Abstract
Bio-oil produced from biomass by fast pyrolysis has the potential to be a valuable substitute for fossil fuels. In a recent work on pinewood, we found that pretreatment alters the structure and chemical composition of biomass, which influence fast pyrolysis. In this study, we evaluated dilute acid, steam explosion, and size reduction pretreatments on sweetgum, switchgrass, and corn stover feedstocks. Bio-oils were produced from untreated and pretreated feedstocks in an auger reactor at 450 °C. The bio-oil’s physical properties of pH, water content, acid value, density, and viscosity were measured. The chemical characteristics of the bio-oils were determined by gas chromatography–mass spectrometry. The results showed that bio-oil yield and composition were influenced by the pretreatment method and feedstock type. Bio-oil yields of 52, 33, and 35 wt% were obtained from medium-sized (0.68–1.532 mm) untreated sweetgum, switchgrass, and corn stover, respectively, which were higher than the yields from other sizes. Bio-oil yields of 56, 46, and 51 wt% were obtained from 1 % H2SO4-treated medium-sized sweetgum, switchgrass, and corn stover, respectively, which were higher than the yields from untreated and steam explosion treatments.
Similar content being viewed by others
References
Agarwal, G. D., & Agarwal, A. K. (1999). TERI Information Monitor on Environmental Science, 4, 79–89.
Chum, H. L., & Overend, R. P. (2001). Fuel Processing Technology, 71, 187–195.
USDA (2005) Biomass as feedstock for a bioenergy and bioproducts industry: The Technical Feasibility of Billion-Ton Annual Supply, Technical Report, U.S. Department of Agricultural Forestry Service, April 2005.
Bridgwater, A. V., Meierb, D., & Radleinc, D. (1999). Organic Geochemistry, 30, 1479–1493.
Bridgwater, A. V., Czernik, S., & Piskorz, J. (2001). Progress in thermochemical biomass conversation (pp. 977–997). Oxford: Blackwell Science.
Bridgwater, A. V., Toft, A. J., & Brammer, J. G. (2002). Renewable Sustainable Energy Rev., 6, 181–246.
Pattiya, A., James, O. T., & Bridgwater A. V. (2006). The 2nd Joint International Conference on Sustainable Energy and Environment Technology and Policy innovations, Bangkok, Thailand, pp. 21–23.
Yang, Y., Sharma, S. R., Burns, J. C., & Cheng, J. (2009). Energy & Fuels, 23, 3759–3766.
Murwanashyaka, J. N., Pakdel, H., & Roy, C. (2001). Purification Technology, 24, 15–165.
Garcia-Perez, M., Chaala, A., & Roy, C. (2002). Journal of Analytical and Applied Pyrolysis, 65, 111–136.
Garcia-Perez, M., Chaala, A., & Roy, C. (2002). Journal of Analytical and Applied Pyrolysis, 81, 893–907.
Oasmaa, A., Kuoppala, E., Gust, S., & Solantausta, Y. (2003). Energy & Fuels, 17, 1–12.
Oasmaa, A., Kuoppala, E., & Solantausta, Y. (2003). Energy & Fuels, 17, 433–443.
Wang, H., Srinivasan, R., Yu, F., Steele P., Li Q., & Mitchell, B. (2011). Energy & Fuels, 25, 3758–3764.
Perlack, R., Wright, L., Turhollow, A., Graham, R., Stokes, B., & Erbach, D. (2005). U.S. Department of Energy Oak Ridge National Laboratory Report. 60 pp.
Martin, E., Duke, J., Pelkki, M., Clausen, E. C., & Carrier, D. J. (2010). Applied Biochemistry and Biotechnology, 162, 1660–1668.
Samuel, B. M., & Lynn, A. K. (2005). Biomass and Bioenergy, 28, 515–535.
John, S., Andy, A., Keith, P., Kendrick, K., John, B., Marie, W., & Richard, N. (2003). Journal of Industrial Ecology, 7, 117–146.
Sluiter, A., Hames, B., Ruiz, R., Scarlata, C., Sluiter, J., Templeton, D., et al. (2008). Determination of structural carbohydrates and lignin in biomass. Laboratory analytical procedure (LAP). National Renewable Energy Laboratory (NREL).
Sluiter, A., Hames, B., Ruiz, R., Scarlata, C., Sluiter, J., & Templeton, D. (2005). Determination of ash in biomass. Laboratory analytical procedure (LAP). National Renewable Energy Laboratory (NREL).
Ingram, L., Mohan, D., Steele, P., Strobel, D., Mitchell, B., Mohammad, J., & Cantrell, K. (2008). Energy & Fuels, 22, 614–625.
ASTM D1744-92. Standard test method for determination of water in liquid petroleum products by Karl Fischer reagent. ASTM International, West Conshohocken, PA (withdrawn 2000).
Hassan, M. E., Steele, P., & Ingram, L. (2009). Applied Biochemistry and Biotechnology, 154, 182–192.
ASTM D4052-11. Standard test method for density, relative density, and API gravity of liquids by digital density meter. ASTM International, West Conshohocken, PA, 2011, doi:10.1520/D4052-11.
Sensöz, S., Angin, D., & Yorgun, S. (2000). Biomass and Bioenergy, 19, 271–279.
Islam, M. N., Zailani, R., & Ani, F. N. (1999). Renewable Energy, 17, 73–84.
Bauer, W. F., Elias, G., Pryfogle, P. A., & Partin, J. K. (2008). 30th Symposium on Biotechnology for Fuels and Chemicals.
Yang, B., & Wyman, C. (2004). Biotechnology and Bioengineering, 86, 88–95.
Scott, D. S., Piskorz, J., & Radelein, D. (1985). Industrial and Engineering Chemistry Process Design and Development, 24, 581–588.
Scott, D. S., Paterson, L., Piskorz, J., & Radlein, D. J. (2001). Analytical and Applied Pyrolysis, 57, 169–176.
Alén, R., Kuoppala, E., & Oesch, P. (1996). Journal of Analytical and Applied Pyrolysis, 36, 137–148.
Acknowledgments
This work was partially funded by the Sustainable Energy Research Centre (SERC) and the Combined Heating and Power (CHP) funding of the Mississippi State University (MSU). The authors thank Aditya Samala, Graduate Research Assistant, Department of Agricultural and Biological Engineering, MSU, for HPLC analysis.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Wang, H., Srinivasan, R., Yu, F. et al. Effect of Acid, Steam Explosion, and Size Reduction Pretreatments on Bio-oil Production from Sweetgum, Switchgrass, and Corn Stover. Appl Biochem Biotechnol 167, 285–297 (2012). https://doi.org/10.1007/s12010-012-9678-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12010-012-9678-8