Skip to main content

Photolysis and photooxidation of typical gaseous VOCs by UV Irradiation: Removal performance and mechanisms

Abstract

Photodegradation by ultraviolet irradiation (UV) is increasingly applied in volatile organic compound (VOC) and odor gas treatments. In this study, 27 typical VOCs, including 11 hydrocarbons and 16 hydrocarbon derivatives, at 150–200 ppm in air and nitrogen gas were treated by a laboratory-scale UV reactor with 185/254 nm irradiation to systematically investigate their removal and conversion by UV irradiation. For the tested 27 VOCs, the VOC removal efficiencies in air were within the range of 13%–97% (with an average of 80%) at a retention time of 53 s, which showed a moderate positive correlation with the molecular weight of the VOCs (R = 0.53). The respective contributions of photolysis and photooxidation to VOC removal were identified for each VOC. According to the CO2 results, the mineralization rate of the tested VOCs was within the range of 9%–90%, with an average of 41% and were negatively correlated to the molecular weight (R = −0.63). Many of the tested VOCs exhibited high concentration particulate matters in the off-gases with a 3–283 mg/m3 PM10 range and a 2–40 mg/m3 PM2.5 range. The carbon balance of each VOC during UVirradiation was analyzed based on the VOC, CO2 and PM10 concentrations. Certain organic intermediates and 23–218 ppm ozone were also identified in the off-gases. Although the UV technique exhibited a high VOC removal efficiency, its drawbacks, specifically low mineralization, particulate matters production, and ozone emission, must be considered prior to its application in VOC gas treatments.

This is a preview of subscription content, access via your institution.

References

  1. 1.

    Duan H, Liu X, Yan M, Wu Y, Liu Z. Characteristics of carbonyls and volatile organic compounds (VOCs) in residences in Beijing, China. Frontiers of Environmental Science and Engineering, 2016, 10(1): 73–84

    CAS  Article  Google Scholar 

  2. 2.

    Niu H, Mo Z, Shao M, Lu S, Xie S. Screening the emission sources of volatile organic compounds (VOCs) in China by multi-effects evaluation. Frontiers of Environmental Science and Engineering, 2016, 10(5): 1

    CAS  Article  Google Scholar 

  3. 3.

    Zhao P, Zhu L. Optimized porous clay heterostructure for removal of acetaldehyde and toluene from indoor air. Frontiers of Environmental Science and Engineering, 2016, 10(2): 219–228

    CAS  Article  Google Scholar 

  4. 4.

    Qiao N, Zhang X, He C, Li Y, Zhang Z, Cheng J, Hao Z. Enhanced performances in catalytic oxidation of o-xylene over hierarchical macro-/mesoporous silica-supported palladium catalysts. Frontiers of Environmental Science and Engineering, 2016, 10(3): 458–466

    CAS  Article  Google Scholar 

  5. 5.

    Berenjian A, Chan N, Malmiri H J. Volatile organic compounds removal methods: A review. American Journal of Biochemistry and Biotechnology, 2012, 8(4): 220–229

    CAS  Article  Google Scholar 

  6. 6.

    Parmar G R, Rao N N. Emerging control technologies for volatile organic compounds. Critical Reviews in Environmental Science and Technology, 2008, 39(1): 41–78

    Article  Google Scholar 

  7. 7.

    Wekhof A. Treatment of contaminated water, air and soil with UV flash lamps. Environment and Progress, 1991, 10(4): 241–247

    CAS  Article  Google Scholar 

  8. 8.

    Bhowmick M, Semmens M J. Ultraviolet photooxidation for the destruction of VOCs in air. Water Research, 1994, 28(11): 2407–2415

    CAS  Article  Google Scholar 

  9. 9.

    Hay S O, Obee T, Luo Z, Jiang T, Meng Y, He J, Murphy S C, Suib S. The viability of photocatalysis for air purification. Molecules (Basel, Switzerland), 2015, 20(1): 1319–1356

    Article  Google Scholar 

  10. 10.

    George C, Beeldens A, Barmpas F, Doussin J F, Manganelli G, Herrmann H, Kleffmann J, Mellouki A. Impact of photocatalytic remediation of pollutants on urban air quality. Frontiers of Environmental Science & Engineering, 2016, 10(5): 2

    Article  Google Scholar 

  11. 11.

    Wang J H, Ray M B. Application of ultraviolet photooxidation to remove organic pollutants in the gas phase. Separation and Purification Technology, 2000, 19(1–2): 11–20

    Article  Google Scholar 

  12. 12.

    Kang I S, Xi J Y, Hu H Y. Effects of different operating conditions on the VOCs removal performance of UV irradiation reactors. Journal of Odor and Indoor Environment, 2017, 16(1): 72–80

    Article  Google Scholar 

  13. 13.

    Feiyan C, Pehkonen S O, Ray M B. Kinetics and mechanisms of UV-photodegradation of chlorinated organics in the gas phase. Water Research, 2002, 36(17): 4203–4214

    Article  Google Scholar 

  14. 14.

    Yu J, Cai W, Chen J, Feng L, Jiang Y, Cheng Z. Conversion characteristics and mechanism analysis of gaseous dichloromethane degraded by a VUV light in different reaction media. Journal of Environmental Sciences-China, 2012, 24(10): 1777–1784

    CAS  Article  Google Scholar 

  15. 15.

    Shen Y S, Ku Y. Treatment of gas-phase volatile organic compounds (VOCs) by the UV/O3 process. Chemosphere, 1999, 38(8): 1855–1866

    CAS  Article  Google Scholar 

  16. 16.

    Chou M S, Chang K L. UV/ozone degradation of gaseous hexamethyldisilazane (HMDS). Chemosphere, 2007, 69(5): 697–704

    CAS  Article  Google Scholar 

  17. 17.

