Skip to main content
SpringerLink
Log in

Magnetic Properties of a Material Used to Estimate Elastic and Plastic Strains of Ferrite—Pearlite Steels

  • Magnetic Methods
  • Published:
Russian Journal of Nondestructive Testing Aims and scope Submit manuscript

Abstract

The effect of elastic and plastic strains on the magnetic properties of ferrite-pearlite steels has been studied. It has been shown that the sensitivity to elastic-tensile and bending strains is four to five times greater for remnant magnetization than for coercive force. In order to determine the degree of cold plastic deformation of high-carbon steels, a two-parametric testing technique based on the use of remnant magnetization and coercive force was suggested. An MMT-2 device was recommended for measurement of the required parameters.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

REFERENCES

  1. Becker, R. and Doring, W., Ferromagnetismus, Berlin: Springer, 1939.

    Google Scholar 

  2. Vonsovskii, S.V. and Shur, Ya.S., Ferromagnetizm (Ferromagnetism), Moscow-Leningrad: OGIZ, 1948.

    Google Scholar 

  3. Bozorth, R.M., Ferromagnetism, New York: D. van Nostrand, 1951; translated under the title Ferromagnetizm, Moscow: Izd. Inostrannoi Literatury, 1956.

    Google Scholar 

  4. Chikasumi, S., Physics of Ferromagnetism. Magnetic Characteristics and Engineering Application, Tokyo: Syokabo, 1984. Translated under the title: Fizika ferromagnetizma. Magnitnye kharakteristiki i prakticheskie primeneniya, Moscow: Mir, 1987.

    Google Scholar 

  5. Brown, W.F., Influence of Field and Stress on Magnetization Changes, Phys. Rev., 1949, vol. 75, pp. 147–158.

    Google Scholar 

  6. Ivayanagi, D., Nondestructive Mangetic Method for Determining Residual Stresses, Khikhakai KENSA, 1974, vol. 23, no.3, pp. 147–154.

    Google Scholar 

  7. Ostatochnye napryazheniya v zagotovkakh i detalyakh krupnykh mashin (Residual Stresses in Blanks and Parts of Large Mashinery), Mikhailov, O.N., Ed., Sverdlovsk: 1971.

  8. Pravdin, L.S., Magnetoelastic Characteristics of Steel under Quasistatic Impacts, Defektoskopiya, 1982, no. 5, pp. 57–61.

  9. Atherton, D.L. and Jiles, D.C., Effects of Stresses on the Magnetization of Steel, IEEE Trans. Magn., 1983, vol. 19, no.5, pp. 2021–2023.

    Article  Google Scholar 

  10. Langman, R., The Effect of Stress on the Magnetization of Mild Steel at Moderate Field Strengths, IEEE Trans. Magn., 1985, vol. MAG-21, no.4, pp. 1314–1320.

    CAS  Google Scholar 

  11. Langman, R., Measurement of Stress by a Magnetic Method, NDT Prog. 4th European Conference, London: 1987, vol. 3, pp. 1783–1799.

    Google Scholar 

  12. Atherton, D.L., Magnetization Changes Induced by a Stress under Constant Applied Field in 2% Mn Pipeline Steel, IEEE Trans. Magn., 1988, vol. 24, no.3, pp. 2029–2032.

    CAS  Google Scholar 

  13. Makar, J.M. and Atherton, D.L., Effect of Uniaxial Stress on the Reversible and Irreversible Permeabilities of 2% Mn Pipeline Steel, IEEE Trans. Magn., 1994, vol. 30, no.4, pp. 1380–1387.

    CAS  Google Scholar 

  14. Kuleev, V.G. and Atangulova, L.V., Effect of Elastic Stresses on the reversible Susceptibility of Ferromagnetic Steels in Various Magnetic States, Fiz. Met. Metalloved., 1998, vol. 87, no.5, pp. 52–57 [Phys. Met. Metallogr. (Engl. Transl.), 1999, vol. 98, no. 5, pp. 409–414].

    Google Scholar 

  15. Bida, G.V. and Kuleev, V.G., Effect of Elastic Deformation on Magnetic Properties of Steels with Vairous Structures, Defektoskopiya, 1998, no. 11, pp. 12–26.

  16. Novikov, V.F. and Izosimov, V.A., Effect of Elastic Stresses on the Coercive Force, Fiz. Met. Metalloved., 1984, vol. 58, no.2, pp. 275–281.

    CAS  Google Scholar 

  17. Musikhin, S.A., Novikov, V.F., and Borisenko, V.N., Using Coercive Force as an Indicator Parameter for Nondestructive Testing Mechanical Stresses, Defektoskopiya, 1987, no. 9, pp. 57–60.

  18. Zakharov, V.A., Borovkova, M.L., Komarov, V.A., and Muzhitskii, V.F., Effect of External Stresses on the Coercive Force of Carbon Steels, Defektoskopiya, 1992, no. 1, pp. 41–46.

