Environmental impact assessment of aviation emission reduction through the implementation of composite materials
- 2.2k Downloads
Carbon-fibre-reinforced polymers (CFRP) have been developed by the aviation industry to reduce aircraft fuel burn and emissions of greenhouse gases. This study presents a life cycle assessment (LCA) of an all-composite airplane, based on a Boeing 787 Dreamliner. The global transition of aircraft to those of composite architecture is estimated to contribute 20–25 % of industry CO2 reduction targets. A secondary stage of the cradle-to-grave analysis expands the study from an individual aircraft to the global fleet.
An LCA was undertaken utilising SimaPro 7.2 in combination with Ecoinvent. Eco-indicator 99 (E) V2.05 Europe EI 99 E/E was the chosen method to calculate the environmental impact of the inventory data. The previously developed aviation integrated model was utilised to construct a scenario analysis of the introduction of composite aircraft against a baseline projection, through to 2050, to model CO2 emissions due to their particular relevance in the aviation sector.
Results and discussion
The analysis demonstrated CFRP structure results in a reduced single score environmental impact, despite the higher environmental impact in the manufacturing phase, due to the increased fossil fuel use. Of particular importance is that CFRP scenario quickly achieved a reduction in CO2 and NOx atmospheric emissions over its lifetime, due to the reduced fuel consumption. The modelled fleet-wide CO2 reduction of 14–15 % is less than the quoted emission savings of an individual aircraft (20 %) because of the limited fleet penetration by 2050 and the increased demand for air travel due to lower operating costs.
The introduction of aircraft based on composite material architecture has significant environmental benefits over their lifetime compared to conventional aluminium-based architecture, particularly with regards to CO2 and NOx a result of reduced fuel burn. The constructed scenario analyses the interactions of technology and the markets they are applied in, expanding on the LCA, in this case, an observed fleet-wide reduction of CO2 emission of 14–15 % compared to an individual aircraft of 20 %.
KeywordsAviation emissions Carbon-fibre-reinforced polymers Composite aircraft Global warming Life cycle assessment
This study has been carried out independently using the information available in the public domain. The authors wish to thank Bart Moenster, John Baumann and David Heck from Boeing for their motivational support.
- Advisory Council for Aeronautics Research in Europe (2002) Strategic research agenda. Luxembourg: Publications Office of the European Union http://www.acare4europe.org/sites/acare4europe.org/files/document/ASD-volume1-2nd-final-ss%20illus-171104-out-asd.pdf. Accessed 14 Sept 2010
- Advisory Council for Aeronautics Research in Europe (2011) Flightpath 2050: Europe’s vision for aviation. Luxembourg: Publications Office of the European Union. http://ec.europa.eu/transport/modes/air/doc/flightpath2050.pdf. Accessed Nov 2013
- Airbus (2011) Global market forecast 2011–2030. Toulouse: Airbus Group. http://www.airbus.com/company/market/forecast/?eID=dam_frontend_push&docID=33755. Accessed Nov 2013
- Airbus (2012) Facts & figures: A350 XWB eco-efficiency. Toulouse: Airbus. http://www.airbus.com/presscentre/presskits/?eID=dam_frontend_push&docID=27412. Accessed Nov 2013
- Boeing (2013a) Current market outlook. Chicago: Boeing. http://www.boeing.com/assets/pdf/commercial/cmo/pdf/Boeing_Current_Market_Outlook_2013.pdf. Accessed Jan 2014
- Boeing (2013b) 787 Dreamliner: program fact sheet. Chicago: Boeing. http://www.boeing.com/boeing/commercial/787family/programfacts.page. Accessed Jan 2014
- Campbell FC (2004) Manufacturing processes for advanced composites. Elsevier, AmsterdamGoogle Scholar
- Campbell FC (2006) Manufacturing technology for aerospace structural material. Elsevier, OxfordGoogle Scholar
- Clarke LE, Edmonds JA, Jacoby HD, Pitcher HM, Reilly JM, Richels RG (2007) Scenarios of greenhouse gas emissions and atmospheric concentrations. Sub-report 2.1A of Synthesis and Assessment Product 2.1 by the US Climate Change Science Program and the Subcommittee on Global Change Research. Washington DC: Department of Energy, Office of Biological and Environmental ResearchGoogle Scholar
