Abstract
The control of low-concentration VOCs in coal-fired flue gas is one of the research hotspots at present. In this work, K2CO3 and K2CO3-KCl were employed to activate the agricultural wastes (pistachio nut shell) to prepare activated carbon (AC), named PSAC-1 and PSAC-2, respectively. By testing the adsorption performance of the prepared AC and commercial activated carbon (CAC) for the five target VOCs, it was observed that the adsorption capacity of PSAC-2 was the best compared to the other two. Particularly, the adsorption capacity of PSAC-2 (225 mg·g-1) for phenol was 3.8 times that of CAC (59 mg·g-1). In addition, the pseudo-first-order model, pseudo-second-order model, and Elovich model all fitted the adsorption process well, which indicated that both physical adsorption and chemical adsorption existed simultaneously, in which physical adsorption played a dominant role and chemical adsorption played a minor role. Weber-Morris kinetic model was used to illustrate the rate-controlling mechanism; the results confirmed that the stage of external membrane mass transfer was the control stage of adsorption rate. The results of this study can provide some references for the commercial production of biomass-derived AC and the removal of VOCs in coal-fired flue gas.
Graphical abstract
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Availability of data and materials
All data generated or analyzed during this study are included in this published article and its supplementary information files.
References
Açıkalın K, Karaca F, Bolat E (2012) Pyrolysis of pistachio shell: effects of pyrolysis conditions and analysis of products. Fuel 95:169–177. https://doi.org/10.1016/j.fuel.2011.09.037
Almazán-Almazán MC, Pérez-Mendoza M, Domingo-García M, Fernández-Morales I, Rey-Bueno FD, García-Rodríguez A, López-Garzón FJ (2007) The role of the porosity and oxygen groups on the adsorption of n-alkanes, benzene, trichloroethylene and 1,2-dichloroethane on active carbons at zero surface coverage. Carbon. 45:1777–1785. https://doi.org/10.1016/j.carbon.2007.05.003
Bazan-Wozniak A, Nowicki P, Pietrzak R (2017) The influence of activation procedure on the physicochemical and sorption properties of activated carbons prepared from pistachio nutshells for removal of NO2/H2S gases and dyes. J. Clean Prod. 152:211–222. https://doi.org/10.1016/j.jclepro.2017.03.114
Cardoso B, Mestre AS, Carvalho AP, Pires J (2008) Activated carbon derived from cork powder waste by KOH Activation: preparation, characterization, and VOCs adsorption. Ind. Eng. Chem. Res. 47:5841–5846. https://doi.org/10.1021/ie800338s
Cheng J, Zhang YS, Wang T, Xu H, Norris P, Pan WP (2018) Emission of volatile organic compounds (VOCs) during coal combustion at different heating rates. Fuel. 225:554–562. https://doi.org/10.1016/j.fuel.2018.03.185
Chiang YC, Chiang PC, Huang CP (2001) Effects of pore structure and temperature on VOC adsorption on activated carbon. Carbon. 39:523–534. https://doi.org/10.1016/S0008-6223(00)00161-5
Deng S, Nie Y, Du ZW, Huang Q, Meng PP, Wang B, Huang J, Yu G (2015) Enhanced adsorption of perfluorooctane sulfonate and perfluorooctanoate by bamboo-derived granular activated carbon. J. Hazard. Mater. 282:150–157. https://doi.org/10.1016/j.jhazmat.2014.03.045
Dolas H, Sahin O, Saka C, Demir H (2011) A new method on producing high surface area activated carbon: the effect of salt on the surface area and the pore size distribution of activated carbon prepared from pistachio shell. Chem. Eng. J. 166:191–197. https://doi.org/10.1016/j.cej.2010.10.061
