Skip to main content
SpringerLink
Log in

Preparation and action mechanism of inclusion complex of β-cyclodextrin and sulfurized isobutylene as additives in solution of polyethylene glycol-600

  • Organic Materials
  • Published:
Journal of Wuhan University of Technology-Mater. Sci. Ed. Aims and scope Submit manuscript

Abstract

The inclusion complex of β-cyclodextrin (β-CD) and sulfurized isobutylene (T321) was prepared with a co-precipitation method. The tribological properties of the complex with different concentrations were investigated by a four-ball tester in the solution of polyethylene glycol-600 (PEG-600). The experimental results suggest that the complex exhibits better anti-friction and anti-wear properties than β-CD under different load conditions. The tribo-system shows the least friction coefficient when the concentration of the complex is 0.8%. During the friction process, the complex was decomposed into various molecular fragments and the T321 molecules were released onto the friction interface to provide effective lubrication. The XPS analytical results on the worn surfaces reveal that sulfide film formed by the released T321 plays a major role, and the iron alkoxide and carbon deposition films formed by the β-CD fragments have better anti-friction effect on the sulfide film surface. The interactions of different films result in the formation of a mixed boundary lubrication film.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Szejtli J. Introduction and General Over View of Cyclodextrin Chemistry[J]. Chem. Rev., 1998, 98: 1 743–1 753

    Google Scholar 

  2. Hbaieb S, Kalfat R, Chevalier Y, et al. Influence of the Substitution of ß-cyclodextrins by Cationic Groups on the Complexation of Organic Anions[J]. Mater. Sci. Eng., C, 2008, 28: 697–704

    Article  Google Scholar 

  3. Abou-Okeil A, Amr A, Abdel-Mohdy FA. Investigation of Silver Nanoparticles Synthesis Using Aminated ß-cyclodextrin [J]. Carbohydr. Polym., 2012, 89:1–6

    Article  Google Scholar 

  4. Arun R, Ashok KC, Sravanthi VV. Cyclodextrins as Drug Carrier Molecule: A review[J]. Scripta Mater., 2008, 76: 567–598

    Google Scholar 

  5. Astray G, Gonzalez-Barreiro C, Mejuto JC, et al. A Review on the Use of Cyclodextrins in Foods[J]. Food Hydrocolloid, 2009, 23: 1 631–1 640

    Article  Google Scholar 

  6. Lesilie RR. Lubricant Additives: Chemistry and Applications[M]. Taylor & Francis Group LLC, 2010, 150–156

    Google Scholar 

  7. Mortier RM, Fox MF, Orszulik ST. Chemistry and Technology of Lubricants [M]. Springer-Verlag, 2010, 15–30

    Google Scholar 

  8. Kamiyama T, Satoh M, Tateishi T, et al. Effects of Modified ß-cyclodextrin on Thermal Stability and Conformation of Lysozyme[J]. Thermochim. Acta, 2012, 20: 10–14

    Article  Google Scholar 

  9. Su J, Chen J, Li L, et al. Formation of ß-cyclodextrin Inclusion Enhances the Stability and Aqueous Solubility of Natural Borneol[J]. J. Food Sci., 2012, 6: 658–664

    Article  Google Scholar 

  10. Álvarez C, Calero J, Menéndez JC, et al. Effects of Hydroxypropylbeta- cyclodextrin on the Chemical Stability and the Aqueous Solubility of Thalidomide Enantiomers[J]. Int. J. Ph. Sci., 2008, 63: 511–513

    Google Scholar 

  11. Shin JS, Wei SF, Chin LT, et al. Polymer-based Self-lubricating Material [J]. J. Appl. Polym. Sci., 2001, 80: 1 514–1 519

    Google Scholar 

  12. Fusaro RL. Self-lubricating Polymer Composites and Polymer Transfer Film Lubrication for Space Applications[J]. Tribol. Int., 1990, 23: 105–122

