Skip to main content
SpringerLink
Log in

A comparative evaluation of the performance of full-scale high-rate methane biofilter (HMBF) systems and flow-through laboratory columns

  • Sustainable Waste Management
  • Published:
Environmental Science and Pollution Research Aims and scope Submit manuscript

Abstract

Methane biofilter (MBF) technology, a cost effective method to control atmospheric emission of CH4, is usually developed as a passively aerated system to control low-volume point-source emissions such as those from landfills with gas collection systems. Actively aerated high-rate methane biofilter (HMBF) systems are designed to overcome the shortcomings of passively aerated systems by ensuring the entire filter bed is utilized for CH4 oxidation. Flow-through column experiments point to the fact that CH4 oxidation rates of actively aerated systems could be several times higher than that of passively aerated systems. However, reports of the performance of field HMBF systems are not available in literature. Furthermore, there are no studies that demonstrate the possibility of using laboratory data in the design and operation of field systems. The current study was conducted to fill this research gap and involve a comparative study of the performance of laboratory columns to field performance of a HMBF system using solution gas produced at an oil battery site as the CH4 source. The actively aerated column studies confirmed past results with high CH4 oxidation rates; one column received air at two injection points and achieved an oxidation rate of 1417 g/m3/d, which is the highest reported value to date for compost-filled columns. Subsequent studies at a specially designed field HMBF filled with compost showed a higher oxidation rate of 1919 g/m3/d, indicating the possibility of exceeding the high CH4 oxidation rates observed in the laboratory. The achievement of observed field oxidation rates being higher than those in the laboratory is attributed to the capability of maintaining higher temperatures in field HMBFs. Furthermore, results show that field HMBFs could operate at lower than stoichiometric air to CH4 ratios, and lower retention times than that of laboratory columns. Results indicated that laboratory columns may not truly represent field behavior, and said results could only be used in the preliminary design of field HMBFs.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Subscribe and save

Springer+ Basic
$34.99 /Month
  • Get 10 units per month
  • Download Article/Chapter or eBook
  • 1 Unit = 1 Article or 1 Chapter
  • Cancel anytime
Subscribe now

Buy Now

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7

Similar content being viewed by others

Explore related subjects

Discover the latest articles, news and stories from top researchers in related subjects.

References

  • Börjesson G, Sundh I, Tunlid Å, Frostegård, Svensson B H (1998) Microbial oxidation of CH4 at high partial pressures in an organic landfill cover soil under different moisture regimes. FEMS Microbiol Ecol 26, 207–217

  • De Visscher A, Thomas D, Boeckx P, Van Cleemput O (1999) Methane oxidation in simulated landfill cover soil environments. Environ Science and Technol 33:1854–1859

    Article  Google Scholar 

  • Environment Canada (2014) Canada’s sixth National Report on climate change. Canada: Canadian Government Publishing. ISBN: 978-1-100-22963-8

  • Farrokhzadeh H (2016) Performance of actively-aerated biofilters using a multiple-level air injection system to enhance biological treatment of methane emissions. MSc Thesis, University of Calgary

  • Gebert J, Groengroeft A (2006) Passive landfill gas emission - influence of atmospheric pressure and implications for the operation of methane-oxidising biofilters. Waste Manag 26:245–251

    Article  CAS  Google Scholar 

  • Haththotuwa CK (2005) Control of greenhouse gas emissions from oil production. PhD Thesis, University of Calgary

  • Haththotuwa CK, Hettiaratchi JPA, Hunte CH (2012) Actively aerated methanobiofilters to control methane emissions from landfills. Int J Environ Technol Manag 15:333–345

    Article  CAS  Google Scholar 

  • Haubrichs R, Widmann R (2006) Evaluation of aerated biofilter systems for microbial methane oxidation of poor landfill gas. Waste Manag 26(4):408–416

    Article  CAS  Google Scholar 

  • Henckel T, Jäckel U, Schnell S, Conrad R (2000) Molecular analyses of novel methanotrophic communities in forest soil that oxidize atmospheric methane. Appl Environ Microbiol 66(5):1801–1808

    Article  CAS  Google Scholar 

  • Hettiarachchi VC, Hettiaratchi PJ, Mehrotra AK, Kumar S (2011) Field-scale operation of methane biofiltration systems to mitigate point source methane emissions. Environ Pollut 159(6):1715–1720