Drenkova-Tuhtan A, Schneider M, Franzreb M, Meyer C, Gellermann C, Sextl G, Mandel K, Steinmetz H (2017) Pilot-scale removal and recovery of dissolved phosphate from secondary wastewater effluents with reusable ZnFeZr adsorbent @ Fe3O4/SiO2 particles with magnetic harvesting. Water Res. 109:77–87. https://doi.org/10.1016/j.watres.2016.11.039
Fernández-Martı́nez G, López-Mahı́a P, Muniategui-Lorenzo S, Prada-Rodrı́guez D, Fernández-Fernández E (2001) Distribution of volatile organic compounds during the combustion process in coal-fired power stations. Atmos. Environ. 35:5823–5831. https://doi.org/10.1016/S1352-2310(01)00282-5
Foo KY, Hameed BH (2011) Preparation and characterization of activated carbon from pistachio nut shells via microwave-induced chemical activation. Biomass Bioenerg. 35:3257–3261. https://doi.org/10.1016/j.biombioe.2011.04.023
Foroushani FT, Tavanai H, Hosseini FA (2016) An investigation on the effect of KMnO4 on the pore characteristics of pistachio nut shell based activated carbon. Microporous Mesoporous Mat. 230:39–48. https://doi.org/10.1016/j.micromeso.2016.04.030
Gao Y, Yue QY, Gao BY, Sun YY, Wang WY, Li Q, Wang Y (2013) Comparisons of porous, surface chemistry and adsorption properties of carbon derived from Enteromorpha prolifera activated by H4P2O7 and KOH. Chem. Eng. J. 232:582–590. https://doi.org/10.1016/j.cej.2013.08.011
Guo YY, Li Y, Zhu TY, Ye M (2012) Effects of concentration and adsorption product on the adsorption of SO2 and NO on activated carbon. Energy Fuels. 27:360–366. https://doi.org/10.1021/ef3016975
Hadoun H, Sadaoui Z, Souami N (2013) Characterization of mesoporous carbon prepared from date stems by H3PO4 chemical activation. Appl. Surf. Sci. 280:1–7. https://doi.org/10.1016/j.apsusc.2013.04.054
Jiang SB, Yu TF, Xia R, Wang X, Gao MZ (2019) Realization of super high adsorption capability of 2D δ-MnO2 /GO through intra-particle diffusion. Mater. Chem. Phys. 232:374–381. https://doi.org/10.1016/j.matchemphys.2019.05.004
Kaghazchi T, Kolur NA, Soleimani M (2010) Licorice residue and pistachio-nut shell mixture: A promising precursor for activated carbon. J. Ind. Eng. Chem. 16:368–374. https://doi.org/10.1016/j.jiec.2009.10.002
Kamandari, H., Hashemipour, H., Saeednia, L., 2013. Experimental and modeling study on production of activated carbon from pistachio shells in rotary reactor. Res Chem Intermed. 40, 509-521. https://doi.org/10.1007/s11164-012-0978-y.
Kamandari H, Hashemipour H, Najjarzadeh H, Eksiri Z (2015) Influence of process variables on chemically activated carbon from pistachio shell with ZnCl2 and KOH. Res. Chem. Intermed. 41:71–81. https://doi.org/10.1007/s11164-013-1169-1
Kim KJ, Ahn HG (2012) The effect of pore structure of zeolite on the adsorption of VOCs and their desorption properties by microwave heating. Microporous Mesoporous Mat. 152:78–83. https://doi.org/10.1016/j.micromeso.2011.11.051
Li XQ, Zhang L, Yang ZQ, Wang P, Yan YF, Ran JY (2020) Adsorption materials for volatile organic compounds (VOCs) and the key factors for VOCs adsorption process: A review. Sep. Purif. Technol. 235:116213. https://doi.org/10.1016/j.seppur.2019.116213
Lillo-Ródenas MA, CazorlHa-Amorós D, Linares-Solano A (2005) Behaviour of activated carbons with different pore size distributions and surface oxygen groups for benzene and toluene adsorption at low concentrations. Carbon. 43:1758–1767. https://doi.org/10.1016/j.carbon.2005.02.023
Liu, Y., Guo, Y.P., Gao W., Wang, Z., Ma Y.J, Wang, Z.C., 2012a. Simultaneous preparation of silica and activated carbon from rice husk ash. J. Clean Prod. 32, 204-209. https://doi.org/10.1016/j.jclepro.2012.03.021.
