Abstract
A new high-throughput method for measuring oil content in intact, single corn kernels is demonstrated using nuclear magnetic resonance imaging (MRI) methods. This nondestructive technique enables the evaluation of relative oil content in up to 2,592 corn kernels in less than 40 min using a 1.5 T clinical MRI scanner. Custom software was developed to process and analyze 3-D magnetic resonance (MR) image data rapidly. The precision and accuracy of the MR method for measuring oil content are discussed. The precision of the MRI results is shown to be dependent on MR scanner noise. The MRI results show very good relative accuracy compared with low-field NMR, NIR transmission, and accelerated solvent extraction measurements. Minor differences between the MRI and low-field NMR experimental protocols were shown to be inconsequential to the oil content measurement. Extending the MRI method to the analysis of other oilseeds and/or the use of other magnetic field strengths is discussed, as is a comparison of this MRI method relative to other high-throughput magnetic resonance screening techniques.
Similar content being viewed by others
References
AOCS, Determination of Oil Content in Oilseeds, in Official Methods and Recommended Practices of the AOCS, 5th edn., edited by D. Firestone, AOCS Press, Champaign, 1997, Official Method Am 2–93.
Hauffe, D., F. Hofler, D.E. Knowles, J. Clark, J.L. Ezzell, and B.E. Richter, The Application of Accelerated Solvent Extraction (ASE) to Food Samples, in Current Status and Future Trends in Analytical Food Chemistry, Proceedings of the European Conference on Food Chemistry, edited by G. Sontag and W. Pfannhauser, Austrian Chemical Society, Vienna, Austria, 1995, pp. 766–767.
Schroeter, F., M. Anastassiades, and E. Scherbaum, Comparison of ASE (accelerated solvent extraction) with Traditional Extraction Methods, CLB Chem. Labor Biotech. 50:4–6 (1999).
Taylor, L.S., J.W. King, and G.R. List, Determination of Oil Content in Oilseeds by Analytical Supercritical Fluid Extraction, J. Am. Oil Chem. Soc. 70:437–439 (1993).
King, J., and W.V. O'Farrel, SFE—New Method to Measure Oil Content, inform 8:1047–1051 (1997).
AOCS, Oil in Oilseeds: Supercritical Fluid Extraction Method, in Official Methods and Recommended Practices of the AOCS, 5th edn., edited by D. Firestone, AOCS Press, Champaign, 1997, Official Method Am 3–96.
Garcia-Ayuso, L.E., J. Velasco, M.C. Dobarganes, M.D. de Castro, and M.D. Luque, Determination of the Oil Content of Seeds by Focused Microwave-Assisted Soxhlet Extraction, Chromatographia 52:103–108 (2000).
Mattaeus, B., Rapid Determination of the Oil Content in Oilseeds, LaborPraxis 22:52–55 (1998).
Daun, J.K., K.M. Clear, and P. Williams, Comparison of Three Whole Seed Near-Infrared Analyzers for Measuring Quality Components of Canola Seed, J. Am. Oil Chem. Soc. 71:1063–1068 (1994).
Orman, B.A., and R.A. Shaumann, Nondestructive Single-Kernel Oil Determination of Maize by Near-Infrared Transmission Spectroscopy, 69:1036–1038 (1992).
Tiwari, P.N., P.N. Gambhir, and T.S. Rajan, Rapid and Nondestructive Determination of Seed Oil by Pulsed Nuclear Magnetic Resonance Technique, 51:104–109 (1974).
Gambhir, P.N., Application of Low-Resolution Pulsed NMR to the Determination of Oil and Moisture in Oilseeds, Trends Food Sci. Technol. 3:191–196 (1992).
Rubel, G., Simultaneous Determination of Oil and Water Contents in Different Oilseeds by Pulsed Nuclear Magnetic Resonance, J. Am. Oil Chem. Soc. 71:1057–1062 (1994).
AOCS, Oil Content of Rapeseed by Nuclear Magnetic Resonance, in Official Methods and Recommended Practices of the AOCS, 5th edn., edited by D. Firestone, AOCS Press, Champaign, 1997, Recommended Practice Ak 3–94.
AOCS, Simultaneous Determination of Oil and Moisture Contents of Oilseeds Using Pulsed Nuclear Magnetic Resonance Spectroscopy,, Recommended Practice Ak 495.
International Standards Organization, Oilseeds—Simultaneous Determination of Oil and Water Contents—Method Using Pulsed Nuclear Magnetic Resonance Spectrometry, ISO Catalogue 67, Food Technology, Geneva, 1998, ISO/DIS 10565, Norm ISO 5725.
Bonnet, G., Statistical Properties of Background Noise in Nuclear Magnetic Resonance, Arch. Sci. (Geneva) Fasicule Spec. 14:297–304 (1961).
Morris, G., Systematic Sources of Signal Irreproducibility and T1 Noise in High-Field NMR Spectrometers, J. Magn. Reson. 100:316–328 (1992).
Hills, B.P., C. Cano, and P.S. Belton, Proton NMR Relaxation Studies of Aqueous Polysaccharide Systems, Macromolecules 24:2944–2950 (1991).
Hills, B.P. and S.L. Duce, The Influence of Chemical and Diffusive Exchange on Water Proton Transverse Relaxation in Plant Tissue, Magn. Reson. Imaging 8:321–331 (1990).
Rutt, B.K., and D.H. Lee, The Impact of Field Strength on Image Quality in MRI, J. Magn. Reson. Imaging 6:57–62 (1996).
Haner, R.L., W. Llanos, and L. Mueller, Small Volume Flow Probe for Automated Direct-Injection NMR Analysis: Design and Performance, J. Magn. Reson. 143:69–78 (2000).
Holmes, E., and J.P. Shockcor, Accelerated Toxicity Screening Using NMR and Pattern Recognition-Based Methods, Curr. Opin. Drug Discov. Devet. 3:72–78 (2000).
Stockman, B.J., Flow NMR Spectroscopy in Drug Discovery, 3:269–274 (2000).
Hicks, R.P., Recent Advances in NMR: Expanding Its Role in Rational Drug Design, Curr. Med. Chem. 8:627–650 (2001).
Author information
Authors and Affiliations
Corresponding author
About this article
Cite this article
Kotyk, J.J., Pagel, M.D., Deppermann, K.L. et al. High-throughput determination of oil content in corn kernels using nuclear magnetic resonance imaging. J Amer Oil Chem Soc 82, 855–862 (2005). https://doi.org/10.1007/s11746-005-1155-5
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11746-005-1155-5