Abstract
A series of nickel phosphide catalysts supported on ultrastable Y zeolites USY (Si/Al = 40) with microporous/mesoporous structure were prepared by impregnation and temperature-programmed reduction and were studied for the hydrodeoxygenation (HDO) of 2-methyltetrahydrofuran (2-MTHF). The loading of the active phase was varied from 0.58, 1.16, and 1.74 to 2.3 mmol (g support)−1 and the corresponding samples were denoted as 0.5, 1.0, 1.5, and 2.0 Ni2P/USY. The two lowest loading supports did not show X-ray diffraction (XRD) lines, but X-ray absorption fine-structure spectroscopy (XAFS) indicated the formation of a Ni2P phase, with low Ni–Ni coordination, consistent with high dispersion. The two highest loading supports showed XRD patterns typical of Ni2P, and XAFS indicated similar bond distances to bulk Ni2P and high Ni–Ni coordination. Furthermore, the XAFS data indicated that the low-loading samples had shorter bond distances and more Ni in square-pyramidal coordination compared to the high loading samples and the reference Ni2P material, suggesting that there were differences in structural properties in the samples. This likely was due to preferred termination of the small crystallites with pyramidal Ni sites. The HDO of 2-MTHF was studied at 0.5 MPa and 513–593 K and the main products were n-pentane and n-butane for all catalysts. The low-loading samples showed higher turnover frequency (based on sites titrated by CO chemisorption), and this was attributed to the higher intrinsic activity of the pyramidal Ni sites. In addition, the low-loading samples showed higher selectivity to n-pentane, and this was attributed to lower C–C hydrogenolysis type reactions, which are favored by metallic ensembles as found in the high-loading samples.
Similar content being viewed by others
References
Ruddy DA, Schaide JA, Ferrell JR III, Wang J, Moen L, Hensley JE (2014) Recent advances in heterogeneous catalysts for bio-oil upgrading via “ex situ catalytic fast pyrolysis”: catalyst development through the study of model compounds. Green Chem 16:454–490
Moon J-S, Kim E-G, Lee Y-K (2014) Active sites of Ni2P/SiO2 catalyst for hydrodeoxygenation of guaiacol: a joint XAFS and DFT study. J Catal 311:144–152
Serrano-Ruiz JC, Dumesic JA (2011) Catalytic routes for the conversion of biomass into liquid hydrocarbon transportation fuels. Energy Environ Sci 4:83–99
Bulushev DA, Ross JRH (2011) Catalysis for conversion of biomass to fuels via pyrolysis and gasification: a review. Catal Today 171:1–13
Chang J, Danuthai T, Dewiyanti S, Wang C, Borgna A (2013) Hydrodeoxygenation of guaiacol over carbon-supported metal catalysts. Chem Cat Chem 5:3041–3049
Furimsky E (2013) Hydroprocessing challenges in biofuels production. Catal Today 217:13–56
Panwar NL, Kothari R, Tyagi VV (2012) Themo chemical conversion of biomass-Eco friendly energy routes. Renew Sustain Energy Rev 16:1801–1813
Bridgwater AV (2012) Review of fast pyrolysis of biomass and product upgrading. Biomass Bioenergy 38:68–94
Czernik S, Bridgwater AV (2004) Overview of applications of biomass fast pyrolysis oil. Energy Fuels 18:590–598
Mohan D, Pittman CU Jr, Steele PH (2006) Pyrolysis of wood/biomass for bio-oil: a critical review. Energy Fuels 20:848–889
Custodis YBF, Hemberger P, Ma Z, van Bokhoven JA (2014) Mechanism of fast pyrolysis of lignin: studying model compounds. J Phys Chem B 118:8524–8531
Moraes MSA, Migliorini MV, Damasceno FC, Georges F, Almeida S, Zini CA, Jacques RA, Caramão EBJ (2012) Qualitative analysis of bio oils of agricultural residues obtained through pyrolysis using comprehensive two dimensional gas chromatography with time-of-flight mass spectrometric detector. J Anal Appl Pyrol 98:51–64
