Abstract
To promote the application of microbially induced mineralization technology in the field of coal dust suppression, two urease-producing bacteria were co-cultured, with the aim to define the influence of different culture conditions on the growth and urease activity of the bacteria. According to the results, when S. pasteurii and B. cereus CS1 were inoculated in succession at a volume ratio of 1:1 and an interval of 14 h, the mixed bacteria achieved optimal growth and had the highest urease activity; when the initial pH value of culture medium was 9 and the urea and Ca2+ concentrations in the substrate were uniformly 0.1 mol/L, the growth and urease activity of the mixed bacterial culture reached their peaks. SEM-EDS and XRD results indicated that, regardless of the specific urease-producing bacteria used (single urease-producing bacteria or the mixed urease-producing bacteria), their mineralization products were uniformly vaterite-type and calcite-type calcium carbonate; FTIR and thermogravimetric analysis also confirmed their mineralization products as calcium carbonate. By spraying the bacterial inoculants with a corresponding calcium source and urea on pulverized coal, it was found that the bacteria successfully survived and caused pulverized coal to be consolidated. In particular, the mixed bacterial inoculant manifested a stronger consolidation effect, with a wind erosion–induced mass loss of less than 20 g/(m2•h). We provide experimental support for the field of microbial coal dust suppression.
Similar content being viewed by others
References
Badiee, H., Sabermahani, M., Tabandeh, F., & Javadi, A. S. (2019). Application of an indigenous bacterium in comparison with Sporosarcina pasteurii for improvement of fine granular soil. International journal of Environmental Science and Technology, 16(12), 8389–8400.
Cheng, L., Qian, C. X., Wang, R. X., & Wang, J. Y. (2007). Study on kinetics and morphology of formation of CaCO3 crystal induced by carbonate-mineralization microbe. Journal of Functional Materials, 9(38), 1511–1515.
Dejong, J. T., Mortensen, B. M., Martinez, B. C., & Nelson, D. C. (2010). Bio-mediated soil improvement. Ecological Engineering, 36(2), 197–210.
Dejong, J. T., Soga, K., Kavazanjian, E., Burns, S., van Paassen, L. A., AL Qabany, A., et al. (2013). Biogeochemical processes and geotechnical applications: progress, opportunities and challenges. Geotechnique, 63(4), 287–301.
Fan, T., Zhou, G., & Wang, J. Y. (2018). Preparation and characterization of a wetting-agglomeration-based hybrid coal dust suppressant. Process Safety and Environmental Protection, 113, 282–291.
Fernandes, P. (2006). Applied microbiology and biotechnology in the conservation of stone cultural heritage materials. Applied Microbiology and Biotechnology, 73(2), 291–296.
Harkes, M. P., van Paassen, L. A., Booster, J. L., Whiffin, V. S., & van Loosdrecht, M. C. M. (2010). Fixation and distribution of bacterial activity in sand to induce carbonate precipitation for ground reinforcement. Ecological Engineering, 36(2), 112–117.
Kang, C. H., Kwon, Y. J., & So, J. S. (2016). Bioremediation of heavy metals by using bacterial mixtures. Ecological Engineering, 89(17), 64–69.
Khaleghi, M., & Rowshanzamir, M. A. (2019). Biologic improvement of a sandy soil using single and mixed cultures: a comparison study. Soil and Tillage Research, 186, 112–119.
Li, P. H., & Qu, W. J. (2009). Mechanism and performance of remediation for historic buildings by bacterially induced mineralization. Journal of the Chinese Ceramic Society, 37(4), 497–505.
Li, C., Zhu, F. H., Fu, X. M., Fu, G. M., & Shu, X. Q. (2013). Research into development of dust depressor and major problems existing in this area. Environmental Engineering, 31(s1), 360–362+392.
Li, D., Tian, K. L., Zhang, H. L., Wu, Y. Y., Nie, K. Y., & Zhang, S. C. (2018). Experimental investigation of solidifying desert aeolian sand using microbially induced calcite precipitation. Construction and Building Materials, 172, 251–262.
Ma, Y. L., Zhou, G., Ding, J. F., Li, S. L., & Wang, G. (2018). Preparation and characterization of an agglomeration-cementing agent for dust suppression in open pit coal mining. Cellulose, 25(7), 4011–4029.
Moravej, S., Habibagahi, G., Nikooee, E., & Niazi, A. (2018). Stabilization of dispersive soils by means of biological calcite precipitation. Geoderma, 315, 130–137.
Okwadha, G. D. O., & Li, J. (2010). Optimum conditions for microbial carbonate precipitation. Chemosphere, 81, 1143–1148.
Qabany, A. A., & Soga, K. (2013). Effect of chemical treatment used in MICP on engineering properties of cemented soils. Geotechnique, 63(4), 331–339.
Qian, C. X., Wang, R. X., Cheng, L., & Wang, J. Y. (2010). Theory of microbial carbonate precipitation and its application in restoration of cement-based materials defects. Chinese Journal of Chemistry, 28(5), 847–857.
Soon, N. W., Lee, L. M., Khun, T. C., & Ling, H. S. (2013). Improvements in engineering properties of soils through microbial-induced calcite precipitation. KSCE Journal of Civil Engineering, 17(4), 718–728.