    Article  CAS  Google Scholar 

  • Huber-Humer M, Gebert J, Hilger H (2008) Biotic systems to mitigate landfill methane emissions. Waste Manag Res 26(1):33–46

    Article  CAS  Google Scholar 

  • Johnson MR, Coderre AR (2012) Opportunities for CO2 equivalent emissions reductions via flare and vent mitigation: a case study for Alberta, Canada. Int J Greenh Gas Control 8:121–131

    Article  CAS  Google Scholar 

  • Jones H, Nedwell DB (1993) Methane emission and methane oxidation in landfill cover soil. FEMS Microbiol Ecol 102(3):185–195

    Article  CAS  Google Scholar 

  • Kightley D, Nedwell DB, Cooper M (1995) Capacity for methane oxidation in landfill cover soils measured in laboratory-scale soil microcosms. Appl Environ Microbiol 61(2):592–601

    CAS  Google Scholar 

  • Macdonald IF, El-Sayed MS, Mow K, Dullien FAL (1979) Flow through porous media-the Ergun equation revisited. Ind Eng Chem Fundam 18(3):199–208

    Article  CAS  Google Scholar 

  • Mancinelli RL (1995) The regulation of methane oxidation in soil. Annual Rev Microbiol 49:581–605

    Article  CAS  Google Scholar 

  • Myhre G, Shindell D, Bréon F M, Collins W, Fuglestvedt J, Huang J, Koch, Lamarque JF, Lee D, Mendoza B, Nakajima T, Robock A, Stephens G, Takemura T, Zhan H, and Zhang H (2013) Anthropogenic and natural radiative forcing. Climate change 2013: the physical science basis. Contribution of Working Group I to the Fifth Assessment Report of the Intergov. Panel on Climate Change [Stocker, T.F., D. Qin, G.-K. Plattner, M. Tignor, S.K. Allen, J. Boschung, A. Nauels, Y. Xia, V. Bex and P.M. Midgley (eds.)]. Cambridge University Press, Cambridge, United Kingdom and New York, NY, USA

  • Pembina Institute (2015) Economic analysis of methane emission reduction opportunities in the Canadian oil and natural gas industries. Fairfax, VA: ICF International

  • Pokhrel D (2006) Compost based biocap performance. PhD Thesis, University of Calgary

  • Stein VB, Hettiaratchi JP (2001) Methane oxidation in three Alberta soils: influence of soil parameters and methane flux rates. Environ Technol 22(1):101–111

    Article  CAS  Google Scholar 

  • Streese J, Stegmann R (2003) Microbial oxidation of methane from old landfills in biofilters. Waste Manag 23:573–580

    Article  CAS  Google Scholar 

  • Whalen SC, Reeburgh WS, Sandbeck KA (1990) Rapid methane oxidation in a landfill cover soil. Appl Environ Microbiol 56(11):3405–3411

    CAS  Google Scholar 

  • Wilshusen JH, Hettiaratchi JP, De Visscher A (2004) Methane oxidation and formation of EPS in compost: effect of oxygen concentration. Environ Pollut 129(2):305–314

    Article  CAS  Google Scholar 

Download references

Funding

The authors wish to acknowledge the funding received from the Climate Change and Emissions Management Corporation (CCEMC), Mitacs, Natural Sciences and Engineering Research Council (NSERC), and the Centre for Environmental Engineering Research and Education (CEERE) at the University of Calgary to undertake this research.

Author information

Authors and Affiliations

  1. Department of Civil Engineering and Centre for Environmental Engineering Research and Education (CEERE), Schulich School of Engineering, University of Calgary, Calgary, Alberta, T2N 1N4, Canada

    S. Samadhi Gunasekera, Joseph Patrick Hettiaratchi, Eranda M. Bartholameuz, Hasti Farrokhzadeh & Eamonn Irvine

Authors
  1. S. Samadhi Gunasekera
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Joseph Patrick Hettiaratchi
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Eranda M. Bartholameuz
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Hasti Farrokhzadeh
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Eamonn Irvine
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Joseph Patrick Hettiaratchi.

Additional information

Responsible editor: Angeles Blanco

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Gunasekera, S.S., Hettiaratchi, J.P., Bartholameuz, E.M. et al. A comparative evaluation of the performance of full-scale high-rate methane biofilter (HMBF) systems and flow-through laboratory columns. Environ Sci Pollut Res 25, 35845–35854 (2018). https://doi.org/10.1007/s11356-018-3100-1

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11356-018-3100-1

Keywords

Search

Navigation