Abstract
Reverse osmosis (RO) is the most preferable process for water recovery from secondary effluent (SE) because of its higher rejection of impurities with lower associated cost and higher quality of product. Fouling still is a major challenge during the water recovery due to higher contaminant loadings in SE and high rejection capability of this membrane. The presence of suspended solids, colloidal and organic matters, and high level of biological activities in SE further elevate fouling potentiality. This review was performed to identify major foulants causing hindrance in sustainable application of reverse osmosis and to present available pre-treatment options for these foulants. There are four fouling types present in RO namely; bio-fouling, inorganic/scaling, organic, and particulate fouling. Among them; bio-fouling is less understood but dominant since the pre-treatment options are not well developed. Other fouling mechanisms have been overcome by well developed pre-treatments. The major foulants for RO are dissolved and macromolecular organic substances, sparingly soluble inorganic compounds, colloidal and suspended particles, and micro-organisms. Some of these potential fouling water quality parameters (PFWQPs) are interrelated with each others such as electrical conductivity is a surrogate measure of total dissolved solids with established stable relationship. Most of these PFWQPs such as total suspended solids, turbidity, chemical oxygen demand can be removed by conventional pre-treatment; some such as colloidal particles and micro-organisms by modern options and even others such as endocrine disrupting compounds, pharmaceutical and personal care products are still challenging for current pre-treatments. These foulants need to be identified properly to integrate appropriate pre-treatments for minimizing fouling potentiality to increase water recovery at minimal costs.
Similar content being viewed by others
References
Abd El-Aleem FA, Al-Sugair KA, Alahmad MI (1998) Biofouling problems in membrane processes for water desalination and reuse in Saudi Arabia. Int Biodeterior Biodegrad 41:19–23
Abdessemed D, Nezzal G, Ben Aim R (2000) Coagulation-adsorption-ultrafiltration for wastewater treatment and reuse. Desalination 131:307–314
Ahn KH, Song Cha JHY, Song KG, Yoo H (1998) Application of tubular ceramic membrane for building wastewater reuse. In: IAWQ 19th international conference, Vancouver
Al-Amoudi A, Lovitt R (2007) Fouling strategies and the cleaning system of NF membranes and factors affecting cleaning efficiency. J Membr Sci 303:4–28
Amjad Z, Zibrida JF, Zuhi RW (1997) A new antifoulant for controlling silica fouling in reverse osmosis systems. In: International desalination association world congress on desalination and water reuse, Cleveland, OH. Internation Desalination Association
Ang WS, Elimelech M (2007) Protein (BSA) fouling of reverse osmosis membranes: implications for wastewater reclamation. J Membr Sci 296(1–2):83–92
Arora ML, Trompeter KM (1983) Fouling of RO membranes in wastewater applications. Desalination 48(3):299–319
Baek SO, Chang IS (2009) Pretreatments to control membrane fouling in membrane filtration of secondary effluents. Desalination 244(1–3):153–163
Barker DJ, Stuckey DC (1999) A review of soluble microbial products (SMP) in wastewater treatment systems. Water Res 33(14):3063–3082
Bartels CR, Wilf M, Andes K, Long J (2005) Design consideration for wastewater treatment by reverse osmosis. Water Sci Technol 51:473–482
Bellona C, Drewes JE, Xu P, Amy G (2004) Factors affecting the rejection of organic solutes during NF/RO treatment-a literature review. Water Res 38(2004):2795–2809
Bick A, Oron G (2001) Assessing the linkage between deed water quality and reverse osmosis membrane performance. Desalination 137:141–148
Bouver EJ, Crowe PB (1988) Biological processes in drinking water treatment. J AWWA 80(9):82
Cabassud C, Labories S, Durand-Bourlier L, Laine JM (2001) Air sparging in ultrafiltration hollow fibres: relationship between flux enhancement, cake characteristics and hydrodynamic parameters. J Membr Sci 181:57–65
Champlin TL (2000) Using circulation tests to model natural organic matter adsorption and particle deposition by spiral-wound nano-filtration membrane elements. Desalination 131:103–115
Choksuchart P, Heran M, Grasmick A (2002) Surface water clarification by ultrafiltration with an immersed membrane system: effect of coagulation/aeration on flux enhancement. In: Proceedings of membranes in drinking and industrial water production, Mulherim/Ruhr, Germany, International Water Association, London, UK
Clifford FFJ (1988) Electronic-grade water production using reverse osmosis technology. In: Parekh BS (ed) Reverse osmosis technology application for high-purity-water production. Marcel Dekker, INC, New York, p 516
Dabbagh TA (1995) The role of desalination in sustaining economic growth in the Gulf. In: Proceedings of the IDA world congress on desalination and water sciences, UAE, Abu Dhabi, Abu Dhabi Publishing Co.
