Abstract
One of the major challenges of the future automotive development is to achieve the required reductions of the CO2 emissions. Therefore, it is necessary to investigate all potential technologies for efficiency improvement. In a combustion engine, about 2/3 of the chemical energy of the fuel is dissipated as waste heat. Due to its high temperature level, the waste heat in the exhaust gas is very promising for the technology of thermoelectric generators (TEG). In this work the methodology for a holistic TEG optimization for automotive vehicle applications will be presented. Thereby, all system interactions between the vehicle and the TEG are modelled and the CO2 reduction can be optimized within the vehicle system. Moreover the costs are calculated for each TEG design, and the method realizes an optimization of the cost–benefit ratio in a direct way. The optimization method is applied with a highly integrated TEG design, which has been developed to be compact and lightweight. Through the combination of improvements in TEG design and system optimization, a gravimetric power density of 267 W/kg and a volumetric power density of 478 W/dm^3 could be achieved. These power densities are about 900% and 700%, respectively, higher than the state of the art. The optimization method was applied exemplarily to a conventional vehicle (Volkswagen Golf VII) and a hybrid vehicle (Opel Ampera/Chevrolet Volt). As a result, reductions in consumption and CO2 emissions of up to 2.2% for the conventional and 3.4% for the hybrid vehicle could be achieved within the worldwide harmonized light duty driving test cycle. The cost–benefit optimum is 81.3 €/(g/km) for the conventional vehicle and 54.8 €/(g/km) for the hybrid vehicle in charge sustaining mode.
Article PDF
Similar content being viewed by others
Explore related subjects
Find the latest articles, discoveries, and news in related topics.Avoid common mistakes on your manuscript.
Abbreviations
- CFD:
-
Computational fluid dynamics
- CO:
-
Coolant
- CO2 :
-
Carbon dioxide
- COHX:
-
Coolant heat exchanger
- DLR:
-
Deutsches Zentrum für Luft- und Raumfahrt/German Aerospace Center
- DSG:
-
Dual-clutch gearbox
- HG:
-
Hot gas
- HGHX:
-
Hot gas heat exchanger
- ICE:
-
Internal combustion engine
- PHEV:
-
Plug-in hybrid electrical vehicles
- TEG:
-
Thermoelectric generator
- TEM:
-
Thermoelectric module
- TSI:
-
Turbocharged stratified injection
- WLTC:
-
Worldwide harmonized light duty driving test cycle
- WLTP:
-
Worldwide harmonized light duty vehicles test procedure
- Wp:
-
Peak power
- \( \psi_{\rm{TEG}} \) :
-
Gravimetric power density (W/kg)
- \( \phi_{\rm{TEG}} \) :
-
Volumetric power density (W/dm^3)
- \( P_{\rm{TEM,rp}} \) :
-
Electrical peak power/electrical rated power (W)
References
U. Kugler, J. Brokate, C. Schimeczek, and S. Schmid, Powertrain Scenarios for Cars in European Markets to the Year 2040. (elib DLR, 2017). https://elib.dlr.de/114744/ Accessed 10. Jan 2019.
G. Berckmans, M. Messagie, J. Smekens, N. Omar, L. Vanhaverbeke, and J.V. Mierlo, Energies 10, 1314 (2017). https://doi.org/10.3390/en10091314.
U. Kugler, and H. Dittus, Elektrisch Mobil in der Erzdiözese Freiburg. (DLR, 2017). https://www.dlr.de/dlr/Portaldata/1/Resources/documents/2018/DLR_2018_Stuttgart_Studie-elektrischmobil.pdf. Accessed 10 Jan 2019.
Bundesministerium für Umwelt, Wie klimafreundlich sind Elektroautos? (BMU, 2019). https://www.bmu.de/fileadmin/Daten_BMU/Download_PDF/Verkehr/emob_klimabilanz_2017_bf.pdf. Accessed 10. Jan 2019.
Agora Verkehrswende, Klimabilanz von Elektroautos. (AGORA Verkehrswende, 2018). https://www.agora-verkehrswende.de/fileadmin/Projekte/2018/Klimabilanz_von_Elektroautos/Agora-Verkehrswende_22_Klimabilanz-von-Elektroautos_WEB.pdf. Accessed 10 Jan 2019.
C. Buchal, H.-D. Karl, and H.-W. Sinn, Kohlemotoren, Windmotoren und Dieselmotoren: Was zeigt die CO2-Bilanz? (ifo Institut, 2019). https://www.ifo.de/DocDL/sd-2019-08-sinn-karl-buchal-motoren-2019-04-25.pdf. Accessed 25 April 2019.
