Abstract
In this paper, the evolution of microstructure and mechanical properties in the Fe-28Ni-20Co-11.5Al-2.5Ta-0.05B (at.%) alloy were systematically studied. The findings elucidate that the absence of thermoelastic martensitic transformation following cyclic loading signifies the lack of superelasticity in solid solution state. Subsequent to the 72 h aging process at 600°C, the emergence of small (4 ± 2 nm) Ni3Al precipitates with an L12 structure was observed within the grains. The degree of misfit between the precipitate and matrix was found to be only 0.28%. The precipitates contribute to the strength through ordering strengthening, ultimately increasing the strength of austenite. In the method this study introduces, there is neither a need for significant cold rolling deformation and prolonged annealing to form specific recrystallization texture nor preparation of large grain sized specimens equivalent to single crystals. The coherent relationship between the Ni3Al phase and matrix induces the occurrence of thermoelastic martensitic transformation, which results in a 1.3% superelasticity.
Similar content being viewed by others
Data availability
No data was used for the research described in the article.
References
J. Ma, B. Kockar, A. Evirgen, I. Karaman, Z. Luo, and Y. Chumlyakov, Acta Mater. 60, 2186–2195 https://doi.org/10.1016/j.actamat.2011.12.047 (2012).
C. Cisse, W. Zaki, and T.B. Zineb, Int. J. Plast. 76, 244–284 https://doi.org/10.1016/j.ijplas.2015.08.006 (2016).
L. Sun, W.M. Huang, Z. Ding, Y. Zhao, C.C. Wang, H. Purnawali, and C. Tang, Mater. Des. 33, 577–640 https://doi.org/10.1016/j.matdes.2011.04.065 (2012).
F. Masdeu, J. Pons, Y. Chumlyakov, and E. Cesari, Mater. Sci. Eng. A 805, 140543 https://doi.org/10.1016/j.msea.2020.140543 (2021).
J.M. Jani, M. Leary, A. Subic, and M.A. Gibson, Mater. Des. 1980–2015(56), 1078–1113 https://doi.org/10.1016/j.matdes.2013.11.084 (2014).
W. Zhang, S. Ao, J.P. Oliveira, Z. Zeng, Z. Luo, and Z. Hao, Smart Mater. Struct. 27, 085020 https://doi.org/10.1088/1361-665X/aacfeb (2018).
X. Wang, Y. Zhang, Z. Zhang, L. Liu, B. Wang, Y. Cui, I. Baker, and J. Cheng, Crit. Rev. Solid State Mater. Sci. https://doi.org/10.1080/10408436.2023.2175641 (2023).
K. Otsuka, C. Wayman, K. Nakai, H. Sakamoto, and K. Shimizu, Acta Metall. 24, 207–226 https://doi.org/10.1016/0001-6160(76)90071-7 (1976).
H. Karaca, A. Turabi, Y. Chumlyakov, I. Kireeva, H. Tobe, and B. Basaran, Scr. Mater. 120, 54–57 https://doi.org/10.1016/j.scriptamat.2016.04.008 (2016).
T. Omori, K. Ando, M. Okano, X. Xu, Y. Tanaka, I. Ohnuma, R. Kainuma, and K. Ishida, Science 333, 68–71 https://doi.org/10.1126/science.1202232 (2011).
W.S. Choi, E.L. Pang, P.-P. Choi, and C.A. Schuh, Scr. Mater. 188, 1–5 https://doi.org/10.1016/j.scriptamat.2020.06.067 (2020).
J. Xia, Y. Noguchi, X. Xu, T. Odaira, Y. Kimura, M. Nagasako, T. Omori, and R. Kainuma, Science 369, 855–858 https://doi.org/10.1126/science.abc1590 (2020).
Y. Tanaka, Y. Himuro, R. Kainuma, Y. Sutou, T. Omori, and K. Ishida, Science 327, 1488–1490 https://doi.org/10.1126/science.1183169 (2010).