Defrance L, Jaffrin MY, Gupta B, Paulier P, Gaengey V (2000) Contribution of various constituents of activated sludge to membrane bioreactor fouling. Bioresour Technol 73:105–112
DOW (1995) Filmtec membranes technical manual. D. L. Separations, Midland
DOW (2008) FILMTEC reverse osmosis membranes technical manual 2008, DOW water & process solutions. p 178
Drewes J, Fox P (1999) Fate of natural organic matter (NOM) during groundwater recharge using reclaimed water. Water Sci Technol 40(9):241–248
Drewes JE, Heberer T, Reddersen K (2002) Fate of pharmaceuticals during indirect potable reuse. Water Sci Technol 46:73–80
Drioli EA, Criscuoli EC (2002) Integrated membrane operations for seawater desalination. Desalination 147:77
Dupont (1980) Permasep engineering design manual. Wilmington, Delaware
Duranceau SJ (2001) Membrane practices for water treatment. American Water Works Association, Denver, pp 59–62
Egozy Y, Jeffrey PD, Ganzi GC (1988) The role of reverse osmosis in production in laboratory water. In: Parekh BS (ed) Reverse osmosis technology application for high-purity-water production, vol 35. Marcel Dekker, INC, New York, p 516
Elimelech M, Wiesner M (2002) Membrane separations in aquatic systems. Environ Eng Sci 19:341
Elimelech M, Zhu X, Childress AE, Seungkwan H (1997) Role of membrane surface morphology in colloidal of cellulose acetate and composite aromatic polyamide RO membranes. J Membr Sci 127:101–109
Flemming HC (1993) Mechanistic aspects of reverse osmosis membrane biofouling and prevention. In: Zahid A (ed) Reverse osmosis: membrane technology, water chemistry and industrial application. Von Nostrand Reinhold, NY, pp 163–209
Flemming HC, Schaule G (1988) Biofouling of membranes—a microbiological approach. Desalination 70:95–119
Flemming HC, Tamachkiarow A (2002) Monitoring of biofilms in technical systems—a crucial components of advanced anti-fouling strategies. In: Proceedings of membranes in drinking and industrial water production, Mulherim/Ruhr, Germany, International Water Association, London
Flemming HC, Griebe T, Schaule G (1996) Antifouling strategies in technical systems—a short review. Water Sci Technol 34(5–6):517–524
Flemming HC, Schaule G, Griebe T, Schmitt J, Tamachkiarowa A (1997) Biofouling-the Achilles heel of membrane processes. Desalination 113:215–225
Geselbracht J, Crook J (1996) A proposed alternate means of meeting TOC requirements for ground-water recharge projects. Proceedings of WateReuse symposium XII. WateReuse Association, Fountain Valley
Ghayeni SBS, Beatson PJ, Schneider RP, Fane AG (1998a) Adhesion of waste water bacteria to reverse osmosis membranes. J Membr Sci 138:29–42
Ghayeni SBS, Beatson PJ, Schneider RP, Fane AG (1998b) Water reclamation from municipal wastewater using combined micro filtration-reverse osmosis (ME-RO): preliminary performance data and microbiological aspects of system operation. Desalination 116:65–80
Ghose K, Schnitzer M (1980) Macromolecular structures of humic substances. Soil Sci 129:226–276
Gray S (2003) NOM removal with membranes. Natural organic matter in drinking water: problems and solutions. CRC for water quality and treatment: Occasional paper 6, pp 5–9
Hilal N, Al-Zoub H, Darwish NA, Mohammad AW, Abu Arabi M (2004) A comprehensive review of NF membranes: treatment, pre-treatment modelling, and atomic force microscopy. Desalination 170:281–308
Hoek EMV, Allred J, Knoell T, Jeong B-H (2008) Modeling the effects of fouling on full-scale reverse osmosis processes. J Membr Sci 314(1–2):33–49