Liu ZH, Qiu JR, Liu H, Tan ZQ, Yan ZQ, Zhang ML, Zeng HC, Yang H (2012b) Effects of SO2 and NO on removal of VOCs from simulated flue gas by using activated carbon fibers at low temperatures. Journal of Fuel Chemistry & Technology. 40:93–99. https://doi.org/10.1016/S1872-5813(12)60008-5
Liu J, Wang JW, Cheng J, Zhang YS, Wang T, Pan WP (2020) Distribution and emission of speciated volatile organic compounds from a coal-fired power plant with ultra-low emission technologies. J. Clean Prod. 264:121686. https://doi.org/10.1016/j.jclepro.2020.121686
Lua AC, Yang T (2004a) Properties of pistachio-nut-shell activated carbons subjected to vacuum pyrolysis conditions. Carbon. 42:224–226. https://doi.org/10.1016/j.carbon.2003.09.013
Lua AC, Yang T (2004c) Effect of activation temperature on the textural and chemical properties of potassium hydroxide activated carbon prepared from pistachio-nut shell. J. Colloid Interface Sci. 274:594–601. https://doi.org/10.1016/j.jcis.2003.10.001
Lua AC, Yang T (2004d) Effects of vacuum pyrolysis conditions on the characteristics of activated carbons derived from pistachio-nut shells. J. Colloid Interface Sci. 276:364–372. https://doi.org/10.1016/j.jcis.2004.03.071
Lua AC, Yang T (2005) Characteristics of activated carbon prepared from pistachio-nut shell by zinc chloride activation under nitrogen and vacuum conditions. J. Colloid Interface Sci. 290:505–513. https://doi.org/10.1016/j.jcis.2005.04.063
Lua AC, Yang T, Guo J (2004) Effects of pyrolysis conditions on the properties of activated carbons prepared from pistachio-nut shells. J. Anal. Appl. Pyrolysis. 72:279–287. https://doi.org/10.1016/j.jaap.2004.08.001
Ma XW, Zhang Z, Wu H, Li JJ, Yang LJ (2020) Adsorption of volatile organic compounds at medium high temperature conditions by activated carbons. Energy Fuels. 34:3679–3690. https://doi.org/10.1021/acs.energyfuels.9b03292
Marett J, Aning A, Foster EJ (2017) The isolation of cellulose nanocrystals from pistachio shells via acid hydrolysis. Ind. Crop. Prod. 109:869–874. https://doi.org/10.1016/j.indcrop.2017.09.039
Meng FY, Song M, Wei YX, Wang YL (2019) The contribution of oxygen-containing functional groups to the gas-phase adsorption of volatile organic compounds with different polarities onto lignin-derived activated carbon fibers. Environ. Sci. Pollut. Res. 26:7195–7204. https://doi.org/10.1007/s11356-019-04190-6
Niksiar A, Nasernejad B (2017) Activated carbon preparation from pistachio shell pyrolysis and gasification in a spouted bed reactor. Biomass Bioenerg. 106:43–50. https://doi.org/10.1016/j.biombioe.2017.08.017
Niksiar A, Nasernejad B (2018) Modeling of gasification reaction to produce activated carbon from pistachio shells in a spouted bed. Biomass Bioenerg. 119:97–108. https://doi.org/10.1016/j.biombioe.2018.09.008
Puziy AM, Poddubnaya OI, Socha RP, Gurgul J, Wisniewski M (2008) XPS and NMR studies of phosphoric acid activated carbons. Carbon 46:2113–2123. https://doi.org/10.1016/j.carbon.2008.09.010
Qu F, Zhu LZ, Yang K (2009) Yang Adsorption behaviors of volatile organic compounds (VOCs) on porous clay heterostructures (PCH). J. Hazard. Mater. 170:7–12. https://doi.org/10.1016/j.jhazmat.2009.05.027
Sarswata A, Mohan D (2016) Sustainable development of coconut shell activated carbon (CSAC) & magnetic coconut shell activated carbon (MCSAC) for phenol (2-nitrophenol) removal. Rsc Adv 6:85390–85410. https://doi.org/10.1039/C6RA19756F