T. Omori, H. Iwaizako, and R. Kainuma, Mater. Des. 101, 263–269 https://doi.org/10.1016/j.matdes.2016.04.011 (2016).
Y. Sutou, T. Omori, J. Wang, R. Kainuma, K. Ishida, and J. de Phys, J. de Phys. IV (Proc.). https://doi.org/10.1051/jp4:2003936 (2003).
T. Omori, M. Okano, and R. Kainuma, APL Mater. 1, 032103 https://doi.org/10.1063/1.4820429 (2013).
Y.M. Koval, and S. Ponomaryova, Tech. Phys. 56, 881–884 https://doi.org/10.1134/S1063784211060119 (2011).
D. Vokoun, and C. Hu, Scr. Mater. 47, 453–457 https://doi.org/10.1016/S1359-6462(02)00149-5 (2002).
S. Kajiwara, D. Liu, T. Kikuchi, and N. Shinya, Scr. Mater. 44, 2809–2814 https://doi.org/10.1016/S1359-6462(01)00978-2 (2001).
Y. Tanaka, R. Kainuma, T. Omori, and K. Ishida, Mater. Today Proc. 2, S485–S492 https://doi.org/10.1016/j.matpr.2015.07.333 (2015).
L.W. Tseng, J. Ma, I. Karaman, S.J. Wang, and Y.I. Chumlyakov, Scr. Mater. 101, 1–4 https://doi.org/10.1016/j.scriptamat.2014.12.021 (2015).
C. Zhang, C.Y. Zhu, S.M. Shin, L. Casalena, and K. Vecchio, Mater. Sci. Eng. A 743, 372–381 https://doi.org/10.1016/j.msea.2018.11.077 (2019).
T. Huang, Y. Zhang, Z. Zhang, K. Du, J. Li, L. Liu, X. Wang, and L. Sun, Mater. Char. 199, 112787 https://doi.org/10.1016/j.matchar.2023.112787 (2023).
K. Du, Y. Zhang, Z. Zhang, T. Huang, G. Zhao, L. Liu, X. Wang, and L. Sun, Mater. Sci. Eng. A 855, 143848 https://doi.org/10.1016/j.msea.2022.143848 (2022).
H. Fu, H. Zhao, S. Song, Z. Zhang, and J. Xie, J. Alloys Compd. 686, 1008–1016 https://doi.org/10.1016/j.jallcom.2016.06.273 (2016).
J. Ma, B. Hornbuckle, I. Karaman, G. Thompson, Z. Luo, and Y.I. Chumlyakov, Acta Mater. 61, 3445–3455 https://doi.org/10.1016/j.actamat.2013.02.036 (2013).
Y. Geng, M. Jin, W. Ren, W. Zhang, and X. Jin, J. Alloys Compd. 577, S631–S635 https://doi.org/10.1016/j.jallcom.2012.03.033 (2013).
Y. Geng, D. Lee, X. Xu, M. Nagasako, M. Jin, X. Jin, T. Omori, and R. Kainuma, J. Alloys Compd. 628, 287–292 https://doi.org/10.1016/j.jallcom.2014.12.172 (2015).
L. Liu, Y. Zhang, J. Li, M. Fan, X. Wang, G. Wu, Z. Yang, J. Luan, Z. Jiao, C.T. Liu, P.K. Liaw, and Z. Zhang, Int. J. Plast. https://doi.org/10.1016/j.ijplas.2022.103235 (2022).
G.U. Nanju, D. Guixia, L. Xiaoping, W. Baoqi, and M.A. Xiaoli, Prog. Nat. Sci. 14, 193–200 https://doi.org/10.1080/10020070412331343351 (2004).
L. Liu, Y. Zhang, J. Han, X. Wang, W. Jiang, C.T. Liu, Z. Zhang, and P.K. Liaw, Adv. Sci. 8, 2100870 https://doi.org/10.1002/advs.202100870 (2021).
Z.H. Wang, B. Niu, Q. Wang, C. Dong, J.C. Jie, T.M. Wang, and T.G. Nieh, Mater. Sci. Tech. 93, 60–70 https://doi.org/10.1016/j.jmst.2021.04.011 (2021).
B.B. He, B. Hu, H.W. Yen, G.J. Cheng, Z.K. Wang, H.W. Luo, and M.X. Huang, Science 357, 1029 https://doi.org/10.1126/science.aan0177 (2017).
