Abstract
The aim of this work was to present the common anaerobic digestion technologies in a typical farm-scale biogas plant in China. The comprehensive benefits of most biogas plants in China have not been fully assessed in past decades due to the limited information of the anaerobic digestion processes in biogas plants. This paper analyzed four key aspects (i.e., operational performance, nonrenewable energy (NE) savings, CO2 emission reduction (CER) and economic benefits (EBs)) of a typical farm-scale biogas plant, where beef cattle manure was used as feedstock. Owing to the monitoring system, stable operation was achieved with a hydraulic retention time of 18–22 days and a production of 876,000 m3 of biogas and 37,960 t of digestate fertilizer annually. This could substantially substitute for the nonrenewable energy and chemical fertilizer. The total amount of NE savings and CER derived from biogas and digestate fertilizer was 2.10×107 MJ (equivalent to 749.7 tce) and 9.71×105 kg, respectively. The EBs of the biogas plant was 6.84×105 CNY·yr−1 with an outputs-to-inputs ratio of 2.37. As a result, the monitoring system was proved to contribute significantly to the sound management and quantitative assessment of the biogas plant. Biogas plants could produce biogas which could be used to substitute fossil fuels and reduce the emissions of greenhouse gases, and digestate fertilizer is also an important bio-product.
Similar content being viewed by others
References
Bhattacharya S C, Abdul Salam P, Sharma M, (2000). Emissions from biomass energy use in some selected Asian countries. Energy, 25(2): 169–188
Boe K, Batstone D J, Steyer J P, Angelidaki I (2010). State indicators for monitoring the anaerobic digestion process. Water Res, 44(20): 5973–5980
Bruni E, Jensen A P, Pedersen E S, Angelidaki I (2010). Anaerobic digestion of maize focusing on variety, harvest time and pretreatment. Appl Energy, 87(7): 2212–2217
Cao Y C, Pawłowski A (2013). Life cycle assessment of two emerging sewage sludge-to-energy systems: evaluating energy and greenhouse gas emissions implications. Bioresour Technol, 127: 81–91
Chen B, Chen G Q, Yang Z F, Jiang M M (2007). Ecological footprint accounting for energy and resource in China. Energy Policy, 35(3): 1599–1609
Chen G Q, Jiang M M, Chen B, Yang Z F, Lin C (2006). Emergy analysis of Chinese agriculture. Agric Ecosyst Environ, 115(1–4): 161–173
Chen G Q, Zhang B (2010). Greenhouse gas emissions in China 2007: inventory and input-output analysis. Energy Policy, 38(10): 6180–6193
Chen H, Chen G Q (2011b). Energy cost of rapeseed-based biodiesel as alternative energy in China. Renew Energy, 36(5): 1374–1378
Chen S Q, Chen B, Song D (2012). Life-cycle energy production and emissions mitigation by comprehensive biogas-digestate utilization. Bioresour Technol, 114: 357–364
Chen Y, Yang G H, Sweeney S, Feng Y Z (2010). Household biogas use in rural China: a study of opportunities and constraints. Renew Sustain Energy Rev, 14(1): 545–549
Chen Z M, Chen G Q (2011a). An overview of energy consumption of the globalized world economy. Energy Policy, 39(10): 5920–5928
Dai J, Chen B (2010). Materials flows analysis of fossil fuels in China during 2000–2007. Procedia Environmental Sciences, 2: 1818–1826
Dai J, Chen B (2011). Extended exergy-based ecological accounting of China during 2000–2007. Procedia Environmental Sciences, 5: 87–95
Duan N, Lin C, Liu X D, Wang Y, Zhang X J, Hou Y (2011). Study on the effect of biogas project on the development of low-carbon circular economy—A case study of Beilangzhong eco-village. Procedia Environmental Sciences, 5: 160–166
El-Mashad H M, Zhang R H (2010). Biogas production from codigestion of dairy manure and food waste. Bioresour Technol, 101(11): 4021–4028
FAO (1999). Agricultural Statistics. http://apps.fao.org/cgi-bin/nphdb.pl?subset-agriculture Food and Agriculture Organization, UN. (11/22/1999)
Fdez-Güelfo L A, Álvarez-Gallego C, Sales D, Romero L I (2012). New indirect parameters for interpreting a destabilization episode in an anaerobic reactor. Chem Eng J, 180: 32–38
Gautam R, Baral S, Herat S (2009). Biogas as a sustainable energy source in Nepal: present status and future challenges. Renew Sustain Energy Rev, 13(1): 248–252
Gebrezgabher S A, Meuwissen M P M, Prins B A M, Lansink A G JMO (2010). Economic analysis of anaerobic digestion—A case of green power biogas plant in the Netherlands. NJAS-Wageningen Journal of Life Sciences, 57(2): 109–115
