Abstract
Raw coal fly ash was activated to an adsorbent by sulfuric acid impregnation. The activation condition, the adsorption capacity, and the regenerative valorization of the adsorbent were studied. The results show that the optimal preparation conditions of the adsorbent are [H2SO4] = 1 mol L−1, activation time = 30 min, the ratio of coal fly ash to acid = 1:20 (g:mL), calcination temperature = 100 °C. The adsorption of p-nitrophenol on the adsorbent accords with the pseudo-second-order kinetic equation and the adsorption rate constant is 0.089 g mg−1 min−1. The adsorption on this adsorbent can be considered enough after 35 min, when the corresponding adsorption capacity is 1.07 mg g−1 (85.6% of p-nitrophenol removal). Compared with raw coal fly ash, the adsorbent has a stable adsorption performance at low pH range (pH = 1–6) and the adsorption of p-nitrophenol is an exothermic process. Ninety minutes is required for the regenerative valorization of saturated adsorbent by Fenton process. The regenerative valorization for this saturated adsorbent can reach 89% under the optimal proposed conditions (30 °C, pH = 3, [H2O2] = 5.0 mmol L−1, [Fe2+] = 5.5 mmol L−1). Within 15 experimental runs, the adsorbent has a better and better stability with the increase of experimental runs. Finally, the mechanism of activating coal fly ash is proposed, being verified by the results of the SEM and BET test.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Adbi J, Vossoughi M, Mahmoodi NM, Alemzadeh I (2017) Synthesis of metal-organic framework hybrid nanocomposites based on GO and CNT with high adsorption capacity for dye removal. Chem Eng J 326:1145–1158
An CJ, Yang SQ, Huang GH, Zhao S, Zhang P, Yao Y (2016) Removal of sulfonated humic acid from aqueous phase by modified coal fly ash waste: equilibrium and kinetic adsorption studies. Fuel 165:264–271. https://doi.org/10.1016/j.fuel.2015.10.069
Arroyo F, Fernandez-Pereira C, Olivares J, Coca P (2009) Hydrometallurgical recovery of germanium from coal gasification fly ash: pilot plant scale evaluation. Ind Eng Chem Res 48:3573–3579. https://doi.org/10.1021/ie800730h
Azhar MR, Abid HR, Periasamy V, Sun HQ, Tade MO, Wang SB (2017) Adsorptive removal of antibiotic sulfonamide by UiO-66 and ZIF-67 for wastewater treatment. J Colloid Interface Sci 500:88–95. https://doi.org/10.1016/j.jcis.2017.04.001
Bai YJ, Zhang AL, Zhou JT (2012) Study on treatment of methylene blue wastewater by fly ash adsorption-Fenton and thermal regeneration. Environ Sci 33:2419–2426
Bhattacharyya P, Reddy KJ (2012) Effect of flue gas treatment on the solubility and fractionation of different metals in fly ash of Powder River basin coal. Water Air Soil Pollut 223:4169–4181. https://doi.org/10.1007/s11270-012-1182-9
Bukhari SS, Behin J, Kazemian H, Rohani S (2014) Conversion of coal fly ash to zeolite utilizing microwave and ultrasound energies: a review. Fuel 140:250–266
Chen HH, Laskin A, Baltrusaitis J, Gorski CA, Scherer MM, Grassian VH (2012) Coal fly ash as a source of iron in atmospheric dust. Environ Sci Technol 46:2112–2120. https://doi.org/10.1021/es204102f
Dash S, Chaudhuri H, Gupta R, Nair UG, Sarkar A (2017) Fabrication and application of low-cost thiol functionalized coal fly ash for selective adsorption of heavy toxic metal ions from water. Ind Eng Chem Res 56:1461–1470. https://doi.org/10.1021/acs.iecr.6b03869