Tang, W. J., & Cai, Q. X. (2018). Dust distribution in open-pit mines based on monitoring data and fluent simulation. Environmental Monitoring and Assessment, 190(11), 632.
Terzis, D., & Laloui, L. (2019). A decade of progress and turning points in the understanding of bio-improved soils: A review. Geomechanics for Energy and the Environment, 19, 100116.
Wang, R. X. (2009). Microbial regulation of calcium carbonate formation and its application in defect repair of cement-based materials. Dissertation, Southeast University.
Wang, C. Q., Lin, B. Q., Li, Q. Z., & Dai, H. M. (2014). Effects of oxygen containing functional groups on coal dust wettability. Safety in Coal Mines, 45(05), 173–176.
Wang, J. Y., Jonkers, H. M., Boon, N., & De Belie, N. (2017). Bacillus sphaericus LMG22257 is physiologically suitable for self-healing concrete. Applied Microbiology and Biotechnology, 101(12), 5101–5114.
Wang, H. T., Wei, X. B., Du, Y. H., & Wang, D. M. (2019a). Effect of water-soluble polymers on the performance of dust-suppression foams: Wettability, surface viscosity and stability. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 568, 92–98.
Wang, X. N., Yuan, S. J., Li, X., & Jiang, B. Y. (2019b). Synergistic effect of surfactant compounding on improving dust suppression in a coal mine in Erdos, China. Powder Technology, 344, 561–569.
Wang, M., Zhao, X. Q., Tang, D., Wang, H., & Zhang, W. Y. (2019c). Bioremediation of Cd-contaminated water using calcium carbonate precipitation induced by bacterial mixtures. Chinese Journal of Environmental Engineering, 13(7), 1541–1549.
Whiffin, V. S. (2004). Microbial CaCO3 precipitation for the production of biocement. Dissertation, Murdoch University.
Wu, Q. Y., Han, L., Xu, M., Zhang, H. D., Ding, B. M., & Zhu, B. L. (2019a). Effects of occupational exposure to dust on chest radiograph, pulmonary function, blood pressure and electrocardiogram among coalminers in an eastern province, China. BMC Public Health, 19(1), 1229.
Wu, M. Y., Hu, X. M., Zhang, Q., Xue, D., & Zhao, Y. Y. (2019b). Growth environment optimization for inducing bacterial mineralization and its application in concrete healing. Construction and Building Materials, 209, 631–643.
Xi, Z. L., Jin, L. W., Richard, L. J., & Li, D. (2018). Characteristics of foam sol clay for controlling coal dust. Powder Technology, 335, 401–408.
Xue, J. L., Wu, Y. N., Shi, K., Xiao, X. F., Gao, Y., Li, L., & Qiao, Y. L. (2019). Study on the degradation performance and kinetics of immobilized cells in straw-alginate beads in marine environment. Bioresource Technology, 280, 88–94.
Yu, X. N., Qian, C. X., & Jiang, J. G. (2018). The influence of curing time on properties of the sand columns cemented by bio-barium phosphate. Construction and Building Materials, 188, 255–261.
Yu, X. N., Qian, C. X., & Jiang, J. G. (2019a). Desert sand cemented by bio-magnesium ammonium phosphate cement and its microscopic properties. Construction and Building Materials, 200, 116–123.
Yu, X. N., Zhan, Q. W., Qian, C. X., Ma, J. J., & Liang, Y. (2019b). The optimal formulation of bio-carbonate and bio-magnesium phosphate cement to reduce ammonia emission. Journal of Cleaner Production, 240, 118156.
Zhan, Q. W., Qian, C. X., & Yi, H. H. (2016). Microbial-induced mineralization and cementation of fugitive dust and engineering application. Construction and Building Materials, 121, 437–444.
Zhang, J. G., Zhou, A. J., Liu, Y. Z., Zhao, B. W., Luan, Y. B., Wang, S. F., Yue, X. P., & Li, Z. (2017). Microbial network of the carbonate precipitation process induced by microbial consortia and the potential application to crack healing in concrete. Scientific Reports, 7, 14600.
Zhang, H. H., Nie, W., Wang, H. K., Bao, Q., Jin, H., & Liu, Y. H. (2018). Preparation and experimental dust suppression performance characterization of a novel guar gum-modification-based environmentally-friendly degradable dust suppressant. Powder Technology, 339, 214–325.
Acknowledgments
We thank funding and support on the study from the National Key Technologies R&D Program of China (2018YFC0807900); the National Natural Science Foundation of China(51674038, 51874193); the Shandong Province Natural Science Foundation (ZR2018JL019, ZR2017PEE024); the Shandong Province Science and Technology Development Plan (2017GSF220003); Scientific Research Foundation of Shandong University of Science and Technology for Recruited Talents (2017RCJJ010, 2017RCJJ037); and Shandong Province First-Class Subject Funding Project (01AQ05202).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of Interest
The authors declare that they have no conflicts of interest.
Ethical Statement
This article does not contain any studies with human participants or experimental animals by any of the authors.
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Zhu, S., Hu, X., Zhao, Y. et al. Coal Dust Consolidation Using Calcium Carbonate Precipitation Induced by Treatment with Mixed Cultures of Urease-Producing Bacteria. Water Air Soil Pollut 231, 442 (2020). https://doi.org/10.1007/s11270-020-04815-4
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11270-020-04815-4