Cu(II) removal using green adsorbents: kinetic modeling and plant scale-up design

  • Munmun Banerjee
  • Ranjan Kumar Basu
  • Sudip Kumar Das
Low cost organic and inorganic sorbents to fight soil and water pollution
  • 16 Downloads

Abstract

Cu(II) adsorption in continuous column using green adsorbents like peanut and almond shell was investigated. Fourier transform infrared (FTIR) spectroscopy, Brunaer-Emmett-Teller (BET) analysis, scanning electron microscopy (SEM), and Point of Zero charge (pHpzc) determination have been used for characterization of the adsorbents. Experiments were conducted at various operating conditions to calculate the adsorption capacity of the adsorbents. Adsorption studies signify that both the adsorbents have good adsorptive capacity for Cu(II) ion. Equilibrium of adsorption was described using Langmuir isotherm and the highest qmax value for both the adsorbent were obtained at an operating condition of 20 ml/min flow rate, 15 mg/L influent Cu(II) concentration, and 7 cm bed depth. Regeneration of both the adsorbents suggests that these adsorbents can be used several times for Cu(II) removal. Seven different kinetic models were tested among which the modified dose response model was fitted well for peanut shell and the Thomas model was fitted well for almond shell. These fitted models were further used for scale-up design. Regeneration studies show that peanut shell and almond shell are useful up to the fifth adsorption cycle. Application of these adsorbents with industrial effluent was also reported. This study reveals that peanut and almond shells can be used for Cu(II) removal for industrial wastewater.

Keywords

Adsorption Almond shell Peanut shell Influent flow rate Influent concentration Kinetic modeling 

Notes

Acknowledgements

The authors are gratefully acknowledging the Department of Science & Technology, West Bengal (Sanction No.: 21(Sanc)/ST/P/S&T/13G-1/2013 dt. 06.06.2014) for providing the research fund.