    Article  Google Scholar 

  13. Qi XW, Jia ZN, Yang YL. Influence of the Dispersion of Nano Titanium Dioxide on the Tribological Performance of Fabric Self-lubricating Liner[J]. J. Appl. Polym. Sci., 2013, Published online: 16, May

    Google Scholar 

  14. Forbes ES. The Load-carrying Action of Organo-sulphur Compounds-a Review[J]. Wear, 1970, 15: 87–96

    Article  Google Scholar 

  15. Plaza S, Mazurkiewicz B, Gruzinski R. Thermal Decomposition of Dibenzyl Disulphide and Its Load-carrying Mechanism[J]. Wear, 1994, 174: 209–216

    Article  Google Scholar 

  16. Xue QJ, Liu WM. Tribochemistry and the Development of AW and EP Oil Additive-a Review[J]. Lubr. Sci., 1994, 10: 81–92

    Article  Google Scholar 

  17. Kajdas C. On a Negative-Ion Concept of EP Action of Organo-Sulfur Compounds[J]. ASLE Transactions, 1985, 28: 21–30

    Article  Google Scholar 

  18. Lara J, Blunt T, Kotvis P, et al. The Surface Chemistry and Extremepressure Lubricant Properties of Dimethyl Disulfide[J]. J. Chem. Phys., 1998, B102: 1 703–1 709

    Google Scholar 

  19. Spikes HA. Additive and Additive-surface Interactions in Lubricants[J]. Lubr. Sci., 1989, 2:3–23

    Article  Google Scholar 

  20. Gao F, Kotvis PV, Tysoe WT. The Surface and Tribological Chemistry of Chlorine- and Sulfur-containing Lubricant Additives[J]. Tribol. Int., 2004, 37: 87–92

    Article  Google Scholar 

  21. Choudhary RB, Jha MK. Action mechanisms of Boundary Lubrication Additives - A Review, Part II[J]. Lubr. Sci., 2004, 17: 75–93

    Article  Google Scholar 

  22. Bowden FP. The Friction and Lubrication of Solids[M]. Oxford University Press, 1950, 178–196

    Google Scholar 

  23. Beltzer M, Jahanmir S. Effect of Additive Molecular Structure on Friction[ J]. Lubr. Sci., 1998, 1: 3–26

    Article  Google Scholar 

  24. Hu YH, Liu WM. Tribological Properties of Alcohols as Lubricating Additives for Aluminum-on-steel Contact[J]. Wear, 1998, 218: 244–249

    Article  Google Scholar 

  25. Fischer DA, Hu ZS, Hsu SM. Tribochemical and Thermochemical Reactions of Stearic Acid on Copper Surfaces in Air as Measured by Ultrasoft X-ray Absorption Spectroscopy[J]. Tribol. Lett., 1997, 3: 35–40

    Article  Google Scholar 

  26. Liviu EM, Daniela R, Vasile P. New Unsymmetrical Complex Diesters of Adipic Acid Considered as Tribological Fluids[J]. Lubr. Sci., 2010, 22: 341–354

    Article  Google Scholar 

  27. Wu YX, Li WM, Zhang M, et al. Oxidative Degradation of Synthetic Ester and Its Influence on Tribological Behavior[J]. Tribol. Int., 2013, 64:16–23

    Article  Google Scholar 

  28. Jimenez MC, Miranda MA, Tormos R. Photodecar Ylation of 2-phenylpropionic Acid in Solution and Included Within ß-cyclodextrin [J]. Tetrahedron, 1995, 51: 2 953–2 958

    Google Scholar 

  29. Schneider, H-J, Hacket F, Rudiger V. NMR Studies of Cyclodextrins and Cyclodextrin Complexes[J]. Chem. Rev., 1998, 98: 1 755–1 785

    Google Scholar 

  30. Pionto LM, Fraceto LF, Santana MH, et al. Physico-chemical Characterization of Benzocaine-beta-cyclodextrin Inclusion Complexes[J]. J. Pharm. Biomed. Anal., 2005, 39: 956–963