M. Kober, Holistic Optimization of Thermoelectric Generators for Automotive Applications: Reaching a Cost Benefit Ratio of 81 €/(g/km). (elib DLR, 2018). https://elib.dlr.de/125922/. Accessed 10 Jan 2019.
M. Kober, Thermoelectric Generators for Automotive Applications: A New Approach to Reach the Cost-Benefit Target. (elib DLR, 2017). https://elib.dlr.de/115947/. Accessed 10. Jan 2019.
M. Kober, and H. Friedrich, Thermoelectric Generators (TEG) with High Power Density for Application in Hybrid Cars. (elib DLR, 2016). https://elib.dlr.de/107902/. Accessed 10 Jan 2019.
C. Häfele, Entwicklung fahrzeuggerechter Thermoelektrischer Generatoren zur Wandlung von Abgaswärme in Nutzenergie, Forschungsbericht 2016-08 (Köln: Deutsches Zentrum für Luft- und Raumfahrt, 2016).
M. Kober, C. Häfele, and H. Friedrich, Methodical Concept Development of Automotive Thermoelectric Generators. (elib DLR, 2016). https://elib.dlr.de/79163/. Accessed 10 Jan 2019.
J. Kitte, Beurteilung und Optimierung thermoelektrischer Systeme im Rahmen der Rekuperation und Wandlung von thermischer Energie im Fahrzeug (Berlin: Logos, 2015).
D. Jänsch, J. Topalova-Gura, and M. Aengenheister, TEG2020—Entwicklung modularer leistungsstarker und flexibel einsetzbarer thermoelektrischer Generatoren zur thermischen Rekuperation in Verbrennungskraftmaschinen und –anlagen. (Leibniz-Informationszentrum Technik und Naturwissenschaften und Universitätsbibliothek, 2015). http://edok01.tib.uni-hannover.de/edoks/e01fb16/856426342.pdf. Accessed 10 Jan 2019.
WLTP DHC, Development of a World-wide Worldwide Harmonized Light Duty Driving Test Cycle (WLTC). (UN/ECE, 2014). https://www.unece.org/fileadmin/DAM/trans/doc/2014/wp29grpe/GRPE-68-03e.pdf. Accessed 10 Jan 2019.
Deutsches Zentrum fuer Luft- und Raumfahrt e.V., DLR is Cooperating with Yamaha Corporation to Develop Thermoelectric Vehicle Systems (Homepage DLR, 2019). https://www.dlr.de/content/en/articles/news/2017/20170201_dlr-is-cooperating-with-yamaha-corporation-to-develop-thermoelectric-vehicle-systems_20587.html. Accessed 01 Nov 2019.
M. Kober, J. Electric Mater. (2020). https://doi.org/10.1007/s11664-020-07991-5
H. Friedrich, M. Schier, C. Häfele, and T. Weiler, Strom aus Abgasen—Fahrzeuggerechte Entwicklung Thermoelektrischer Generatoren. (elib DLR, 2010). https://elib.dlr.de/74793/. Accessed 10 Jan 2019.
B. Mazar, Gesamtsystemoptimierung eines thermoelektrischen Generators für eine Fahrzeuggruppe (München: Verlag Dr. Hut GmbH, 2010).
U. Rusche, D. Rabeiga, M. Padberg, and T. Bukes, Industrialisierungskonzept für hochtemperaturtaugliche thermoelektrische Generatoren zur Abgaswärmenutzung in Automobilen auf Basis neuartiger Materialien. (Leibniz-Informationszentrum Technik und Naturwissenschaften und Universitätsbibliothek, 2014). http://edok01.tib.uni-hannover.de/edoks/e01fb15/835362795.pdf. Accessed 10 Jan 2019.
M. Kober, L. Heber, J. Heuer, F. Rinderknecht, J. König, and H. Friedrich, RExTEG—Neuartiger Thermoelektrischer Generator zur Steigerung der Effizienz von Hybrid- und Range Extender Fahrzeugen. (elib DLR, 2015). https://elib.dlr.de/98080/. Accessed 10 Jan 2019.
M. Kober, T. Knobelspies, A. Rossello, and L. Heber, J. Electric. Mater. (2020). https://doi.org/10.1007/s11664-020-07963-9.
Acknowledgments
Open Access funding provided by Projekt DEAL.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Kober, M. Holistic Development of Thermoelectric Generators for Automotive Applications. J. Electron. Mater. 49, 2910–2919 (2020). https://doi.org/10.1007/s11664-020-07966-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11664-020-07966-6