- De Beaufrt-Langeveld A, van den Berg N, Christiansen K, Haydock R, ten Houten M, Kotaji S (1997) Simplifying LCA: just a cut? Final report of the SETAC Europe Screening and Streamlining Working Group. SETAC, AmsterdamGoogle Scholar
- European Commission (2008) Fuel and air transport. Brussels: European Commission. http://ec.europa.eu/transport/modes/air/doc/fuel_report_final.pdf. Accessed 25 Aug 2010
- Helms H, Lambrecht U (2007) The potential contribution of light-weighting to reduce transport energy consumption. Int J Life Cycle Assess 12(1):58–64Google Scholar
- Intergovernmental Panel on Climate Change (1999) Aviation and the global atmosphere: a special report of IPCC Working Groups I and III in collaboration with the Scientific Assessment Panel to the Montreal Protocol on Substances that Deplete the Ozone Layer; Penner EP, Lister DH, Griggs DJ, Dokken DJ, McFarland M (eds), Cambridge University Press: Cambridge, UK, 1999Google Scholar
- International Air Transport Association (2009) The IATA technology roadmap report. Montreal: International Air Transport Association. http://www.iata.org/whatwedo/environment/Documents/technology-roadmap-2013.pdf. Accessed Nov 2013
- International Air Transport Association (2012) Financial forecast June 2012. Montreal: International Air Transport Association. https://www.iata.org/whatwedo/Documents/economics/Industry-Outlook-Jun2012.pdf. Accessed Nov 2013
- International Civil Aviation Organisation (2011) The thirty-fifth session of the UNFCCC Subsidiary Body for Scientific and Technological Advice, agenda item 9(a). Montreal: International Civil Aviation Organization. http://www.iata.org/pressroom/Documents/annual-report-2011.pdf. Accessed Nov 2013
- International Civil Aviation Organisation (2013) Report of the executive committee on agenda item 17 (section on climate change). Montreal: International Civil Aviation Organization. http://www.icao.int/Meetings/a38/Documents/WP/wp430_en.pdf. Accessed Jan 2014
- International Energy Agency (2007a) Energy statistics of OECD countries 2007. OECD/IEA, ParisGoogle Scholar
- International Energy Agency (2007b) Energy statistics of non-OECD countries 2007. OECD/IEA, ParisGoogle Scholar
- International Energy Agency (2009) Energy technology transitions for industry. OECD/IEA, ParisGoogle Scholar
- International Standardization Organization (2006) ISO14040 International Standard. In: Environmental management—lifecycle assessment—principles and framework. Geneva: International Organisation for StandardizationGoogle Scholar
- Kahn Ribeiro S, Kobayashi S et al (2007) Climate change 2007: mitigation of climate change contribution of working group III to the fourth assessment report of the intergovernmental panel on climate change. In: Metz B, Davidson OR, Bosch PR, Dave R, Meyer LA (eds) Transport and its infrastructure. Cambridge University Press, Cambridge and New YorkGoogle Scholar
- Norris G, Wagner M (2009) Boeing 787 dreamliner. Zenith Press, MinneapolisGoogle Scholar
- Peel CJ, Gregson PJ (1995) High performance materials in aerospace. In: Flower HM (ed) Design requirements for aerospace structural materials. Chapman & Hall, London, pp 1–48Google Scholar
- Reynolds T, Barrett S, Dray L, Evans A, Kohler M, Vera-Morales M et al. (2007) Modelling environmental & economic impacts of aviation: introducing the aviation integrated modelling project. Presented at the 7th AIAA Aviation Technology, Intergration and Operations Conference, BelfastGoogle Scholar
- Sims R, Schaeffer R, Creutzig F, Cruz-Núñez X, D’Agosto M, Dimitriu D, Figueroa Meza MJ, Fulton L, Kobayashi S, Lah O, McKinnon A, Newman P, Ouyang M, Schauer JJ, Sperling D, Tiwari G (2014) Transport. In: Edenhofer O, Pichs-Madruga R, Sokona Y, Farahani E, Kadner S, Seyboth K, Adler A, Baum I, Brunner S, Eickemeier P, Kriemann B, Savolainen J, Schlömer S, von Stechow C, Zwickel T, Minx JC (eds) Climate change 2014: mitigation of climate change. Contribution of working group III to the fifth assessment report of the intergovernmental panel on climate change. Cambridge University Press, CambridgeGoogle Scholar
- Vera-Morales M, Graham W, Hall C, Schäfer A (2011) Techno-economic analysis of aircraft. Cambridge: University of Cambridge. http://www.toscaproject.org/FinalReports/TOSCA_WP2_Aircraft.pdf. Accessed July 2013