Zhang Q, Chang J, Wang T, Xu Y (2007) Review of biomass pyrolysis oil properties and upgrading research. Energy Convers Manage 48:87–92
Mortensen PM, Grunwaldt J-D, Jensen PA, Knudsen KG, Jensen AD (2011) A review of catalytic upgrading of bio-oil to engine fuels. Appl Catal A 407:1–19
Boullosa-Eiras S, Lødeng R, Bergem H, Stöcker M, Hannevold L, Blekkan EA (2014) In: Spivey JJ, Han YF, Dooley KM (eds) Potential for metal-carbide, -nitride, and -phosphide as future hydrotreating (HT) catalysts for processing of bio-oils. Catalysis, A Specialist Periodical Report, vol 2. Royal Society of Chemistry, London
Şenol Oİ, Viljava T-R, Krause AOI (2007) Effect of sulphiding agents on the hydrodeoxygenation of aliphatic esters on sulphided catalysts. Appl Catal A 326:236–244
Şenol Oİ, Ryymin E-M, Viljava TR, Krause AOI (2007) Reactions of methyl heptanoate hydrodeoxygenation on sulphided catalysts. J Mol Catal A 268:1–8
Ryymin E-M, Honkela ML, Viljava TR, Krause AOI (2009) Insight to sulfur species in the hydrodeoxygenation of aliphatic esters over sulfided NiMo/γ-Al2O3 catalyst. Appl Catal A 358:42–48
Romero Y, Richard F, Brunet D (2010) Hydrodeoxygenation of 2-ethylphenol as a model compound of bio-crude over sulfided Mo-based catalysts: promoting effect and reaction mechanism. Appl Catal B 98:213–223
Bui VN, Laurenti D, Afanasiev P, Geantet C (2011) Hydrodeoxygenation of guaiacol with CoMo catalysts. Part I: promoting effect of cobalt on HDO selectivity and activity. Appl Catal B 101:239–245
Gutierrez A, Kaila RK, Honkela ML, Slioor R, Krause AOI (2009) Hydrodeoxygenation of guaiacol on noble metal catalysts. Catal Today 147:239–246
Chen L, Zhu Y, Zheng H, Zhang C, Zhang B, Li Y (2011) Aqueous-phase hydrodeoxygenation of carboxylic acids to alcohols or alkanes over supported Ru catalysts. J Mol Catal A 351:239–252
Bunch AY, Wang X, Ozkan US (2007) Hydrodeoxygenation of benzofuran over sulfided and reduced Ni–Mo/γ-Al2O3 catalysts: effect of H2S. J Mol Catal A 270:264–272
Yakovlev VA, Khromova SA, Sherstyuk OV, Dundich VO, Ermakov DY, Novopashina VM, Lebedev MY, Bulavchenko O, Parmon VN (2009) Development of new catalytic systems for upgraded bio-fuels production from bio-crude-oil and biodiesel. Catal Today 144:362–366
Echeandia S, Arias PL, Barrio VL, Pawelec B, Fierro JLG (2010) Synergy effect in the HDO of phenol over Ni–W catalysts supported on active carbon: effect of tungsten precursors. Appl Catal B 101:1–12
Oyama ST (2003) Novel catalysts for advanced hydroprocessing: transition metal phosphides. J Catal 216:343–352
Korányi TI (2003) Phosphorus promotion of Ni (Co)-containing Mo-free catalysts in thiophene hydrodesulfurization. Appl Catal A 239:253–267
Sawhill SJ, Layman KA, Van Wyk DR, Engelhard MH, Wang C, Bussell ME (2005) Thiophene hydrodesulfurization over nickel phosphide catalysts: effect of the precursor composition and support. J Catal 231:300–313
Lee Y-K, Shu Y, Oyama ST (2007) Active phase of a nickel phosphide (Ni2P) catalyst supported on KUSY zeolite for the hydrodesulfurization of 4,6-DMDBT. Appl Catal A 322:191–201
Oyama ST, Lee Y-K (2008) The active site of nickel phosphide catalysts for the hydrodesulfurization of 4,6-DMDBT. J Catal 258:393–400
Oyama ST, Gott T, Zhao H, Lee Y-K (2009) Transition metal phosphide hydroprocessing catalysts: a review. Catal Today 143:94–107
Zhao HY, Li D, Bui P, Oyama ST (2011) Hydrodeoxygenation of guaiacol as model compound for pyrolysis oil on transition metal phosphide hydroprocessing catalysts. Appl Catal A 391:305–310
