Abstract
In this research, the use of ZnO thin films, as anti-reflective layers of solar cells, is presented. The thin films were synthesized through a sol–gel method and then deposited on a P–N silicon substrate using the spin-coating technique. The effect of the ZnO thin films on the efficiency of a solar cell piece was then investigated. To synthesize the ZnO films, zinc acetate dihydrate was used as the precursor, monoethanolamine (MEA) was employed as the stabilizer, and 2-methoxyethanol was used as the solvent. Moreover, to investigate the effect of the sol–gel solution concentration on the formation of ZnO nanoparticles, samples with various concentrations were prepared, and after deposition, the solar cell piece was fabricated. The ZnO thin films prepared were characterized using X-ray diffraction and field-emission-scanning electron microscopy, and a four-point probe was used to measure the surface resistance of the sample. The obtained results indicated that the nano-structured ZnO films with hexagonal crystallites and 30–50 nm particle sizes were successfully formed on the silicon substrate. In addition, the observations unraveled that the coated ZnO films could act as anti-reflection films improving the efficiency of silicon solar cells. All in all, it was concluded that the concentration of the sol–gel solution could have a considerable effect on the efficiency of the silicon solar cell.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Arnoldbik WM, Maree CH, Maas AJ, Van den Boogaard MJ (1993) Dynamic behavior of hydrogen in silicon nitride and oxynitride films made by low-pressure chemical vapor deposition. Phys Rev B 48:5444–5456. https://doi.org/10.1103/PhysRevB.48.5444
Aslan MH, Oral AY, Mensur E, Gül A, Basaran E (2004) Preparation of c-axis-oriented zinc-oxide thin films and the study of their microstructure and optical properties. Sol Energy Mater Sol Cells 82:543–552. https://doi.org/10.1016/j.solmat.2003.06.016
Awan SA, Gould RD, Gravano S (1999) Electrical conduction processes in silicon nitride thin films prepared by RF magnetron sputtering using nitrogen gas. Thin Solid Films 335:456–460. https://doi.org/10.1016/S0040-6090(99)00550-7
Caglar M, Ilican S, Caglar Y, Yakuphanoglu F (2009) Electrical conductivity and optical properties of ZnO nanostructured thin film. Appl Surf Sci 255:4491–4496. https://doi.org/10.1016/j.apsusc.2008.11.055
Duttagupta S, Ma F, Hoex B, Mueller T, Aberle AG (2012) Optimised antireflection coating using silicon nitride on textured silicon surface based on measurement and multidimensional modeling. Energy Proc 15:78–83. https://doi.org/10.1016/j.egypro.2012.02.009
Eder D, Windle AH (2008) Carbon–inorganic hybrid materials: the carbon nanotube/TiO2 interface. Adv Mater 20:1787–1793. https://doi.org/10.1002/adma.200702835
Ehara T, Ueno T, Abe J (2010) Preparation of ZnO thin film by the sol–gel method using low temperature ozone oxidation. Phys Status Solidi A 207:1600–1603. https://doi.org/10.1002/pssa.200983720
Elmer K, Kelein A, Rech B (2008) Transparent conductive zinc oxide basics and application in thin film solar cell. Springer, Berlin
Hasnidawani JN, Azlina HN, Norita H, Bonnia NN, Ratim S, Ali ES (2016) Synthesis of ZnO nanostructures using sol–gel method. Proc Chem 19:211–216. https://doi.org/10.1016/j.proche.2016.03.095
Isabella O, Jager K, Smets A, Swaaij RV (2016) Solar energy: fundamentals, technology, and systems. UIT Cambridge, Cambridge
Jeon YC, Lee HY, Joo SK (1994) IV characteristics of electron-cyclotron-resonance plasma-enhanced chemical-vapor-deposition silicon nitride thin films. J Appl Phys 75:979–984. https://doi.org/10.1063/1.356455
Karataş S, El-Nasser HM, Al-Ghamdi AA, Yakuphanoglu F (2018) High photoresponsivity Ru-doped ZnO/p-Si heterojunction diodes by the sol–gel method. Silicon 10:651–658. https://doi.org/10.1007/s12633-016-9508-7
