/Hazardous Substances and Environmental Engineering, 45(10), 1169–1184.
O’Flaherty, V. (2006). The microbiology and biochemistry of anaerobic bioreactors with relevance to domestic sewage treatment. Reviews in Environmental Science and Bio/Technology, 5(1), 39–55.
Ramasamy, E. V., Gajalakshmi, S., Sanjeevi, R., Jithesh, M. N., & Abbasi, S. A. (2004). Feasibility studies on the treatment of dairy wastewaters with upflow anaerobic sludge blanket reactors. Bioresource Technology, 93(2), 209–212.
Liu, Y., Xu, H. L., Yang, S. F., & Tay, J. H. (2003). Mechanisms and models for anaerobic granulation in Upflow anaerobic sludge blanket reactor. Water Research, 37(3), 661–673.
Tiwari, M. K., Guha, S., Harendranath, C. S., & Tripathi, S. (2006). Influence of extrinsic factors on granulation in UASB reactor. Applied Microbiology and Biotechnology, 71(2), 145–154.
Bujoczek, G., Oleszkiewicz, J. A., Danesh, S., & Sparling, R. R. (2002). Co-processing of organic fraction of municipal solid waste and primary sludge-Stabilization and disinfection. Environmental Technology, 23(2), 227–241.
Zhang, Z., Quan, T., Li, P., Zhang, Y., Sugiura, N., & Maekawa, T. (2004). Study on methane fermentation and production of vitamin B12 from alcohol waste slurry. Applied Biochemistry and Biotechnology-Part A Enzyme Engineering and Biotechnology, 115(40238), 1033–1039.
Taconi, K.A. (2004). Methanogenic generation of biogas from synthesis-gas fermentation wastewaters. PhD (Chemical Engineering) thesis, Mississippi State University, USA.
Guerrero-Barajas, C., & Field, J. A. (2005). Riboflavin- and cobalamin-mediated biodegradation of chloroform in a methanogenic consortium. Biotechnology and Bioengineering, 89(5), 539–550.
Mendoza, L., Carballa, M., Sitorus, B., Pieters, J., & Verstraete, W. (2009). Technical and economic feasibility of gradual concentric chambers reactor for sewage treatment in developing countries. Electronic Journal of Biotechnology, 12(2), 1–13.
Fermoso, F. G., Bartacek, J., & Lens, P. N. L. (2010). Effect of vitamin B12 pulse addition on the performance of cobalt deprived anaerobic granular sludge bioreactors. Bioresource Technology, 101(14), 5201–5205.
Mohan, S. V., Srikanth, S., Dinakar, P., & Sarma, P. N. (2008). Photo-biological hydrogen production by the adopted mixed culture: data enveloping analysis. International Journal of Hydrogen Energy, 33(2), 559–569.
Srikanth, S., Mohan, S. V., & Sarma, P. N. (2010). Positive anodic poised potential regulates microbial fuel cell performance with the function of open and closed circuitry. Bioresource Technology, 101(14), 5337–5344.
Shi, R., Xu, H., & Zhang, Y. (2011). Enhanced treatment of wastewater from the vitamin C biosynthesis industry using a UASB reactor supplemented with zero-valent iron. Environmental Technology, 32(16), 1859–1865.
Shi, R., Zhang, Y., Yang, W., & Xu, H. (2012). Microbial community characterization of an UASB treating increased organic loading rates of vitamin C biosynthesis wastewater. Water Science and Technology, 65(2), 254–261.
APHA (2005). Standard Methods for the Examination of Water and Waste Water, American Public Health Association, Washington DC.
Ramasamy, E. V., & Abbasi, S. A. (2000). High-solids anaerobic digestion for the recovery of energy from municipal solid waste (MSW). Environmental Technology, 21(3), 345–349.
Ramasamy, E. V., & Abbasi, S. A. (2001). Enhancement in the treatment efficiency and conversion to energy of dairy wastewaters by augmenting CST reactors with simple biofilm support systems. Environmental Technology, 22(5), 561–565.
Abbasi, S. A., Nipaney, P. C., & Schaumberg, G. D. (1990). Bioenergy potential of eight common aquatic weeds. Biological Wastes, 34(4), 359–366.
Sankar Ganesh, P., Ramasamy, E. V., Gajalakshmi, S., & Abbasi, S. A. (2005). Extraction of volatile fatty acids (VFAs) from water hyacinth using inexpensive contraptions, and the use of the VFAs as feed supplement in conventional biogas digesters with concomitant final disposal of water hyacinth as vermicompost. Biochemical Engineering Journal, 27(1), 17–23
Sankar Ganesh, P., Sanjeevi, R., Gajalakshmi, S., Ramasamy, E. V., & Abbasi, S. A. (2008). Recovery of methane-rich gas from solidfeed anaerobic digestion of ipomoea (Ipomoea carnea). Bioresource Technology, 99(4), 812–818.
Abbasi, S. A., & Nipaney, P. C. (1986). Infestation by aquatic weeds of the fern genus Salvinia: Its status and control. Environmental Conservation, 13(3), 235–241.
Abbasi, S. A., & Nipaney, P. C. (1994). Potential of aquatic weed Salvinia molesta (Mitchell) for water treatment and energy recovery. Indian Journal of Chemical Technology, 1(4), 204–213.
Abbasi, S. A., Nipaney, P. C. & Panholzer, M. B. (1991), Biogas production from the aquatic weed pistia (Pistia stratiotes). Bioresource Technology, 37(3), 211–214.
Li, X-M., Liu, Q-Q., Yang, Q., Guo, L., Zeng, G-M., Hu, J-M., & Zheng, W. (2009). Enhanced aerobic sludge granulation in sequencing batch reactor by Mg2+ augmentation. Bioresource Technology, 100, 64–67.
Sponza D. T. (2003). Enhancement of granule formation and sludge retainment for tetrachloroethylene (TCE) removal in an upflow anaerobic sludge blanket (UASB) reactor. Advances in Environmental Research, 7, 453–462.
Laguna, A., Ouattara, A., Gonzalez, R. O., Baron, O., Fama, G., El Mamouni, R., Guiot, S., Monroy, O., & Macarie, H. (1999). A simple and low cost technique for determining the granulometry of upflow anaerobic sludge blanket reactor sludge. Water Science and Technology, 40(8), 1–8.
Ghangrekar, M. M., Asolekar, S. R., & Joshi, S. G. (2005). Characteristics of sludge developed under different loading conditions during UASB reactor start-up and granulation. Water Research, 39(6), 1123–1133.
Ryan, T. (2007). Modern experimental design (p. 655). New Jersey: Wiley-Blackwell.
Schmidt, J. E., & Ahring, B. K. (1996). Granular sludge formation in upflow anaerobic sludge blanket (UASB) reactors. Biotechnology and Bioengineering, 49(3), 229–246.
Yan, Y.-G., & Tay, J.-H. (1997). Characterisation of the granulation process during UASB start-up. Water Research, 31(7), 1573–1580.
Acknowledgment
RS thanks the Council for Scientific and Industrial Research, New Delhi, for Research Associateship, and TA and SAA thank the Ministry of Water Resources, Government of India, for support in the form of an R&D project.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Abbasi, T., Sanjeevi, R., Makhija, M. et al. Role of Vitamins B-3 and C in the Fashioning of Granules in UASB Reactor Sludge. Appl Biochem Biotechnol 167, 348–357 (2012). https://doi.org/10.1007/s12010-012-9691-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12010-012-9691-y