Emami A, Rahbar-Kelishami A (2016) Zinc and nickel adsorption onto a low-cost mineral adsorbent: kinetic, isotherm, and thermodynamic studies. Desalin Water Treat 57:21881–21892
Gao DW, Hu Q, Pan H, Jiang JP, Wang P (2015) High-capacity adsorption of aniline using surface modification of lignocellulose-biomass jute fibers. Bioresour Technol 193:507–512. https://doi.org/10.1016/j.biortech.2015.06.138
Grela A, Hebda M, Lach M, Mikula J (2016) Thermal behavior and physical characteristics of synthetic zeolite from CFB-coal fly ash. Microporous Mesoporous Mater 220:155–162. https://doi.org/10.1016/j.micromeso.2015.08.036
Hamoud HL, Finqueneisel G, Azambre B (2017) Removal of binary dyes mixtures with opposite and similar charges by adsorption coagulation/flocculation and catalytic oxidation in the presence of CeO2/HO2O2 Fenton-like system. J Environ Manag 195:195–207
Ifelebuegu AO, Ezenwa CP (2011) Removal of endocrine disrupting chemicals in wastewater treatment by Fenton-like oxidation. Water Air Soil Pollut 217:213–220. https://doi.org/10.1007/s11270-010-0580-0
Lee YR, Soe JT, Zhang SQ, Ahn JW, Park MB, Ahn WS (2017) Synthesis of nanoporous materials via recycling coal fly ash and other solid wastes: a mini review. Chem Eng J 317:821–843. https://doi.org/10.1016/j.cej.2017.02.124
Mallapur VP, Oubagaranadin JUK (2017) A brief review on the synthesis of zeolites from hazardous wastes. Trans Indian Ceram Soc 76:1–13
Martin-Hemandez M, Carrera J, Perez J, Suarez-Ojeda ME (2009) Enrichment of a K-strategist microbial population able to biodegrade p-nitrophenol in a sequencing batch reactor. Water Res 43:3871–3883. https://doi.org/10.1016/j.watres.2009.06.001
Meng FQ, Ma W, Zong PP, Wang R, Wang L, Duan CY, Wang BD (2016) Synthesis of a novel catalyst based on Fe(II)/Fe(III) oxide and high alumina coal fly ash for the degradation of o-methyl phenol. J Clean Prod 133:986–993. https://doi.org/10.1016/j.jclepro.2016.05.094
Perez-Ameneiro M, Vecino X, Barbosa-Pereira L, Cruz JM, Moldes AB (2014) Removal of pigments from aqueous solution by a calciumalginate–grape marc biopolymer: a kinetic study. Carbohydr Polym 101:954–960. https://doi.org/10.1016/j.carbpol.2013.09.091
Perez-Ameneiro M, Bustos G, Vecino X, Barbosa-Pereira L, Cruz JM, Moldes AB (2015) Heterogenous lignocellulosic composites as bio-based adsorbents for wastewater dye removal: a kinetic comparison. Water Air Soil Pollut 226:133
Samet Y, Ayadi M, Abdelhedi R (2009) Degradation of 4-Chloroguaiacol by dark Fenton and solar photo-Fenton advanced oxidation processes. Water Environ Res 81:2389–2397. https://doi.org/10.2175/106143009X425997
Sharma S, Kapoor S, Christian RA (2017) Effect of Fenton process on treatment of simulated textile wastewater: optimization using response surface methodology. Int J Environ Sci Technol 14:1665–1678. https://doi.org/10.1007/s13762-017-1253-y
Shiroudi A, Deleuze MS (2015) Reaction mechanisms and kinetics of the isomerization processes of naphthalene peroxy radicals. Comput Theor Chem 1074:26–35. https://doi.org/10.1016/j.comptc.2015.10.005
Vecino X, Devesa-Rey R, Cruz JM, Moldes AB (2013) Entrapped peat in alginate beads as green adsorbent for the elimination of dye compounds from Vinasses. Water Air Soil Pollut 224:1448
