Skip to main content
SpringerLink
Log in

The preparation and performance of lignin-based activated carbon fiber adsorbents for treating gaseous streams

  • Research Article
  • Published:
Frontiers of Chemical Science and Engineering Aims and scope Submit manuscript

Abstract

Two types of lignin-based carbon fibers were prepared by electrospinning method. The first was activated with Fe3O4 (LCF-Fe), and the second was not activated with Fe3O4 (LCF). Gas phase adsorption isotherms for toluene on LCF-Fe and LCF were studied. The gas phase adsorption isotherm for 0% RH showed LCF-Fe have about 439 mg/g adsorption capacity which was close to that of commercially available activated carbon (500 mg/g). The Dubinin-Radushkevich equation described the isotherm data very well. Competitive adsorption isotherms between water vapor and toluene were measured for their RH from 0 to 80%. The effect of humidity on toluene gas-phase adsorption was predicted by using the Okazaki et al. model. In addition, a constant pattern homogeneous surface diffusion model (CPHSDM) was used to predict the toluene breakthrough curve of continuous flow-packed columns containing LCF-Fe, and its capacity was 412 mg/g. Our study, which included material characterization, adsorption isotherms, kinetics, the impact of humidity and fixed bed performance modeling, demonstrated the suitability of lignin-based carbon fiber for volatile organic compound removal from gas streams.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Lillo-Ródenas M A, Cazorla-Amorós D, Linares-Solano A. Behaviour of activated carbons with different pore size distributions and surface oxygen groups for benzene and toluene adsorption at low concentrations. Carbon, 2005, 43(8): 1758–1767

    Article  Google Scholar 

  2. Gupta V K, Verma N. Removal of volatile organic compounds by cryogenic condensation followed by adsorption. Chemical Engineering Science, 2002, 57(14): 2679–2696

    Article  CAS  Google Scholar 

  3. Das D, Gaur V, Verma N. Removal of volatile organic compound by activated carbon fiber. Carbon, 2004, 42(14): 2949–2962

    Article  CAS  Google Scholar 

  4. Long C, Liu P, Li Y, Li A, Zhang Q. Characterization of hydrophobic hypercrosslinked polymer as an adsorbent for removal of chlorinated volatile organic compounds. Environmental Science & Technology, 2011, 45(10): 4506–4512

    Article  CAS  Google Scholar 

  5. Sullivan P, Moate J, Stone B, Atkinson J D, Hashisho Z, Rood M J. Physical and chemical properties of PAN-derived electrospun activated carbon nanofibers and their potential for use as an adsorbent for toxic industrial chemicals. Adsorption, 2012, 18(3–4): 265–274

    Article  CAS  Google Scholar 

  6. Hashisho Z, Emamipour H, Rood M J, James Hay K, Kim B J, Thurston D. Concomitant adsorption and desorption of organic vapor in dry and humid air streams using microwave and direct electrothermal swing adsorption. Environmental Science & Technology, 2008, 42(24): 9317–9322

    Article  CAS  Google Scholar 

  7. Foster K L, Fuerman R G, Economy J, Larson S M, Rood M J. Adsorption characteristics of trace volatile organic compounds in gas streams onto activated carbon fibers. Chemistry of Materials, 1992, 4(5): 1068–1073

    Article  CAS  Google Scholar 

  8. Qiao WM, Huda M, Song Y, Yoon S H, Korai Y, Mochida I, Katou O, Hayashi H, Kawamoto K. Carbon fibers and films based on biomass resins. Energy & Fuels, 2005, 19(6): 2576–2582

    Article  CAS  Google Scholar 

  9. Carrott P J M, Carrott M M L R. Lignin-from natural adsorbent to activated carbon: A review. Bioresource Technology, 2007, 98(12): 2301–2312

    Article  Google Scholar 

  10. Hayashi J, Kazehaya A, Muroyama K, Watkinson A P. Preparation of activated carbon from lignin by chemical activation. Carbon, 2000, 38(13): 1873–1878

    Article  CAS  Google Scholar 

  11. Ruiz-Rosas R, Bedia J, Lallave M, Loscertales I G, Barrero A, Rodríguez-Mirasol J, Cordero T. The production of submicron diameter carbon fibers by the electrospinning of lignin. Carbon, 2010, 48(3): 696–705

    Article  CAS  Google Scholar 

  12. Ahmad J J, Babak K, Nemat J, Roshanak R K, Mehdi A, Ali A B. Fenton-like catalytic oxidation of tetracycline by AC@Fe3O4 as a heterogeneous persulfate activator: Adsorption and degradation studies. Journal of Industrial and Engineering Chemistry, 2017, 45: 323–333

    Article  Google Scholar 

  13. Chiang Y C, Chiang P C, Huang C P. Effects of pore structure and temperature on VOC adsorption on activated carbon. Carbon, 2001, 39(4): 523–534

    Article  CAS  Google Scholar 

  14. Lordgooei M, Kim M S. Modeling volatile organic compound sorption in activated carbon. I: Dynamics and single-component equilibrium. Journal of Environmental Engineering, 2004, 130(3): 212–222

    CAS  Google Scholar 

  15. Cosnier F, Celzard A, Furdin G, Bégin D, Marêché J F. Influence of water on the dynamic adsorption of chlorinated VOCs on active carbon: Relative humidity of the gas phase versus pre-adsorbed water. Adsorption Science and Technology, 2006, 24(3): 215–228