Hong SK, Elimelech M (1997) Chemical and physical aspects of natural organic matter (nom) fouling of nanofiltration membranes. J Membr Sci 132:159–181
Jarusutthirak C, Amy G (2001) Membrane filtration of wastewater effluent for reuse: effluent organic matter rejection and fouling. Water Sci Technol 43(10):225–232
Jarusutthirak C, Amy G (2006) Role of soluble microbial products (SMP) in membrane fouling and flux decline. Environ Sci Technol 40:969–974
Jarusutthirak C, Amy G, Croue JP (2002) Fouling characteristics of wastewater effluent organic matter isolates on NF and UF membranes. Desalination 145:247–255
Jarusutthirak C, Amy G, Croue JP, Von Gunten U (2003) Fouling of high-pressure (NF and RO) membranes by soluble microbial products (SMPs) associated with wastewater effluent organic matter (EfOM). In: Proceedings of the American water works association membrane technology conference, Denver, CO, American Water Works Association
Jegatheesan V, Lamsal PR, Visvanathan C, Ngo HH, Shu L (2002) Effects of natural organic compounds on the removal of organic carbon in coagulation and flocculation processes. Water Sci Technol Water Supply 2(5–6):473–479
Kasper DR (1993) Pre- and post treatment processes for membrane water treatment systems. In: Proceedings of the American water works association membrane technology conference, Denver, CO, American Water Works Association
Khedr MG (2003) Development of reverse osmosis desalination membranes composition and configuration: future prospects. Desalination 153:295–304
Kim DH, Moon JH, Cho J (2003) Evaluation of UF membranes for effective wastewater effluent organic matter (EfOM) removal with hydrophilic polymer additives. In: Proceedings of the 2002 water quality technology conference, Denver, CO, American Water Works Association
Kim J, DiGiano FA, Reardon DR (2008) Autopsy of high-pressure membranes to compare effectiveness of MF and UF pretreatment in water reclamation. Water Res 42(3):697–706
Kim S-H, Min C-S, Cho J (2011) Comparison of different pretreatments for seawater desalination, accepted manuscripts, desalination and water treatment (www.deswater.com) Proof DWT 8303 @ 2011 Desalination Publications
Kweon J, Lawler DF (2002) Effects of characteristics of softening as a pre-treatment for ultrafiltration. In: Proceedings of membranes in drinking and industrial water production, Mulherim/Ruhr, Germany, International Water Association, London, UK, pp 757–764
Laine JM, Campos C, Baudin I, Janex ML (2002) Understanding membrane fouling: a review of over a decade of research. In: Proceedings of membranes in drinking and industrial water production, Mulherim/Ruhr, Germany, International Water Association, London, UK
Lazarova V, Levine B, Sack J, Cirelli G, Jefferey P, Muntau H, Salgot M, Brissaud F (2001) Role of water reuse for enhancing integrated water management in Europe and Mediterranean countries. Water Sci Technol 43(10):23–33
Le Gouellec YDS, Elimelech M (2002) Calcium sulfate (gypsum) scaling in nanofiltration of agricultural drainage water. J Membr Sci 205:279
Le Roux I, Krieg HM, Yeates CA, Breytenbach JC (2005) Use of chitosan as an antifouling agent in a membrane bioreactor. J Membr Sci 248:127–136
Lee KC, Rittmann BE (2003) Effects of pH and precipitation on autohydrogenotrophic denitrification using the hollow-fiber membrane-biofilm reactor. Water Res 37:1551–1556
Levine AD, Tchobanoglous G, Asano T (1991) Size distributions of particulate contaminants in wastewater and their impact on treatability. Water Res 25:911–922
