Skip to main content

Cost–Performance Analysis and Optimization of Fuel-Burning Thermoelectric Power Generators


Energy cost analysis and optimization of thermoelectric (TE) power generators burning fossil fuel show a lower initial cost compared with commercialized micro gas turbines but higher operating cost per energy due to moderate efficiency. The quantitative benefit of the thermoelectric system on a price-per-energy ($/J) basis lies in its scalability, especially at a smaller scale (<10 kW), where mechanical thermodynamic systems are inefficient. This study is based on propane as a chemical energy source for combustion. The produced heat generates electric power. Unlike waste heat recovery systems, the maximum power output from the TE generator is not necessarily equal to the economic optimum (lowest $/kWh). The lowest cost is achieved when the TE module is optimized between the maximum power output and the maximum efficiency, dependent on the fuel price and operation time duration. The initial investment ($/W) for TE systems is much lower than for micro gas turbines when considering a low fractional area for the TE elements, e.g., 5% to 10% inside the module. Although the initial cost of the TE system is much less, the micro gas turbine has a lower energy price for longer-term operation due to its higher efficiency. For very long-term operation, operating cost dominates, thus efficiency and material ZT become the key cost factors.

This is a preview of subscription content, access via your institution.


  1. N. Gronewold, Sci. Am. (2009).

  2. J.L. Sweeney, The California Electricity Crisis (Stanford: Hoover Institution, 2002).

    Google Scholar 

  3. K. Yazawa and A. Shakouri, Proc. ThETA3 (2010).

  4. K. Yazawa and A. Shakouri, Proc. ASME Interpack’11, 52190 (2011).

  5. K. Yazawa and A. Shakouri, J. Electron. Mater. 41, 1845 (2012).

    Article  CAS  Google Scholar 

  6. K. Yazawa and A. Shakouri, J. Mater. Res. 27, 1 (2012).

    Article  Google Scholar 

  7. J.W. Fairbanks, Proceedings of the 2nd Thermoelectrics Applications Workshop (2011).

  8. C. Soares, Microturbines: Applications for Distributed Energy Systems (Burlington: Academic, 2007).

    Google Scholar 


  10. A. Van Maaren, D.S. Thung, and L.R.H. De Goey, Combust. Sci. Technol. 96, 327 (1994).

    Article  Google Scholar 

  11. K. Yazawa and A. Shakouri, J. Appl. Phys. 111, 024509 (2012).

    Article  Google Scholar 


  13. Y. You-hong and S. Feng-rui, Proc. IEEM on IEEE, 2004 (2010).

  14. US Energy Information Administration, Annual Energy Outlook 2012 with Projections to 2035 (2012).

Download references

Author information

Authors and Affiliations


Corresponding author

Correspondence to Kazuaki Yazawa.

Rights and permissions

Reprints and Permissions

About this article

Cite this article

Yazawa, K., Shakouri, A. Cost–Performance Analysis and Optimization of Fuel-Burning Thermoelectric Power Generators. J. Electron. Mater. 42, 1946–1950 (2013).

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI:


  • Topping cycle
  • thermoelectric
  • energy production
  • energy cost