Lapeyrade M, Besland MP, Meva’á C, Sibai A, Hollinger G (1999) Silicon nitride thin films deposited by electron cyclotron resonance plasma-enhanced chemical vapor deposition. J Vac Sci Technol 17:433. https://doi.org/10.1116/1.582106
Laughlin JB, Sarquis JL, Jones VM, Cox JA (2000) Using sol–gel chemistry to synthesize a material with properties suited for chemical sensing. development and implementation of a materials science experiment for the undergraduate curriculum. J Chem Educ 77:77–79. https://doi.org/10.1021/ed077p77
Lee JH, Ko KH, Park BO (2003) Electrical and optical properties of ZnO transparent conducting films by the sol–gel method. J Cryst Growth 247:119–125. https://doi.org/10.1016/S0022-0248(02)01907-3
Lee J, Li Z, Hodgson M, Metson J, Asadov A, Gao W (2004) Structural, electrical and transparent properties of ZnO thin films prepared by magnetron sputtering. Curr Appl Phys 4:398–401. https://doi.org/10.1016/j.cap.2003.11.058
Li J, Srinivasan S, He GN, Kang JY, Wu ST, Ponce FA (2008) Synthesis and luminescence properties of ZnO nanostructures produced by the sol–gel method. J Cryst Growth 310:599–603. https://doi.org/10.1016/j.jcrysgro.2007.11.054
Lin LY, Kim DE (2009) Effect of annealing temperature on the tribological behavior of ZnO films prepared by sol–gel method. Thin Solid Films 517:1690–1700. https://doi.org/10.1016/j.tsf.2008.10.018
Löbl HPL, Huppertz M (1998) Thermal stability of nonstoichiometric silicon nitride films made by reactive dc magnetron sputter deposition. Thin Solid Films 317:153–156. https://doi.org/10.1016/S0040-6090(97)00512-9
Louwen A, Van Sark W, Schropp R, Faaij A (2016) A cost roadmap for silicon heterojunction solar cells. Sol Energy Mater Sol Cells 147:295–314. https://doi.org/10.1016/j.solmat.2015.12.026
Mohammadi M, Rokn-Abadi MR, Arabshahi H (2010) Investigations on impact of post-heat temperature on structural, optical and electrical properties of Al-doped ZnO thin films prepared by sol-gel method. Indian J Sci Technol. 3:110–112
Saga T (2010) Advances in crystalline silicon solar cell technology for industrial mass production. NPG Asia Mater 2:96–102. https://doi.org/10.1038/asiamat.2010.82
Sagar P, Shishodia PK, Mehra RM (2007) Influence of pH value on the quality of sol–gel derived ZnO films. Appl Surf Sci 253:5419–5424. https://doi.org/10.1016/j.apsusc.2006.12.026
Schmidt J, Schuurmans FM, Sinke WC, Glunz SW, Aberle AG (1997) Observation of multiple defect states at silicon–silicon nitride interfaces fabricated by low-frequency plasma-enhanced chemical vapor deposition. Appl Phys Lett 71:252. https://doi.org/10.1063/1.119512
Schnabel W (2007) Polymers and light: fundamentals and technical applications. Wiley, Hoboken
Serreze HB (1978) Optimization solar cell by simultaneous consideration of grid pattern design and interconnect configuration. In: Photovoltaic Specialists Conference, Washington, D.C, pp 609–614
Sirimanne PM, Perera VPS (2008) Progress in dye-sensitized solid state solar cells. Phys Status Solidi B 241:1828–1833. https://doi.org/10.1002/pssb.200779540
Suwanboonl S, Tanatth R, Tanakorn R (2008) Fabrication and properties of nanocrystalline zinc oxide thin film prepared by sol–gel method. Songklanakarin J Sci Technol 30:65–69
Thitima R, Patehatee C, Takashi S, Susumu Y (2009) Efficient electron transfers in ZnO nanorod arrays with N719 dye for hybrid solar cells. Solid State Electron 53:176–180. https://doi.org/10.1016/j.sse.2008.10.014
Wright DN, Marstein ES, Holt A (2005) Double. In: Conference record of the Thirty-first IEEE photovoltaic specialists conference, IEEE
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Jalali, A., Vaezi, M.R., Naderi, N. et al. Investigating the effect of sol–gel solution concentration on the efficiency of silicon solar cells: role of ZnO nanoparticles as anti-reflective layer. Chem. Pap. 74, 253–260 (2020). https://doi.org/10.1007/s11696-019-00872-0
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11696-019-00872-0