Shafiei M, Alivand MS, Rashidi A, Samimi A, Mohebbi-Kalhori D (2018) Synthesis and adsorption performance of a modified micro-mesoporous MIL-101(Cr) for VOCs removal at ambient conditions. Chem. Eng. J. 341:164–174. https://doi.org/10.1016/j.cej.2018.02.027
Song MD, Liu XA, Zhang YH, Shao M, Lu KD, Tan QW, Feng M, Qu Y (2019) Sources and abatement mechanisms of VOCs in southern China. Atmos. Environ. 201:28–40. https://doi.org/10.1016/j.atmosenv.2018.12.019
Vijayalakshmi P, Bala VSS, Thiruvengadaravi KV, Panneerselvam P, Palanichamy M, Sivanesan S (2010) Removal of Acid Violet 17 from aqueous solutions by adsorption onto activated carbon prepared from pistachio nut shell. Sep. Sci. Technol. 46:155–163. https://doi.org/10.1080/01496395.2010.484006
Yang T, Lua AC (2003) Characteristics of activated carbons prepared from pistachio-nut shells by physical activation. J. Colloid Interface Sci. 267:408–417. https://doi.org/10.1016/S0021-9797(03)00689-1
Yang T, Lua AC (2006) Textural and chemical properties of zinc chloride activated carbons prepared from pistachio-nut shells. Mater. Chem. Phys. 100:438–444. https://doi.org/10.1016/j.matchemphys.2006.01.039
Yang K, Yang JT, Jiang Y, Wu WH, Lin DH (2016) Correlations and adsorption mechanisms of aromatic compounds on a high heat temperature treated bamboo biochar. Environ. Pollut. 210:57–64. https://doi.org/10.1016/j.jhazmat.2009.05.027
Zhang GX, Liu YY, Zheng SL, Hashisho Z (2019) Adsorption of volatile organic compounds onto natural porous minerals. J. Hazard. Mater. 364:317–324. https://doi.org/10.1016/j.jhazmat.2018.10.031
Zhang BP, Yang DJ, Qiu XQ, Qian Y, Yan MZ, Li Q (2020) Influences of aggregation behavior of lignin on the microstructure and adsorptive properties of lignin-derived porous carbons by potassium compound activation. J. Ind. Eng. Chem. 82:220–227. https://doi.org/10.1016/j.jiec.2019.10.016
Funding
Funding is acknowledged from the National Key Research and Development Program of China (2018YFB0605200).
Author information
Authors and Affiliations
Contributions
Tangying Cheng: Conceptualization; methodology; formal analysis; investigation; resources; writing—original draft, writing, review and editing.
Jinjin Li: Methodology, investigation, writing—review and editing.
Xiuwei Ma: Methodology, resources, writing—review and editing.
Lei Zhou and Hao Wu: Conceptualization; writing—review and editing; supervision.
Linjun Yang: Conceptualization; writing—review and editing, supervision, project administration, funding acquisition.
Corresponding author
Ethics declarations
Ethical approval
Not applicable.
Consent to participate
Not applicable.
Consent to publish
Not applicable.
Competing interests
The authors declare that they have no competing interests.
Additional information
Responsible Editor: Tito Roberto Cadaval Jr
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
ESM 1
(DOCX 7133 kb)
Rights and permissions
About this article
Cite this article
Cheng, T., Li, J., Ma, X. et al. The adsorption properties of microporous activated carbon prepared from pistachio nut shell for low-concentration VOCs under low-medium temperatures. Environ Sci Pollut Res 28, 65216–65228 (2021). https://doi.org/10.1007/s11356-021-14586-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-021-14586-y