Vecino X, Devesa-Rey R, Villagrasa S, Cruz JM, Moldes AB (2015) Kinetic and morphology study of alginate-vineyard pruning waste biocomposite vs. non modified vineyard pruning waste for dye removal. J Environ Sci 38:158–167. https://doi.org/10.1016/j.jes.2015.05.032
Wang NN, Zheng T, Zhang GS, Wang P (2015) Treatment of m-nitroaniline wastewater by microwave-Cu(II)-Fenton oxidation. Chin J Environ Eng 9:351–359
Wang WX, Ye ZB, Li F (2016) Removal of oil from simulated oilfield wastewater using modified coal fly ashes. Desalin Water Treat 57:9644–9650. https://doi.org/10.1080/19443994.2015.1033470
Wang NN, Zhao Q, Zhang AL (2017) Catalytic oxidation of organic pollutants in wastewater via a Fenton-like process under the catalysis of HNO3- modified coal fly ash. RSC Adv 7:27619–27628. https://doi.org/10.1039/C7RA04451H
Xiang YL, Wang LP, Jiao YR (2016) Disintegration of excess sludge enhanced by a combined treatment of gamma irradiation and modified coal fly ash. Radiat Phys Chem 120:49–55. https://doi.org/10.1016/j.radphyschem.2015.11.035
Yildiz A, Gunes E, Amir M, Baykal A (2017) Adsorption of industrial acid red 114 onto Fe3O4@ histidine magnetic nanocomposite. Desalin Water Treat 60:261–268
Yunusa IAM, Braun M, Lawrie R (2009) Amendment of soil with coal fly ash modified the burrowing habits of two earthworm species. Appl Soil Ecol 42:63–68. https://doi.org/10.1016/j.apsoil.2009.02.002
Zaharia C (2015) Application of waste materials as “low cost” sorbents for industrial effluent treatment: a comparative overview. Int J Mater Prod Technol 50:196–220. https://doi.org/10.1504/IJMPT.2015.068524
Zaharia C, Suteu D (2013) Coal fly ash as adsorptive material for treatment of a real textile effluent: operating parameters and treatment efficiency. Environ Sci Pollut Res Int 20:2226–2235. https://doi.org/10.1007/s11356-012-1065-z
Zaharia C, Suteu D, Muresan A, Muresan R, Popescu A (2009) Textile wastewater treatment by homogeneous oxidation with hydrogen peroxide. Environ Eng Manag J 8:1359–1369
Zhang AL, Wang NN, Zhou JT, Jiang P, Liu GF (2012) Heterogeneous Fenton-like catalytic removal of p-nitrophenol in water using acid-activated fly ash. J Hazard Mater 201-202:68–73. https://doi.org/10.1016/j.jhazmat.2011.11.033
Zhang ZY, Qiao XC, Yu JG (2015) Aluminum release from microwave-assisted reaction of coal fly ash with calcium carbonate. Fuel Process Technol 134:303–309. https://doi.org/10.1016/j.fuproc.2014.12.050
Zhang KH, Zhang DX, Zhang K (2016) Arsenic removal from water using a novel amorphous adsorbent developed from coal fly ash. Water Sci Technol 73:1954–1962. https://doi.org/10.2166/wst.2016.028
Zhu XY, Ma YP, Liu Y, Yang ZM, Li QS, Zhou ZY, Ren ZQ (2017) Synthesis of a Fe/AC Fenton-like catalyst and heterogeneous catalysis in decolorization of sunset yellow by pulsed high-voltage discharge. J Chem Technol Biotechnol 92:1970–1979. https://doi.org/10.1002/jctb.5184
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible editor: Philippe Garrigues
Rights and permissions
About this article
Cite this article
Wang, N., Hao, L., Chen, J. et al. Adsorptive removal of organics from aqueous phase by acid-activated coal fly ash: preparation, adsorption, and Fenton regenerative valorization of “spent” adsorbent. Environ Sci Pollut Res 25, 12481–12490 (2018). https://doi.org/10.1007/s11356-018-1560-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-018-1560-y