Genovesi A, Harmand J, Steyer J P (1999). A fuzzy logic based diagnosis system for the on-line supervision of an anaerobic digestor pilot-plant. Biochem Eng J, 3(3): 171–183
Ghosh N (2004). Reducing dependence on chemical fertilizers and its financial implications for farmers in India. Ecol Econ, 49(2): 149–162
Gunamantha M, Sarto (2012). Life cycle assessment of municipal solid waste treatment to energy options: case study of Kartamantul region, Yogyakarta. Renew Energy, 41: 277–284
Hoffmann G, Schingnitz D, Schnapke A, Bilitewski B (2010). Reduction of CO2-emissions by using biomass in combustion and digestion plants. Waste Manag, 30(5): 893–901
Ihunegbo F N, Madsen M, Esbensen K H, Holm-Nielsen J B, Halstensen M (2012). Acoustic chemometric prediction of total solids in bioslurry: a full-scale feasibility study for on-line biogas process monitoring. Chemom Intell Lab Syst, 110(1): 135–143
Jantsch T G, Mattiasson B (2004). An automated spectrophotometric system for monitoring buffer capacity in anaerobic digestion processes. Water Res, 38(17): 3645–3650
Jiang M M, Chen B, Zhou J B, Tao F R, Li Z, Yang Z F, Chen G Q (2007). Emergy account for biomass resource exploitation by agriculture in China. Energy Policy, 35(9): 4704–4719
Jiang X Y, Sommer S G, Christensen K V (2011). A review of the biogas industry in China. Energy Policy, 39(10): 6073–6081
Ju L P, Chen B (2011). Embodied energy and emergy evaluation of a typical biodiesel production chain in China. Ecol Modell, 222(14): 2385–2392
Kahrl F, Li Y J, Su Y F, Tennigkeit T, Wilkes A, Xu J C (2010). Greenhouse gas emissions from nitrogen fertilizer use in China. Environ Sci Policy, 13(8): 688–694
Karellas S, Boukis I, Kontopoulos G (2010). Development of an investment decision tool for biogas production from agricultural waste. Renew Sustain Energy Rev, 14(4): 1273–1282
Koroneos C J, Nanaki E A, Xydis G A (2011). Exergy analysis of the energy use in Greece. Energy Policy, 39(5): 2475–2481
Kowalski K, Stagl S, Madlener R, Omann I (2009). Sustainable energy futures: methodological challenges in combining scenarios and participatory multi-criteria analysis. Eur J Oper Res, 197(3): 1063–1074
Kuang X Z, Shi X S, Wu X, Yuan X Z, Qiu Y L (2009). Progress of monitoring and control of anaerobic digestion. China Biogas, 27(1): 16–19 (in Chinese)
Lefroy E, Rydberg T (2003). Emergy evaluation of three cropping systems in southwestern Australia. Ecol Modell, 161(3): 195–211
Li J S, Chen G Q (2013). Energy and greenhouse gas emissions review for Macao. Renew Sustain Energy Rev, 22: 23–32
Li J S, Chen G Q, Lai T M, Ahmad B, Chen Z M, Shao L, Ji X (2013). Embodied greenhouse gas emission by Macao. Energy Policy, 59: 819–833
Li J S, Duan N, Guo S, Shao L, Lin C, Wang J H, Hou J, Hou Y, Meng J, Han M Y (2012). Renewable resource for agricultural ecosystem in China: ecological benefit for biogas by-product for planting. Ecol Inform, 12: 101–110
Limmeechokchai B, Chawana S (2007). Sustainable energy development strategies in the rural Thailand: the case of the improved cooking stove and the small biogas digester. Renew Sustain Energy Rev, 11(5): 818–837
Liu Y, Kuang Y Q, Huang N S (2008). Rural biogas development and greenhouse gas emission mitigation. China Population. Resources and Environment, 18(3): 48–53 (in Chinese)
Lu H F, Campbell D E, Li Z A, Ren H (2006). Emergy synthesis of an agro-forest restoration system in lower subtropical China. Ecol Eng, 27(3): 175–192
Meyer-Aurich A, Schattauer A, Hellebrand H J, Klauss H, Plöchl M, Berg W (2012). Impact of uncertainties on greenhouse gas mitigation potential of biogas production from agricultural resources. Renew Energy, 37(1): 277–284
Nguyen H X, Yamamoto R (2007). Modification of ecological footprint evaluation method to include non-renewable resource consumption using thermodynamic approach. Resour Conserv Recycling, 51(4): 870–884
Ozbilen A, Dincer I, Rosen M A (2012). Exergetic life cycle assessment of a hydrogen production process. Int J Hydrogen Energy, 37(7): 5665–5675
Patterson T, Esteves S, Dinsdale R, Guwy A (2011). Life cycle assessment of biogas infrastructure options on a regional scale. Bioresour Technol, 102(15): 7313–7323
Pehnt M (2006). Dynamic life cycle assessment (LCA) of renewable energy technologies. Renew Energy, 31(1): 55–71
Peng J Q, Lu L, Yang H X (2013). Review on life cycle assessment of energy payback and greenhouse gas emission of solar photovoltaic systems. Renew Sustain Energy Rev, 19: 255–274
Poeschl M, Ward S, Owende P (2010). Prospects for expanded utilization of biogas in Germany. Renew Sustain Energy Rev, 14(7): 1782–1797