References

  1. Aber S, Salari D, Ayoubi Feiz B (2011) The sorption of copper on almond shell: optimization and kinetics. Water Sci Technol 63(7):1389–1395CrossRefGoogle Scholar
  2. Ahmari Z, Khosravi M, Niazi A (2015) Removal of Cu(II) from aqueous solution using dried activated sludge and dried activated nano-sludge: adsorption on a fixed bed column. Orient J Chem 31(2):933–938CrossRefGoogle Scholar
  3. Ahmed R, Haseeb S (2015) Competitive adsorption of Cu2+ and Ni2+ on Luffa acutangula modified tetraethoxysilane (LAP-TS) from the aqueous solution: thermodynamic and isotherm studies. Gr Water Sustain Dev 1:146–154CrossRefGoogle Scholar
  4. Ali RM, Hamad HA, Hussein Mo M, Malash GF (2016) Potential of using green adsorbent of heavy metal removal from aqueous solutions: adsorption kinetics, isotherm, thermodynamic, mechanism and economic analysis. Ecol Eng 91:317–332CrossRefGoogle Scholar
  5. Altun T, Pehlivan E (2007) Removal of Copper(II) ions from aqueous solutions by walnut, hazelnut and almond shells. Clean Soil Air Water 35(6):601–606Google Scholar
  6. Aman T, Kazi AA, Sabri MU, Bano Q (2008) Potato peels as solid waste for the removal of copper(II) from waste water/industrial effluent. Colloids Surf B: Biointerfaces 63:116–121CrossRefGoogle Scholar
  7. Banerjee M, Bar N, Basu RK, Das SK (2017) Comparative study of adsorptive removal of Cr(VI) ion from aqueous solution in fixed bed column by peanut shell and almond shell using empirical models and ANN. Environ Sci Pollut Res 24:10604–10620CrossRefGoogle Scholar
  8. Banerjee M, Bar N, Basu RK, Das SK (2018) Removal of Cr(VI) from its aqueous solution using green adsorbent pistachio shell: a fixed bed column study and GA-ANN modeling. Water Conserv Sci Eng 3:19–31CrossRefGoogle Scholar
  9. Baral SS, Das N, Ramulu TS, Sahoo SK, Das SN, Chaudhury GR (2009) Removal of Cr(VI) by thermally activated weed SalviniaCucullata in a fixed bed column. J Hazard Mater 161:1427–1435CrossRefGoogle Scholar
  10. Bharthare P, Shrivastava P, Singh P, Tiwari A (2014) Peanut shell as renewable energy source and their utility in production of ethanol. Int J Adv Res 2(4):1–14Google Scholar
  11. Bhattacharyya KG, Gupta SS (2011) Removal of Cu(II) by natural and acid-activated clays: an insight of adsorption isotherm, kinetic and thermodynamics. Desalination 272:66–75CrossRefGoogle Scholar
  12. Bishnoi N, Bajaj M, Sharma N, Gupta A (2004) Adsorption of Cr(VI) on activated rice husk carbon and activated alumina. Bioresour Technol 91:305–307CrossRefGoogle Scholar
  13. Bohart GS, Adams EQ (1920) Behaviour of charcoal towards chlorine. J Chem Soc 42:523–529CrossRefGoogle Scholar
  14. Chowdhury ZZ, Hamid SBA, Zain SM (2015) Evaluating design parameters for breakthrough curve analysis and kinetics of fixed bed columns for Cu(II) cations using lignocellulosic wastes. BioResources 10(1):732–749Google Scholar
  15. Community data of Govt. of India. Available in https://community.data.gov.in/groundnut-production-of-various-states-in-2015-16/. Accessed on 8 Jan 2018
  16. Environmental Protection Rules, (Schedule VI) of Central Pollution Control Board, Govt. of India (1986). Available: cpcb.nic.in/GeneralStandards.pdf. Seen on 27th Sept 2017
  17. Han R, Zou W, Li H, Li Y, Shi J (2006) Copper (II) and Lead(II) removal from aqueous solution in fixed bed columns by manganese oxide coated zeolite. J Hazard Mater B137:934–942CrossRefGoogle Scholar
  18. Hasfalina CM, Maryam RZ, Luqman CA, Rashid M (2012) Adsorption of copper(II) from aqueous medium in fixed bed column by kenaf fibers. APCBBE Proc 3:255–263CrossRefGoogle Scholar
  19. GAIN Report no.IN7113 dated 20.9.2017. Available on https://gain.fas.usda.gov/Recent%20GAIN%20Publications/Tree%20Nuts%20Annual_New%20Delhi_India_9-20-2017.pdf. Accessed on 8.2.2018
  20. Georgaka A, Spanos N (2010) Study of the Cu(II) removal from aqueous solutions by adsorption on titania. Glob Nest J 12(3):239–247Google Scholar
  21. Indian Standards for Drinking water (IS 10500:2012) Available on http://cgwb.gov.in/Documents/WQ-standards.pdf. Accessed on 27 Sept 2017
  22. Kafshgari F, Keshtkar AR, Musavian MA (2013) Study of Mo(VI) removal from aqueous solution: application of different mathematical models to continuous biosorption data. Iranian J Environ Health Sci Eng 10(1–11):14CrossRefGoogle Scholar
  23. Kyzas G, Kostoglou ZM (2014) Green adsorbents for wastewaters: a critical review. Materials 7:333–364CrossRefGoogle Scholar
  24. Langmuir I (1918) Theadsorption of gases on plane surfaces of glass, mica and platinum. J Am Chem Soc 40:1361–1368CrossRefGoogle Scholar
  25. Larous S, Meniai AH, Lehocine MB (2005) Experimental study of the removal of copper from aqueous solutions by adsorption using sawdust. Desalination 185:483–493CrossRefGoogle Scholar
  26. Lin X, Li R, Wen Q, Wu J, Fan J, Jin X, Qian W, Liu D, Chen X, Chen Y, Xie J, Bai J, Ying H (2013) Experimental and modeling studies on the sorption breakthrough behaviors of butanol from aqueous solution in a fixed bed of KA-I resin. Biotechnol Bioprocess Eng 18:223–233CrossRefGoogle Scholar
  27. Malkoc E, Nuhoglu Y, Dundar M (2006) Adsorption of chromium(VI) on pomace—an olive oil industry waste: batch and column study. J Hazard Mater B138:142–151CrossRefGoogle Scholar
  28. Misra V, Balomajumder C, Agarwal VK (2013) Adsorption of Cu(II) on the surface of nonconventional biomass: a study on forced convective mass transfer in packed bed column. J Waste Manag.  https://doi.org/10.1155/2013/632163
  29. Shanmugam D, Alagappan M, Rajan RK (2016) Bench-scale packed bed sorption of Cibacron blue F3GA using lucrative algal biomass. Alex Eng J.  https://doi.org/10.1016/j.aej.2016.05.012
  30. Singha B, Das SK (2011) Biosorption of Cr(VI) ions from aqueous solutions: kinetics, equilibrium, thermodynamics and desorption studies. Colloids Surf B: Biointerfaces 84:221–232Google Scholar
  31. Singha B, Das SK (2013) Adsorptive removal of Cu(II) from aqueous solution and industrial effluent using natural/ agricultural. Colloids Surf B: Biointerfaces 107:97–106CrossRefGoogle Scholar
  32. Srivastava VC, Mall ID, Mishra IM (2006) Characterization of mesoporous rice husk ash (RHA) and adsorption kinetics of metal ions from aqueous solution onto RHA. J Hazard Mater 134:257–267CrossRefGoogle Scholar
  33. Thomas HC (1944) Heterogeneous ion exchange in a flowing system. J Am Chem Soc 66(10):1664–1666CrossRefGoogle Scholar
  34. Witek-Krowiak A, Szafran R, Modelski S (2011) Biosorption of heavy metals from aqueous solutions onto peanut shell as a low-cost biosorbent. Desalination 265:126–134CrossRefGoogle Scholar
  35. Wolborska A (1989) Adsorption on activated carbon of p-nitrophenol from aqueous solution. Water Res 23:85–91CrossRefGoogle Scholar
  36. Yan GY, Viraraghavan T, Chem M (2001) A new model for heavymetal removal in a biosorptioncolumn. Adsorpt Sci Technol 19:25–43CrossRefGoogle Scholar
  37. Yoon YH, Nelson JH (1984) Application of gas adsorption kinetics II. A theoritical model for respirator cartridge service life. Am Ind Hyg Assoc J 45:509–516CrossRefGoogle Scholar

Copyright information

© Springer-Verlag GmbH Germany, part of Springer Nature 2018

Authors and Affiliations

  • Munmun Banerjee
    • 1
    • 2
  • Ranjan Kumar Basu
    • 1
  • Sudip Kumar Das
    • 1
  1. 1.Chemical Engineering DepartmentUniversity of CalcuttaKolkataIndia
  2. 2.Polymer Science and Technology DepartmentUniversity of CalcuttaKolkataIndia

Personalised recommendations