  19. Kuleev, V.G. and Gorkunov, E.S., Mechanisms of Effect of Internal and External Stresses on the Coercive Force of Ferromagnetic Steels, Defektoskopiya, 1997, no. 11, pp. 3–18.

  20. Novikov, V.F., Yatsenko, T.A., and Bakharev, M.S., Coercive Force of Low-Carbon Steels as a Function of Uniaxial Stress. Part 1, Defektoskopiya, 2001, no. 11, pp. 51–57 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2001, vol. 37, no. 11, p. 799].

  21. Novikov, V.F., Yatsenko, T.A., and Bakharev, M.S., Coercive Force as a Function of Uniaxial Stress (Part 2), Defektoskopiya, 2002, no. 4, pp. 10–17 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2002, vol. 38, no. 4, p. 231].

  22. Gorkunov, E.S., Tsar'kova, T.P., Smirnov, S.V., et al., Effect of Deviation from Coaxiality between the Directions of Magnetization and Mechanical Strain on the Results of Magnetic Testing of Elastic Strain in Steels, Defektoskopiya, 2004, no. 5, pp. 40–52 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2004, vol. 40, no. 5, p. 317].

  23. Gorkunov, E.S., Novikov, V.F., Nichipuruk, A.P., Nasonov, V.V., Kadrov, A.V., and Tatlybaeva, I.N., Stability of Residual Magnetization of Thermally Treated Steel Parts under the Effect of Elastic Deformations, Defektoskopiya, 1991, no. 2, pp. 68–76.

  24. Kuleev, V.G., Bida, G.V., and Atangulova, L.V., Feasibility of NDT of Ferromagnetic Steel Structures Based on Measurements of Residual Magnetization as a Function of Elastic Stress, Defektoskopiya, 2000, no. 12, pp. 7–19 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2000, vol. 36, no. 12, p. 866].

  25. Kostin, V.N., Tsar'kova, T.P., and Sazhina, E.Yu., Measurements of Relative Magnetic Parameters of Materials in Tested Components Incorporated in Closed Circuits, Defektoskopiya, 2001, no. 1, pp. 15–26 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2001, vol. 37, no. 1, p. 10].

  26. Kostin, V.N., Osintsev, A.A., Stashkov, A.N., and Tsar'kova, T.P., Multiparameter Methods for Structural Analysis of Steel Articles Using the Magnetic Properties of Substances, Defektoskopiya, 2004, no. 3, pp. 69–82 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2004, vol. 40, no. 3, p. 197].

  27. Stepin, P.A., Soprotivlenie materialov (Resistance of Materials), Moscow: Vysshaya Shkola, 1983.

    Google Scholar 

  28. Mes'kin, V.S., Ferromagnitnye splavy (Ferromagnetic Alloys), Leningrad-Moscow: ONTI, 1937.

    Google Scholar 

  29. Gorkunov, E.S., Grachev, S.V., Smirnov, S.V., et al., Relation of Physical-Mechanical Properties to the Structural Condition of Severely Deformed Patented Carbon Steels at Drawing, Defektoskopiya, 2005, no. 2, pp. 3–22 [Rus. J. of Nondestructive Testing (Engl. Transl.), 2005, vol. 41, no. 2, p. 65].

  30. Kostin, V.N., Possibility of Magnetic Testing Mechanical Properties of Steels with Various Carbon Amount after Cold Plastic Deformation and Annealing, Defektoskopiya, 1989, no. 5, pp. 35–42.

  31. Chetyrkin, E.M. and Kalikhman, I.L., Veroyatnost' i statistika (Probability and Statistics), Moscow: Finansy i Statistika, 1982.

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Institute of Metal Physics, Ural Division, Russian Academy of Sciences, ul. Sof'i Kovalevskoi 18, Yekaterinburg, 620219, Russia

    V. N. Kostin, A. V. Kadrov & A. E. Kuskov

  2. Physicotechnical Institute, Ural Division, Russian Academy of Sciences, ul. Kirova 132, Izhevsk, 426000, Russia

    V. N. Kostin, A. V. Kadrov & A. E. Kuskov

Authors
  1. V. N. Kostin
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. A. V. Kadrov
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. A. E. Kuskov
    View author publications

    You can also search for this author in PubMed Google Scholar

Additional information

Devoted to the Centenary of the Birth of M.N. Mikheev

__________

Translated from Defektoskopiya, Vol. 41, No. 10, 2005, pp. 13–22.

Original Russian Text Copyright © 2005 by Kostin, Kadrov, Kuskov.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Kostin, V.N., Kadrov, A.V. & Kuskov, A.E. Magnetic Properties of a Material Used to Estimate Elastic and Plastic Strains of Ferrite—Pearlite Steels. Russ J Nondestruct Test 41, 632–639 (2005). https://doi.org/10.1007/s11181-006-0014-7

Download citation

  • Received:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11181-006-0014-7

Keywords

Search

Navigation