Liu C, Caothien S, Jennifer H, Tom C, Takehiko O, Takashi O (2001) Membrane chemical cleaning: from art to science 25
López-Ramírez JA, Oviedo MDC, Alonso JMQ (2006) Comparative studies of reverse osmosis membranes for wastewater reclamation. Desalination 191(1–3):137–147
Makdissy G, Croue JP, Amy G, Lee N, Habarau H, Buisson H (2002) Advances in the knowledge of the fouling of an ultrafiltration membrane. In: Proceedings of the 2002 water quality technology conference, Denver, CO, American Water Works Association
Malpei F, Rozzi A, Colli S, Uberti M (1997) Size distribution of TOC in mixed municipal-textile effluents after biological and advanced treatment. J Membr Sci 131:71–83
Mänttäri M, Puro L, Jutta N-J, Nyström M (2000) Fouling effects of polysaccharides and humic acid in NF. J Membr Sci 165:1–17
Maurer M, Boller M (1999) Modelling of phosphorus precipitation in wastewater treatment plants with enhanced biological phosphorus removal. Water Sci Technol 39(1):147
McCoy WF, Olson BH (1986) Relationship among turbidity, particle counts and bacteriological quality within water distribution lines. Water Res 20:1023–1029
Metcalf & Eddy, Inc. (2003) Wastewater engineering: treatment and reuse. McGraw Hill, New York
Mickley M, Hamilton R, Truesdall J (1993) Membrane concentrate disposal. AWWA Research Foundation, Denver
Miura Y, Hiraiwa MN, Ito T, Itonaga T, Watanabe Y, Okabe S (2007) Bacterial community structures in MBRs treating municipal wastewater: relationship between community stability and reactor performance. Water Res 41:627–637
Munro A (1999) Biological control on membrane surfaces. Asian Water 15(8):22–26
Pandey SR, Jegatheesan V, Baskaran K, Muthukumaran S (2011) Ranking of pre-treatment technologies for reverse osmosis for water recovery. In: Orhon D et al. (ed) Proceeding of the 8th international symposium on waste management problems in agro-industries (AGRO’2011) 22–24 June 2011, Çeşme, Izmir, Turkey, pp 463–470
Paranjape S, Reardon R, Foussereau X (2003) Pretreatment technology for reverse osmosis membrane used in wastewater reclamation application past, present and future a literature review. Proc Water Environ Fed 2003:459–486
Pettygrove GS, Asano T (1985) Irrigation with reclaimed municipal wastewater-a guidance manual. Lewis Publishers Inc., Chelsea
Potts DE, Ahlert RC, Wang SS (1981) A critical review of fouling of RO membranes. Desalination 36:235–264
Reardon R, DiGiano F, Aitken M, Paranjabe S, Kim JH, Chang SY (2005) Membrane treatment of secondary effluent for subsequent reuse, Water Environment Research Foundation Report, IWA Publishing
Ridgway HF, Flemming HC (1996) Membrane biofouling in water treatment. Membrane processes. McGraw Hill, NY
Roudman AR, DiGiano FA (2000) Surface energy of experimental and commercial NF membranes: effects of wetting and NOM fouling. J Membr Sci 175:61–73
Sablani SS, Goosen MFA, Al-Belushi R, Wilf M (2001) Concentration polarization in ultrafiltration and reverse osmosis: a critical review. Desalination 141:269–289
Sahachaiyunta P, Koo T, Sheikholeslami R (2002) Effect of several inorganic species on silica fouling in RO membranes. Desalination 144:373–378
Schäfer AI, Fane AG, Waite TD (1998) Nano-filtration of natural organic matter: removal, fouling and the influence of multivalent ions. Desalination 118:109–122
Schäfer AI, Fane AG, Waite TD (2005) Nano-filtration-principle and applications. Elsevier Advanced Technology, Oxford, UK, pp 1–543
