Abstract
Stable superhydrophobic n-tetradecanoic acid (CH3(CH2)14COOH) film was prepared by means of sol-gel and self-assembly techniques, with a very high seawater contact angle (158°) and a small sliding angle (<5°). There are many microconvexities with binary structure uniformly distributed on the surface atop the film with an average diameter of about 80 nm by observation of scanning electron microscope (SEM), and the film surface structure is similar to that of lotus surface. The corrosion resistance behavior of intermetallic Fe3Al with the biomimetic superhydrophobic film surface is improved obviously when compared with pure Fe3Al sample by measurement of electrochemical impedance spectroscopy (EIS).
Similar content being viewed by others
References
Gao X F, Jiang L. Water-repellent legs of water striders. Nature, 2004, 432: 36–36
Lau K K S, Bico J, Teol K B K. Superhydrophobic carbon nanotube forests. Nano Lett, 2003, 3(12): 1701–1705
Liu C T, Stiegler J O, Froes F H. Ordered Intermetallics. 10th ed, Metals Handbook, vol 2. Pittsburgh: ASM, 1990. 913–943
Gonzalez-Rodriguez J G. Effect of heat treatment on corrosion behaviour of deposited Fe-40Al intermetallics. British Corrosion J, 2001, 36(1): 65–69
Shang H M, Wang Y, Limmer S J, et al. Optically transparent superhydrophobic silica-based films. Thin Solid Films, 2005, 472(1–2): 37–43
Feng L, Li S, Li Y, et al. Super-hydrophobic surfaces: From natural to artificial. Adv Mater, 2002, 14(24): 1857–1860
Guo Z G, Zhou F, Hao J C, et al. Stable biomimetic super-hydrophobic engineering materials. J Am Chem Soc, 2005, 127: 15670–15671
Da Silva S, Basseguy R, Bergel A. Electron transfer between hydrogenase and 316L stainless steel: Identification of a hydrogenase-catalyzed cathodic reaction in anaerobic mic. J Electroanal Chem, 2004, 561(1–2): 93–102
Thompson I, Campbell D. Interpreting Nyquist responses from defective coatings on steel substrates. Corros Sci, 1994, 36(1): 187–198
Bonora P L, Deflorian F, Fedrizzi L. Electrochemical Impedance Spectroscopy as a tool for investigating underpaint corrosion. Electrochim Acta, 1996, 41(7–8): 1073–1082
Boukamp B A. Equivalent Circuit Users Manual. 2nd ed. Enschede: University of Twente, 1993
Author information
Authors and Affiliations
Corresponding author
Additional information
Supported by the Excellent Mid-youthful Scientist Encouraging Foundation of Shandong Province (Grant No. 2006BS04021) and the National Natural Science Foundation of China (Grant Nos. 50672090 and 50702053)
Rights and permissions
About this article
Cite this article
Chen, S., Liu, T. & Yin, Y. Stable biomimetic film on Fe3Al surface for corrosion resistance in seawater. Sci. China Ser. E-Technol. Sci. 51, 975–978 (2008). https://doi.org/10.1007/s11431-008-0071-3
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11431-008-0071-3