G. Gottstein, Solid State Phase Transf. (Phys Found. Mater. Sci.). https://doi.org/10.1007/978-3-662-09291-0 (2004).
Y.I. Chumlyakov, I. Kireeva, E.Y. Panchenko, V. Kirillov, E. Timofeeva, I. Kretinina, Y.N. Danil’son, I. Karaman, H. Maier, and E. Cesari, Russ. Phys. J. 54, 937–950 https://doi.org/10.1007/s11182-011-9701-5 (2012).
Y.I. Chumlyakov, I. Kireeva, O. Kuts, and D. Kuksgauzen, Russ. Phys. J. 57, 1328–1335 https://doi.org/10.1007/s11182-015-0385-0 (2015).
C. Craciunescu, J. Li, and M. Wuttig, Scr. Mater. 48, 65–70 https://doi.org/10.1016/S1359-6462(02)00347-0 (2003).
T. Omori, S. Abe, Y. Tanaka, D. Lee, K. Ishida, and R. Kainuma, Scr. Mater. 69, 812–815 https://doi.org/10.1016/j.scriptamat.2013.09.006 (2013).
I. Kireeva, Y.I. Chumlyakov, V. Kirillov, I. Kretinina, Y.N. Danil’son, I. Karaman, and E. Cesari, Russ. Phys. J. 53, 1103–1106 https://doi.org/10.1007/s11182-011-9536-0 (2011).
I.V. Kireeva, Y.I. Chumlyakov, V.A. Kirillov, I. Karaman, and E. Cesari, Tech. Phys. Lett. 37, 487–490 https://doi.org/10.1134/s1063785011050221 (2011).
J. Ortin, and A. Planes, Acta Mater. 37, 1433–1441 https://doi.org/10.1016/0001-6160(89)90175-2 (1989).
Z. Nishiyama, Martensitic Transformation (Elsevier, New York, 2012).
S. Jiang, H. Wang, Y. Wu, X. Liu, H. Chen, M. Yao, B. Gault, D. Ponge, D. Raabe, and A. Hirata, Nature 544, 460–464 https://doi.org/10.1038/nature22032 (2017).
J. Christian, The Theory of Transformations in Metals and Alloys (Newnes, Pergamon, 2002)
K. Du, Y. Zhang, G. Zhao, T. Huang, L. Liu, J. Li, X. Wang, and Z. Zhang, Mater. Sci. Eng. A 890, 145858 https://doi.org/10.1016/j.msea.2023.145858 (2024).
G. Kurdjumov, JOM 11, 449–453 (1959).
T. Yang, Y. Zhao, Y. Tong, Z. Jiao, J. Wei, J. Cai, X. Han, D. Chen, A. Hu, and J. Kai, Science 362, 933–937 https://doi.org/10.1126/science.aas8815 (2018).
S. Qu, I. Yang, H. Liu, X. Ma, and Y. Wang, J. Yunnan Univ. Nat. 24, 346–348 (2015).
R. Völkl, U. Glatzel, and M. Feller-Kniepmeier, Acta Mater. 46, 4395–4404 https://doi.org/10.1016/S1359-6454(98)00085-8 (1998).
U. Brückner, A. Epishin, T. Link, and K. Dressel, Mater. Sci. Eng. A 247, 23–31 https://doi.org/10.1016/j.msea.2012.03.041 (1998).
F. Diologent, P. Caron, T. d’Almeida, A. Jacques, and P. Bastie, Nucl. Instrum. Methods B. 200, 346–351 https://doi.org/10.1016/S0168-583X(02)01699-3 (2003).
L. Dirand, J. Cormier, A. Jacques, J.-P. Chateau-Cornu, T. Schenk, O. Ferry, and P. Bastie, Mater. Char. 77, 32–46 https://doi.org/10.1016/j.matchar.2012.12.003 (2013).
J.R. Patel, and M. Cohen, Acta Metall. 1, 531–538 https://doi.org/10.1016/0001-6160(53)90083-2 (1953).