    Article  CAS  Google Scholar 

  16. Kim T Y, Kim S J, Cho S Y. Effect of relative humidity on the adsorption characteristics of carbon tetrachloride in a fixed bed. Journal of Industrial and Engineering Chemistry, 2004, 10(2): 188–195

    CAS  Google Scholar 

  17. Russell B P, LeVan M D. Coadsorption of organic compounds and water vapor on BPL activated carbon.3. Ethane, propane, and mixing rules. Industrial & Engineering Chemistry Research, 1997, 36(6): 2380–2389

    Article  CAS  Google Scholar 

  18. Marban G, Fuertes A B. Co-adsorption of n-butane/water vapour mixtures on activated carbon fibre-based monoliths. Carbon, 2004, 42(1): 71–81

    Article  CAS  Google Scholar 

  19. Kaplan D, Nir I, Shmueli L. Effects of high relative humidity on the dynamic adsorption of dimethyl methylphosphonate (DMMP) on activated carbon. Carbon, 2006, 44(15): 3247–3254

    Article  CAS  Google Scholar 

  20. Ryu Y K, Lee H J, Yoo H K, Lee H C. Adsorption equilibria of toluene and gasoline vapors on activated carbon. Journal of Chemical & Engineering Data, 2002, 47(5): 1222–1225

    Article  CAS  Google Scholar 

  21. El-Sharkawy I I, He J M, Ng K C, Yap C, Saha B B. Adsorption equilibrium and kinetics of gasoline vapors onto carbon-based adsorbents. Journal of Chemical & Engineering Data, 2007, 53(1): 41–47

    Article  Google Scholar 

  22. Brosillon S, Manero M H, Foussard J N. Mass transfer in VOC adsorption on zeolite: Experimental and Theoretical Breakthrough Curves. Environmental Science & Technology, 2001, 35(17): 3571–3575

    Article  CAS  Google Scholar 

  23. Díez N, Álvarez P, Granda M, Blanco C, Santamaría R, Menéndez R. A novel approach for the production of chemically activated carbon fibers. Chemical Engineering Journal, 2015, 260: 463–468

    Article  Google Scholar 

  24. Song M, Jin B, Xiao R, Yang L, Wu Y M, Zhong Z P, Huang Y J. The comparison of two activation techniques to prepare activated carbon from corn cob. Biomass and Bioenergy, 2013, 48: 250–256

    Article  CAS  Google Scholar 

  25. Yun J H, Hwang K Y, Choi D K. Adsorption of benzene and toluene vapors on activated carbon fiber at 298, 323, and 348 K. Journal of Chemical & Engineering Data, 1998, 43(5): 843–845

    Article  CAS  Google Scholar 

  26. Wood G O. Affinity coefficients of the Polanyi/Dubinin adsorption isotherm equations: A review with compilations and correlations. Carbon, 2001, 39(3): 343–356

    Article  CAS  Google Scholar 

  27. Stoeckli F, Lavanchy A. The adsorption of water by active carbons, in relation to their chemical and structural properties. Carbon, 2000, 38(3): 475–477

    Article  CAS  Google Scholar 

  28. Crittenden J C, Rigg T J, Perram D L, Tang S R, Hand D W. Predicting gas-phase adsorption equilibria of volatile organics and humidity. Journal of Environmental Engineering, 1989, 115(3): 560–573

    Article  CAS  Google Scholar 

  29. Okazaki M, Tamon H, Toei R. Prediction of binary adsorption equilibria of solvent and water vapor on activated carbon. Journal of Chemical Engineering of Japan, 1978, 11(3): 209–215

    Article  CAS  Google Scholar 

  30. Defay R, Prigogine I, Bellemans A. Surface Tension and Adsorption. New York: Longman, 1966

    Google Scholar 

  31. Crittenden J C, Cartright P D, Rick B, Tang S R, Perram D L. An Evaluation of the Technical Feasibility of the Air-Stripping Solvent Recovery Process. Denver: American Water Works Association Research Foundation, 1987

Download references

Acknowledgements

The authors are grateful for the National Natural Science Foundation of China (Grant No. 51576048). Thanks to the financial support of Jiangsu Province Environmental Protection Foundation (2015013), the Industry, Education, and Research Prospective Project of Jiangsu Province (BY2015060-04) and Fok Ying Tong Education Foundation (142026). This research was also supported by the Brook Byers Institute for Sustainable Systems, Hightower Chair, and the Georgia Research Alliance at the Georgia Institute of Technology.

Author information

Authors and Affiliations

  1. Key Laboratory of Energy Thermal Conversion and Control (Ministry of Education), School of Energy and Environment, Southeast University, Nanjing, 210096, China

    Min Song

  2. State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, School of Resources and Environmental Engineering, East China University of Science and Technology, Shanghai, 200237, China

    Wei Zhang

  3. Brook Byers Institute for Sustainable System, School of Civil and Environmental Engineering, Georgia Institute of Technology, Atlanta, GA, 30332-0595, USA

    Yongsheng Chen, Jinming Luo & John C. Crittenden

Authors
  1. Min Song
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Wei Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Yongsheng Chen
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Jinming Luo
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. John C. Crittenden
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Min Song.

Electronic supplementary material

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Song, M., Zhang, W., Chen, Y. et al. The preparation and performance of lignin-based activated carbon fiber adsorbents for treating gaseous streams. Front. Chem. Sci. Eng. 11, 328–337 (2017). https://doi.org/10.1007/s11705-017-1646-y

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11705-017-1646-y

Keywords

Search

Navigation