Summary
Molasses-based distilleries produce large quantities of dark coloured effluent, which is a major cause of environmental pollution. An experiment was conducted to investigate the efficacy of distillery effluent amendment for edible mushroom production. Three species of oyster mushroom, namely Pleurotus florida Eger (EM 1303), Pleurotus pulmonarius (Fries) Quelet (EM 1302) and Pleurotus sajor-caju (Fries) Singer (EM 1304) were grown on wheat straw (variety UP 2338) and bagasse amended with post-anaerobic distillery effluent, a high organic load wastewater with high biochemical oxygen demand and chemical oxygen demand. Three different levels of effluent treatment were applied to bagasse and wheat straw. Wheat straw was found to be the preferred substrate and showed better results than bagasse in all treatments with respect to yield, biological efficiency (BE) and dry matter loss. P. florida (EM 1303) and P. pulmonarius (EM 1302) gave significantly enhanced yield with increasing levels of effluent, with BE reaching highest at 238.6% for P. florida (EM 1303). Using bagasse as a substrate, P. sajor-caju (EM 1304) and P.␣pulmonarius (EM 1302) exhibited a decreasing trend as compared to control. However, the effect of effluent concentrations did not influence yield and BE significantly in case of bagasse. The dry matter loss of the substrate varied from 9.4% to 53.4% in wheat straw and 17.5% to 45.2% in bagasse respectively.
Similar content being viewed by others
References
Adamovic M., Grubic G., Milenkovic I., Jovanovic R., Protic R., Sretenovic L., Stoicevic Lj., 1998 The biodegradation of wheat straw by Pleurotus ostreatus mushrooms and its use in cattle feeding Animal Feed Science and Technology 71:357–362
Aksu, S., Isik, S.E. & Erkal, S. 1996 Development of cultivated mushroom production in Turkey and general characteristics of mushroom establishment. In Fifth National Congress of Edible Mushrooms, November 5–7, 1996, Turkey, pp. 1–13
APHA 1995 Standard methods for the examination of water and wastewater. 19th edn. American Public Health Association, Washington, DC. ISBN 0875532233
Banik S., Nandi R., 2004 Effect of supplementation of rice straw with biogas residual slurry manure on the yield, protein and mineral contents of oyster mushroom Industrial Crops and Products 20:311–319
Beltran F.J., Garcia-Araya J.F., Alvarez P.M., 1999 Wine distillery wastewater degradation. 1. Oxidative treatment using ozone and its effect on the wastewater biodegradability Journal of Agricultural and Food Chemistry 47:3911–3918
Bisaria R., Madan M., Bisaria V.S., 1987 Biological efficiency and nutritive value of Pleurotus sajor-caju cultivated on different agro-wastes Biological Wastes 19:239–255
Chang S.T., 1996 Mushroom research and development equality and mutual benefit. In Royse D.J, ed. Mushroom Biology and Mushroom Products, State College: the Pennsylvania State University pp. 1–10 ISBN 1-883956-01-3
Croan S., 2000 Conversion of wood waste into value-added products into edible and medicinal Pleurotus (F.) P. Karst. Species (Agaricales sl., Basidiomycetes) International Journal of Medicinal Mushrooms 2:73–80
FitzGibbon F., Singh D., McMullan G., Marchant R., 1998 The effect of phenolic acids and molasses spent wash concentration on distillery wastewater remediation by fungi Process Biochemistry 33:799–803
Kakkar V.K., Dhanda S., 1998 Comparative evaluation of wheat and paddy straws for mushroom production and feeding residual straws to ruminants Bioresource Technology 66:175–177
Kalmis E., Sargin S., 2004 Cultivation of two Pleurotus species on wheat straw substrates International Biodeterioration and Biodegradation 53:43–47
Kannabiran B., Pragasam A. 1993 Effect of distillery effluent on seed germination, seedling growth and pigment content of Vigna mungo (L.) Hepper (CVT9) Geobios 20:108–112
Madan M., Vasudevan P., Sharma S., 1987 Cultivation of Pleurotus sajor-caju on different wastes Biological Wastes 22:241–250
