Abstract
Storage tanks are used in process industries to store large volumes of flammable materials. The frequency of storage tank accidents is low, but there is considerable damage in case of occurrence. LP gas storage tanks are no exception to this rule, and due to storage under pressure and above the boiling point, a small leak has the potential to become a widespread accident. There have been several accidents related to storage tanks over the past years, and if we learn from these accidents, we can prevent them from happening again. The purpose of this study is to investigate liquefied gas tank accidents and provide solutions to prevent and control accidents. All LP gas tank accidents were extracted from valid databases, paper, and other reliable sources. Of these, 23 accidents that had a detailed report were analyzed with fault tree analysis. These accidents were investigated in terms of consequences, domino effects, and causes. The most important accident scenarios were identified, and solutions were provided for prevention and control according to past accidents. A total of 638 people were killed and 7,280 were injured in the 23 accidents. That means an average of 31 people were killed and 364 injured in each accident. 67% of accidents had at least one casualty. Management and organizational factors and design and installation errors were involved in 25% and 23% of accidents, respectively. Domino effects occurred in 70% of accidents, and the accident was not limited to the storage tank and spread to other areas. 43% of accidents resulted in a BLEVE phenomenon. The results of this study can prevent similar accidents in LPG storage tanks.
Similar content being viewed by others
References
M.S. Hildebrand, G.G. Noll, B. Hand, Above Ground Bulk Storage Tank Emergencies. (Jones & Bartlett Learning, Massachusetts, 2017)
F. Kadri, E. Châtelet, G. Chen, Method for quantitative assessment of the domino effect in industrial sites. Process Saf. Environ. Prot. 91(6), 452–462 (2013)
C. Pietersen, Analysis of the Lpg-disaster in Mexico city. J. Hazard. Mater. 20, 85–107 (1988)
Z. Török et al., Comparative consequence analysis of the bleve phenomena in the context on land use planning; case study: the Feyzin accident. Process Saf. Environ. Prot. 89(1), 1–7 (2011)
J.I. Chang, C.C. Lin, A study of storage tank accidents. J. Loss Prev. Process Ind. 19(1), 51–59 (2006)
B. Zheng, G.H. Chen, Storage tank fire accidents. Process Saf. Prog. 30(3), 291–293 (2011)
O. Ahmadi, S.B. Mortazavi, H.A. Mahabadi, Review of atmospheric storage tank fire scenarios: costs and causes. J. Fail. Anal. Prev. 20, 384–405 (2020)
CCPS (Center for Chemical Process Safety), & American Institute of Chemical Engineers, Center for Chemical Process Safety. Guidelines for chemical process quantitative risk analysis. (Wiley-AIChE, 2000)
R. Darbra, A. Palacios, J. Casal, Domino effect in chemical accidents: main features and accident sequences. J. Hazard. Mater. 183(1–3), 565–573 (2010)
G.R. Astbury, A review of the properties and hazards of some alternative fuels. Process Saf. Environ. Prot. 86(6), 397–414 (2008). https://doi.org/10.1016/j.psep.2008.05.001
G. Astbury, A review of the properties and hazards of some alternative fuels. Process Saf. Environ. Prot. 86(6), 397–414 (2008)
J.A. Fay, Risks of Lng and Lpg. Annu. Rev. Energy. 5(1), 89–105 (1980)
Analysis, Research and Information on Accidents (ARIA), Propane leak on a sphere (France, 2004). Available on https://www.aria.developpement-durable.gouv.fr
U.S. Chemical Safety and Hazard Investigation Board (CSB), Herrig Brothers Farm Propane Tank Explosion (1999). Available on https://www.csb.gov
U.S.Csb, Propan Tanl Explosion at Herrig Brothers Feather Creek Farm (1998). U. S. Chemical Safety And Hazard Investigation Board: Albert City, Lowa (2005)
K. Johnson, State and Community During the Aftermath of Mexico City's November 19, 1984 Gas Explosion. (1985)
G. Arturson, The tragedy of san juanico—the most severe Lpg disaster in history. Burns. 13(2), 87–102 (1987)
L. Pemex, Terminal, Mexico City, Mexico Explosion, 19th November 1984
Mannan, Sam (ed.), Lees' loss prevention in the process industries (Butterworth-Heinemann, 2005)
S. Mannan, Lees’ Loss Prevention In: The Process Industries. (Butterworth-Heinemann, Oxford, 2005)
U.S.Csb, Propane Explosion at the Little General Store (2007). U.S. Chemical Safety and Hazard Investigation Board: Ghent, West Virginia (2008)
T.V. Rodante, Analysis of an Lpg explosion and fire. Process Saf. Prog. 22(3), 174–181 (2003)
Analysis, Research and Information on Accidents (ARIA), Wall Rupture of a Cereal Storage Silo And "Domino Effect" On a Propane Tank (France, 2004). Available on https://www.aria.developpement-durable.gouv.fr
Aria, Wall Rupture of a Cereal Storage Silo and "Domino Effect" an a Propane Tank. French Ministry Of Sustainable Development: Loiret (France) (2008)
U.S.Csb, Lpg Fire At Valero – Mckee Refinery. U.S. Chemic Al S Afety And H Az Ard Investig Ation Board: Sunray, Texas (2008)
S. Zama, et al., On damage of oil storage tanks due to the 2011 off the pacific coast of Tohoku earthquake (Mw9. 0), Japan. In: Proceedings Of The 15th World Conference On Earthquake Engineering (Wcee). (2012)
X. Li, H. Koseki, M.S. Mannan, case study: assessment on large scale Lpg bleves in the 2011 Tohoku earthquakes. J. Loss Prev. Process Ind. 35, 257–266 (2015)
Emars, Explosions in the Cracking Plant of aPetrochemical Industry. Major Accident Hazards Bureau (1985)
Emars, Rupture of aBall Valve Shaft Installed on the Liquid Outlet Pipe of the Tank. Major Accident Hazards Bureau (2002)
Hse, Fire at North West Aerosols Ltd, Liverpool. Health And Safety Executive (Hse) (2005)
F. Zenier et al., Investigation of an lpg accident with different mathematical model applications. Int. J. Risk Assess. Manag. 2(3), 340–351 (2001)
L. Mattar et al., Attitudes and behaviors shaping household food waste generation: lessons from lebanon. J. Clean. Prod. 198, 1219–1223 (2018)
Emars, Leakage of Several Litres of Liquid Propane Caused by an Attempted to Steal Lpg. Major Accident Hazards Bureau (1988)
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Sarvestani, K., Ahmadi, O. & Alenjareghi, M.J. LPG Storage Tank Accidents: Initiating Events, Causes, Scenarios, and Consequences. J Fail. Anal. and Preven. 21, 1305–1314 (2021). https://doi.org/10.1007/s11668-021-01174-y
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11668-021-01174-y