Whiffen VML, Smith KJ, Straus SK (2012) The influence of citric acid on the synthesis and activity of high surface area MoP for the hydrodeoxygenation of 4-methylphenol. Appl Catal A 419:111–121
Yang Y, Ochoa-Hernández C, O’Shea VAP, Coronado JM, Serrano DP (2012) Ni2P/SBA-15 as a hydrodeoxygenation catalyst with enhanced selectivity for the conversion of methyl oleate into n-octadecane. ACS Catal 2:592–598
Eiras SB, Lødeng R, Bergem H, Stöcker MW, Hannevold L, Blekkan EA (2014) Catalytic hydrodeoxygenation (HDO) of phenol over supported molybdenum carbide, nitride, phosphide and oxide catalysts. Catal Today 223:44–53
Echeandia S, Pawalec B, Barrio VL, Arias PL, Cambra JF, Loricera CV, Fierro JLG (2014) Enhancement of phenol hydrodeoxygenation over Pd catalysts supported on mixed HY zeolite and Al2O3, An approach to O-removal from bio-oils. Fuel 117:1061–1073
Bando KK, Koike Y, Kawai T, Tateno G, Oyama ST, Inada Y, Nomura M, Asakura K (2011) Quick X-ray absorption fine structure studies on the activation process of Ni2P supported on K-USY. J Phys Chem C 115:7466–7471
Iino A, Cho A, Takagaki A, Kikuchi R, Oyama ST (2014) Kinetic studies of hydrodeoxygenation of 2-methyltetrahydrofuran on a Ni–2P/SiO2 catalyst at medium pressure. J Catal 311:17–27
Shin J, Cho A, Takagaki A, Kikuchi R, Oyama ST (2012) Ligand and ensemble effects in bimetallic NiFe phosphide catalysts for the hydrodeoxygenation of 2-methyltetrahydrofuran. Top Catal 55:969–980
Bui P, Cecilia JA, Oyama ST, Takagaki A, Infantes-Molina A, Zhao H, Li D, Rodríguez-Castellón E, Jiménez López A (2012) Studies of the synthesis of transition metal phosphides and their activity in the hydrodeoxygenation of a biofuel model compound. J Catal 294:184–198
Li W, Dhandapani B, Oyama ST (1998) Molybdenum phosphide: a novel catalyst for hydrodenitrogenation. Chem Lett 3:207–208
Ankudinov AL, Ravel B, Rehr JJ, Conradson SD (1998) Real-space multiple-scattering calculation and interpretation of x-ray-absorption near-edge structure. Phys Rev B 58:7565–7576
Lee Y-K, Oyama ST (2006) Bifunctional nature of a SiO2-supported Ni2P catalyst for hydrotreating: eXAFS and FTIR studies. J Catal 239:376–389
Janssen AH, Koster AJ, Jong KP (2001) Three-Dimensional Transmission Electron Microscopic Observations of Mesopores in Dealuminated Zeolite Y. Angew Chem Int Ed 40:1102–1104
Rundqvist S (1962) X-Ray investigations of Mn3P, Mn2P, and Ni2P. Acta Chem Scand 16:992–998
Wang X, Clark P, Oyama ST (2002) Synthesis, characterization, and hydrotreating activity of several iron group transition metal phosphides. J Catal 208:321–331
Cho A, Kim H, Iino A, Takagaki A, Oyama ST (2014) Kinetic and FTIR studies of 2-methyltetrahydrofuran hydrodeoxygenation on Ni2P/SiO2. J Catal 318:151–161
Boudart M (1969) Catalysis by metals. Adv Catal Rel Subj 20:153–166
Acknowledgments
This work was supported by Development of Next-generation Technology for Strategic Utilization of Biomass Energy of New Energy and Industrial Technology Development Organization (NEDO), Japan and JSPS KAKENHI Grant Number 26289301, the National Science Foundation under Grant CHE-1361842 and the US Department of Energy under Grant DE-FG02-96ER14669. The XAFS experiments were conducted under approval of PF-PAC (Project No. 2012G655).
Author information
Authors and Affiliations
Corresponding author
Electronic supplementary material
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Cho, A., Takagaki, A., Kikuchi, R. et al. Active Sites in Ni2P/USY Catalysts for the Hydrodeoxygenation of 2-Methyltetrahydrofuran. Top Catal 58, 219–231 (2015). https://doi.org/10.1007/s11244-015-0363-3
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11244-015-0363-3