    Article  Google Scholar 

  31. Fernandes CM, Teresa Vieira M, Veiga FJ. Physicochemical Characterization and in vitro Dissolution Behavior of Nicardipinecyclodextrins Inclusion Compounds[J]. J. Pharm. Sci., 2002, 15:79–88

    Google Scholar 

  32. Kaltchev M, Kotvis PV, Blunt TJ, et al. A Molecular Beam Study of the Tribological Chemistry of Dialkyl Disulfides[J]. Tribol. Lett., 2001, 10: 45–50

    Article  Google Scholar 

  33. Briggs D. Surface analysis of polymers by XPS and static SIMS[M]. Cambridge University Press, London, 1998, 35–52

    Book  Google Scholar 

  34. Hsu SM, Zhang J, Yin ZF. The Nature and Origin of Tribochemistry[J]. Tribol. Lett., 2002, 13: 131–139

    Article  Google Scholar 

  35. Kajdas C. A Novel Approach to Tribochemical Reactions: Generalized NIRAM-HSAB Action Mechanism[C]. In: Proc. Int. Trib. Conf. Yokohama-Satellite Forum on Tribochemistry, 1995, 31–35

    Google Scholar 

  36. Kajdas C, Furey MJ, Ritter, et al. Triboemission as a Basic Part of the Boundary Friction Regime: A Review[J]. Lubr. Sci., 2002, 14: 223–254

    Article  Google Scholar 

  37. Kajdas C. Importance of the Triboemission Process for Tribochemical Reaction[J]. Tribol. Int., 2005, 38: 337–353

    Article  Google Scholar 

  38. Kajdas C. Importance of Anionic Reactive Intermediates for Lubricant Component Reactions with Friction Surfaces[J]. Lubr. Sci., 1994, 6: 203–228

    Article  Google Scholar 

  39. Bowden FP, Moore AC. Physical and Chemical Adsorption of Long Chain Compounds on Radio Active Metals [J]. Transactions of the Faraday Society, 1951, 47: 900–908

    Article  Google Scholar 

  40. Jahanmir S. Chain Length Effects in Boundary Lubrication[J]. Wear, 1985, 102: 331–349

    Article  Google Scholar 

  41. Yi HL, Wu H, Zeng XQ, et al. X-ray Absorption Near-edge Structure Spectroscopy of Tribochemical/Thermal Films Generated from Serial Alkyl Polysulfides[J]. Acta Physica Sinica, 2006, 22: 1 473–1 477

    Google Scholar 

  42. Han N, Shui L, Liu WM, et al. Study of the Lubrication Mechanism of Olefin Sulfide[J]. Tribology, 2002, 22: 49–53

    Google Scholar 

  43. Buckley DH. Surface Effects in Adhesion, Friction, Wear, and Lubrication[M]. Elsevier Scientific Pub. Co., Amsterdam, 1981: 121–145

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Key Laboratory of Special Purpose Equipment and Advanced Processing Technology, Ministry of Education & Zhejiang Province, Zhejiang University of Technology, Hangzhou, 310014, China

    Jiju Guan  (关集俱), Xuefeng Xu  (许雪峰), Jiande Hu & Wei Peng

Authors
  1. Jiju Guan  (关集俱)
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Xuefeng Xu  (许雪峰)
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Jiande Hu
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Wei Peng
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Xuefeng Xu  (许雪峰).

Additional information

Funded by the National Natural Science Foundation of China (No. 51075366)

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Guan, J., Xu, X., Hu, J. et al. Preparation and action mechanism of inclusion complex of β-cyclodextrin and sulfurized isobutylene as additives in solution of polyethylene glycol-600. J. Wuhan Univ. Technol.-Mat. Sci. Edit. 30, 859–867 (2015). https://doi.org/10.1007/s11595-015-1237-z

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11595-015-1237-z

Keywords

Search

Navigation