    Mahmoudkhani F, Rezaei M, Asili V, Atyabi M, Vaisman E, Langford C H, De Visscher A. Benzene degradation in waste gas by photolysis and photolysis-ozonation: experiments and modeling. Frontiers of Environmental Science & Engineering, 2016, 10(6): 10

    Article  Google Scholar 

  18. 18.

    Cheng Z W, Sun P F, Jiang Y F, Yu J M, Chen J M. Ozone-assisted UV254 nm photodegradation of gaseous ethylbenzene and chlorobenzene: Effects of process parameters, degradation pathways, and kinetic analysis. Chemical Engineering Journal, 2013, 228 (3): 1003–1010

    CAS  Article  Google Scholar 

  19. 19.

    Koh L H, Kuhn C S, Mohseni M, Allen D G. Utilizing ultraviolet Photolysis as a pre-treatment of volatile organic compounds upstream of a biological gas cleaning operation. Journal of Chemical Technology and Biotechnology (Oxford, Oxfordshire), 2004, 79(6): 619–625

    CAS  Article  Google Scholar 

  20. 20.

    Wang C, Xi J Y, Hu H Y, Yao Y. Advantages of combined UV photodegradation and biofiltration processes to treat gaseous chlorobenzene. Journal of Hazardous Materials, 2009, 171(1–3): 1120–1125

    CAS  Article  Google Scholar 

  21. 21.

    Braslavskys S E. Glossary of terms used in photochemistry, 3rd ed. Pure and Applied Chemistry, 2007, 79(3): 293–465

    Google Scholar 

  22. 22.

    Kang I S, Xi J Y, Wang C, Hu H Y. UV Photodegradation of chlorinated VOCs: Removal efficiency and products. Journal of Korean Society for Atmospheric Environment, 2017, 33(2): 87–96

    Article  Google Scholar 

  23. 23.

    Ji J, Xu Y, Huang H, He M, Liu S, Liu G, Xie R, Feng Q, Shu Y, Zhan Y, Fang R, Ye X, Leung D Y C. Mesoporous TiO2 under VUV irradiation: Enhanced photocatalytic oxidation for VOCs degradation at room temperature. Chemical Engineering Journal, 2017, 327: 490–499

    CAS  Article  Google Scholar 

  24. 24.

    Mohseni M. Gas phase trichloroethylene (TCE) photooxidation and byproduct formation: Photolysis vs. titania/silica based photocatalysis. Chemosphere, 2005, 59(3): 335–342

    CAS  Google Scholar 

  25. 25.

    Huang H, Huang H, Zhan Y, Liu G,Wang X, Lu H, Xiao L, Feng Q, Leung D Y C. Efficient degradation of gaseous benzene by VUV photolysis combined with ozone-assisted catalytic oxidation: Performance and mechanism. Applied Catalysis B: Environmental, 2016, 186: 62–68

    CAS  Article  Google Scholar 

  26. 26.

    Jeong T S, Shin C H, Kim J S, Longzhe C. A study on the treatment of toluene and pilot test by using UV and ozone. Journal of Korean Society of Environmental Technology, 2007, 8: 33–39

    Google Scholar 

  27. 27.

    Holzinger R, Millet D B, Williams B, Lee A, Kreisberg N, Hering S V, Jimenez J, Allan J D, Worsnop D R, Goldstein A H. Emission, oxidation, and secondary organic aerosol formation of volatile organic compounds as observed at Chebogue Point, Nova Scotia. Journal of Geophysical Research, 2007, 112(D10): D10S24

    Article  Google Scholar 

  28. 28.

    Camredon M, Aumont B, Lee-Taylor J, Madronich S. The SOA/ VOC/NOx system: An explicit model of secondary organic aerosol formation. Atmospheric Chemistry and Physics Discussions, 2007, 7: 5599–5610

    CAS  Article  Google Scholar 

  29. 29.

    Lee S B, Bae G N, Moon K C. Smog chamber measurements. In: Kim Y J, Platt U, Gu M B, Iwahashi H, eds. Atmospheric and Biological Environmental Monitoring. Dordrecht: Springer, 2009, 105–136

    Chapter  Google Scholar 

  30. 30.

    Vaden T D, Song C, Zaveri R A, Imre D, Zelenyuk A. Morphology of mixed primary and secondary organic particles and the adsorption of spectator organic gases during aerosol formation. Proceedings of the National Academy of Sciences of the United States of America, 2010, 107(15): 6658–6663

    CAS  Article  Google Scholar 

  31. 31.

    Tie X, Madronich S, Li G H, Ying Z, Zhang R, Garcia A R, Lee-Taylor J, Liu Y. Characterizations of chemical oxidants in Mexico City: A regional chemical/dynamical model (WRF-Chem) study. Atmospheric Environment, 2007, 41(9): 1989–2008

    CAS  Article  Google Scholar 

Download references

Acknowledgments

This study was supported by the National Natural Science Foundation of China (Grant No.51378286) and the Science and Technology Program for Water Pollution Control (No. 2011ZX07301-003). We thank LetPub (www.letpub.com) for providing linguistic assistance during the preparation of this manuscript.

Author information

Affiliations

Authors

Corresponding author

Correspondence to Jinying Xi.

Rights and permissions

Reprints and Permissions

About this article

Verify currency and authenticity via CrossMark

Cite this article

Kang, IS., Xi, J. & Hu, HY. Photolysis and photooxidation of typical gaseous VOCs by UV Irradiation: Removal performance and mechanisms. Front. Environ. Sci. Eng. 12, 8 (2018). https://doi.org/10.1007/s11783-018-1032-0

Download citation

Keywords

  • VOCs
  • UV photodegradation
  • Particulate matters
  • Ozone