Poeschl M, Ward S, Owende P (2012a). Environmental impacts of biogas deployment—Part II: life cycle assessment of multiple production and utilization pathways. J Clean Prod, 24: 184–201
Poeschl M, Ward S, Owende P (2012b). Environmental impacts of biogas deployment—Part I: life cycle inventory for evaluation of production process emissions to airs. J Clean Prod, 24: 168–183
Ramírez C A, Worrell E (2006). Feeding fossil fuels to the soil: an analysis of energy embedded and technological learning in the fertilizer industry. Resour Conserv Recycling, 46(1): 75–93
Rehl T, Müller J (2011). Life cycle assessment of biogas digestate processing technologies. Resour Conserv Recycling, 56(1): 92–104
Rehl T, Müller J (2013). CO2 abatement costs of greenhouse gas (GHG) mitigation by different biogas conversion pathways. J Environ Manage, 114: 13–25
Shao L, Wu Z, Chen G Q (2013). Exergy based ecological footprint accounting for China. Ecol Modell, 252: 83–96
Simpson A P, Edwards C F (2013). The utility of environmental exergy analysis for decision making in energy. Energy, 55: 742–751
Talens Peiró L, Villalba Méndez G, Sciubba E, Gabarrell i Durany X (2010). Extended exergy accounting applied to biodiesel production. Energy, 35(7): 2861–2869
Tock J Y, Lai C L, Lee K T, Tan K T, Bhatia S (2010). Banana biomass as potential renewable energy resource: a Malaysian case study. Renew Sustain Energy Rev, 14(2): 798–805
Vaneeckhaute C, Meers E, Michels E, Buysse J, Tack F M G (2013). Ecological and economic benefits of the application of bio-based mineral fertilizers in modern agriculture. Biomass Bioenergy, 49: 239–248
Wei D H, Li W Z (2010). PLC and configuration software and its application in the process of the methane system. Journal of Agricultural Mechanization Research, (3): 196–198 (in Chinese)
Wei D Y, Yu T, Liu F, Niu L, Dong Z L, Xu Z C (2011). Economic effect of the clean development mechanism on the countryside biogas project. Journal of Arid Land Resources and Environment, (1): 176–179 (in Chinese)
Xi Y G, Qin P (2009). Emergy evaluation of organic rice-duck mutualism system. Ecol Eng, 35(11): 1677–1683
Xia Y, Massé D I, McAllister T A, Beaulieu C, Ungerfeld E (2012). Anaerobic digestion of chicken feather with swine manure or slaughterhouse sludge for biogas production. Waste Manag, 32(3): 404–409
Xuan J, Leung MKH, Leung D Y C, Ni M (2009). A review of biomass-derived fuel processors for fuel cell systems. Renew Sustain Energy Rev, 13(6–7): 1301–1313
Yabe N (2013). Environmental and economic evaluations of centralized biogas plants running on cow manure in Hokkaido, Japan. Biomass Bioenergy, 49: 143–151
Yang Q, Chen G Q (2013). Greenhouse gas emission of corn-ethanol production in China. Ecol Modell, 252: 176–184
Yang Q, Chen G Q (2012). Nonrenewable energy cost of corn-ethanol in China. Energy Policy, 41: 340–347
Zeng X Y, Ma Y T, Ma L R (2007). Utilization of straw in biomass energy in China. Renew Sustain Energy Rev, 11(5): 976–987
Zhang B, Chen G Q (2010). Physical sustainability assessment for the China society: exergy-based systems account for resources use and environmental emissions. Renew Sustain Energy Rev, 14(6): 1527–1545
Zhang J, Smith K R, Ma Y, Ye S, Jiang F, Qi W, Liu P, Khalil M A K, Rasmussen R A, Thorneloe S A (2000). Greenhouse gases and other airborne pollutants from household stoves in China: a database for emission factors. Atmospheric Environment, 34(26): 4537–4549
Zhang L X, Wang C B, Yang Z F, Chen B (2010). Carbon emissions from energy combustion in rural China. Procedia Environmental Sciences, 2: 980–989
Zhang W X, Sun G (2008). Potential of CDM project on agriculture and stockbreeding. Jiangxi Energy, 1: 21–23 (in Chinese)
Zheng Y H, Li Z F, Feng S F, Lucas M, Wu G L, Li Y, Li C H, Jiang GM (2010). Biomass energy utilization in rural areas may contribute to alleviating energy crisis and global warming: a case study in a typical agro-village of Shandong, China. Renew Sustain Energy Rev, 14(9): 3132–3139
Zhou M, Qiu L, Zou Z Y, Luo T (2010). The design of expert consulting system for the comprehensive utilization of biogas and residue of the rural biogas project. Journal of Agricultural Mechanization Research, 4: 179–181 (in Chinese)
Author information
Authors and Affiliations
Corresponding authors
Rights and permissions
About this article
Cite this article
Duan, N., Lin, C., Wang, P. et al. Ecological analysis of a typical farm-scale biogas plant in China. Front. Earth Sci. 8, 375–384 (2014). https://doi.org/10.1007/s11707-014-0411-5
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11707-014-0411-5