Miller G.L., 1959 Use of dinitrosalicylic acid reagent for determination of reducing sugar Analytical Chemistry 31:426–428
Muthukrishnan N., Venugopal M.S., Janarthanan R., 2000 Recycling spent larval food of Corcyra cephalonica Stainton for preparing spawn and sporophore of Pleurotus sajor-caju (Fr.) Singer World Journal of Microbiology and Biotechnology 16:265–270
Nandy T., Shastry S., Kaul S.N., 2002 Wastewater management in a cane molasses distillery involving bioresource recovery Journal of Environmental Management, 65:25–38
Pandey A., Soccol C.R., Nigam P., Soccol V.T., 2000 Biotechnological potential of agro-industrial residues. I: Sugarcane Bagasse Bioresource Technology 74:69–80
Pathak H., Joshi H.C., Chaudhary A., Kalra N., Dwivedi M.K., 1999 Soil amendment with distillery effluent for wheat and rice cultivation Water, Air, Soil Pollution 113:133–140
Philippoussis A., Zervakis G., Diamantopoulou P., 2001 Bioconversion of agricultural lignocellulosic wastes through the cultivation of the edible mushrooms Agrocybe aegerita, Volvariella volvacea and Pleurotus spp World Journal of Microbiology and Biotechnology 17:191–200
Poppe, J.A. & Hofte, M. 1995 Twenty wastes for twenty cultivated mushrooms. In Proceedings of the 14th International Congress on the Science and Cultivation of Edible fungi, Oxford, pp. 171–179. Rotterdam, Balkema, ISBN 9054105712 (v.1) and 9054105720 (v.2)
Quimio J.H., 1978 Introducing Pleurotus flabellatus for your dinner table Mushroom Journal 68:282–283
Ramana S., Biswas A.K., Singh A.B., 2002 Effect of distillery effluent on some physiological aspects of maize Bioresource Technology 84:295–297
Stamets P., 2000 Growing Gourmet and Medicinal Mushrooms 3 Ten Speed Press, Berkley, California, pp. 201–325. ISBN 1580081754
Somogyi M., 1952 Notes on sugar determination. Journal of Biological Chemistry 195:19–23
Uppal, J. 2004 Water Utilization and Effluent Treatment in the Indian Alcohol Industry – An Overview. In Liquid Assets, Proceedings of Indo-EU workshop on Promoting Efficient Water Use in Agro-based Industries, New Delhi 15–16 January 2004, pp. 13–19. TERI Press, New Delhi, India
Velázquez-Cedeño M.A., Mata G., Savoie J.M., 2002 Waste-reducing cultivation of Pleurotus ostreatus and Pleurotus pulmonarius on coffee pulp: changes in the production of some lignocellulolytic enzymes World Journal of Microbiology and Biotechnology 18:201–207
Yang F.C., Tung H.L., 1996 Reuse of stillage from rice spirit for the culture of the yeast Saccharomyces cerevisiae Process Biochemistry 31:617–620
Yang F.C., Hsieh C., Chen H.M., 2003 Use of stillage grain from a rice-spirit distillery in the solid-state fermentation of Ganoderma lucidum Process Biochemistry 39:21–26
Zadrazil F., 1980 Influence of ammonia nitrate and organic supplements on the yield of Pleurotus sajor-caju European Journal of Applied Microbiology and Biotechnology 9:31–35
Zadrazil F., Kamara D.N., Isikhuemhen O.S., Schuhardt F., Lachowsku G., 1996 Bioconversion of lignocellulose into ruminant feed with white rot fungi- review of work done at the FAL Braunschweig Journal of Applied Animal Research 10:105–124
Zhang R., Xiujin L., Fadel J.G., 2002 Oyster mushroom cultivation with rice and wheat strawBioresource Technology 82:277–284
Acknowledgements
Authors wish to thank Dr. R. K. Pachauri, Director-General, TERI, New Delhi, India for offering the infrastructure for carrying out the present investigation. Financial assistance from University Grants Commission, New Delhi in form of Junior Research Fellowship to the first author is duly acknowledged.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Pant, D., Reddy, U.G. & Adholeya, A. Cultivation of oyster mushrooms on wheat straw and bagasse substrate amended with distillery effluent. World J Microbiol Biotechnol 22, 267–275 (2006). https://doi.org/10.1007/s11274-005-9031-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11274-005-9031-2