T. Hsu, and X. Zuyao, Ecomaterials. https://doi.org/10.1016/0036-9748(83)90217-X (1994).
S. Bodner, J. Singer, A. Solan, and Z. Hashin, Theoret. Appl. Mech. 1992, 53 https://doi.org/10.1016/C2009-0-10254-4 (1993).
E. Galindo-Nava, and P. Rivera-Díaz-del-Castillo, Acta Mater. 98, 81–93 https://doi.org/10.1016/j.actamat.2015.07.018 (2015).
E. Galindo-Nava, W. Rainforth, and P. Rivera-Díaz-del-Castillo, Acta Mater. 117, 270–285 https://doi.org/10.1016/j.actamat.2016.07.020 (2016).
N. Kamikawa, K. Sato, G. Miyamoto, M. Murayama, N. Sekido, K. Tsuzaki, and T. Furuhara, Acta Mater. 83, 383–396 https://doi.org/10.1016/j.actamat.2014.10.010 (2015).
E. Nembach, and E. Nembach, Mater. Sci. Tech. https://doi.org/10.1179/026708387790122585 (1997).
T. Gladman, Mater. Sci. Tech. 15, 30–36 (1999).
A. Argon, Strengthening Mechanisms in Crystal Plasticity (OUP Oxford, 2007)
L.M. Brown and R.K. Ham, Strengthening Methods in Crystals (Elsevier, London, 1971)
X. Wei, X. Cao, J. Luan, Z. Jiao, C. Liu, and Z. Zhang, Mater. Sci. Eng. A 832, 142487 https://doi.org/10.1016/j.msea.2021.142487 (2022).
S. Xu, Y. Zhao, D. Chen, L. Sun, L. Chen, X. Tong, C. Liu, and Z. Zhang, Int. J. Plast. 113, 99–110 https://doi.org/10.1016/j.ijplas.2018.09.009 (2019).
Z. Xiong, I. Timokhina, and E. Pereloma, Prog. Mater. Sci. 118, 100764 https://doi.org/10.1016/j.pmatsci.2020.100764 (2021).
J. He, H. Wang, H. Huang, X. Xu, M. Chen, Y. Wu, X. Liu, T. Nieh, K. An, and Z. Lu, Acta Mater. 102, 187–196 https://doi.org/10.1016/j.actamat.2015.08.076 (2016).
L. Liu, Y. Zhang, J. Li, M. Fan, X. Wang, G. Wu, Z. Yang, J. Luan, Z. Jiao, and C.T. Liu, Int. J. Plast. 153, 103235 https://doi.org/10.1016/j.ijplas.2022.103235 (2022).
Z. Wang, B. Niu, Q. Wang, C. Dong, J. Jie, T. Wang, and T. Nieh, J. Mater. Sci. Tech. 93, 60–70 https://doi.org/10.1016/j.jmst.2021.04.011 (2021).
Acknowledgements
The present work was supported by the National Key Research and Development Project (2020YFE0202600), the NSFC Funding (U2141207, 52171111, 52001083) and Natural Science Foundation of Heilongjiang (YQ2023E026).
Author information
Authors and Affiliations
Contributions
Xiyu Wang: Formal analysis, Data curation, Analyzing and discussing data, Writing—original draft. Yang Zhang: Conceptualization, Formal analysis, Supervision, Funding acquisition, Writing—review and editing. Zhongwu Zhang: Conceptualization, Formal analysis, Supervision, Funding acquisition, Writing—review & editing. Junpeng Li: Formal analysis, Data curation, Analyzing and discussing data. Liyuan Liu: Formal analysis, Data curation, Analyzing data. Weiguo Jiang: Formal analysis, Analyzing and discussing data. Kang Du: Formal analysis, Data curation, Analyzing and discussing data.
Corresponding authors
Ethics declarations
Conflict of interest
The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Wang, X., Zhang, Y., Zhang, Z. et al. High-Number-Density Coherent Nanoprecipitates Induce Superelasticity in a Fe-Ni-Co-Al-Based Alloy. JOM 76, 2526–2536 (2024). https://doi.org/10.1007/s11837-024-06469-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11837-024-06469-7