Schäfer AI, Pihlajamäki A, Fane AG, Waite TD, Nyström M (2004) Natural organic matter removal by nanofiltration: effects of solution chemistry on retention of low molar mass acids versus bulk organic matter. J Membr Sci 242(2004):73–85
Schneider RP, Ferreira LM, Binder P, Ramos JR (2005) Analysis of foulant layer in all elements of an RO train. J Membr Sci 261:152–162
Shon HK, Vigneswaran S, Kim IS, Cho J, Ngo HH (2004) Effect of pretreatment on the fouling of membranes: application in biologically treated sewage effluent. J Membr Sci 234:111–120
Shon HK, Vigneswaran S, Ben Aim R, Ngo HH, Kim IS, Cho J (2005) Influence of flocculation and adsorption as pretreatment on the fouling of ultrafiltration and nanofiltration membranes: application with biologically treated sewage effluent. Environ Sci Technol 39(10):3864–3871
Shon HK, Vigneswaran S, Ngo HH (2006a) Effects of partial flocculants and adsorption as pretreatment to ultrafiltration. J AIChE 52(1):207–216
Shon HK, Vigneswaran S, Snyder SA (2006b) Effluent organic matter (EfOM) in wastewater: constituents, effects, and treatment. In: Logan TJ (ed) Critical reviews in environmental science and technology, vol 36, Issue 4. Taylor & Francis, UK, pp 327–374
Shon HK, Vigneswaran S, Kandasamy J, Cho J (2009) Membrane Technology For Organic Removal In Wastewater. In: (Vigi) Vigneswaran S (ed) Water and wastewater treatment technologies, in encyclopedia of life support systems (EOLSS) Developed under the auspices of the UNESCO. Eolss Publishers, Oxford, UK available at http://www.eolss.net. Retrieved at 24 Aug 2011
Snyder SA, Wert E, Yoon Y, Westerhoff P (2006) Role of membranes and activated carbon in the removal of endocrine disruptors and pharmaceutical during water treatment processes. Desalination
Song L (1998) Flux decline in crossflow microfiltration and ultrafiltration: mechanisms and modelling of membrane fouling. J Membr Sci 139:183–200
Speth TF, Summers RS, Gusses AM (1998) Nanofiltration foulants from a treated surface. Environ Sci Technol 32:3612–3617
Tanninen J, Kamppinen L, Nyström M (2004) Pretreatment/hybrid processes. Chapter 10 in Schaefer A., Fane A. and Waite T. Nanofiltration: principles and applications. Elsevier
Tchobanoglous G, Burton FL (1991) Wastewater engineering: treatment, disposal, and reuse. McGraw Hill, New York
Temperely TG (1995) The coming age of desalination. In: Proceedings of the IDA world congress on desalination and water sciences, UAE, Abu Dhabi, Abu Dhabi Publishing Co.
USEPA (2004) Guidelines for water reuse 2004. N. Office of Research and Development, Technology Transfer and Support Division, Paris, Lynnann
Vander Bruggen B, Vandecasteele C (2002) Distillation vs membrane filtration: overview of process evolutions in seawater desalination. Desalination 143:207–218
Visvanathan C, Boonthanon N, Sathasium A, Jegatheesan V (2002) Pre-treatment of seawater for biodegradable organic content removal using membrane bioreactor. Desalination 153:133–140
Vrouwenvelder JS, van der Kooij D (2001) Diagnosis, prediction and prevention of bio-fouling of NF and RO membranes. Desalination 139:65
WEF (2005) Membrane systems for wastewater treatment. McGraw-Hill Professional Publishing, Blacklick
Wend CF, Steward PS, Jones W, Camper AK (2003) Pre-treatment for membrane water treatment systems: a laboratory study. Water Res 37:3367–3378
Wiesner MR, Chellan S (1999) The promise of membrane technologies. Environ Sci Technol 33:360A–366A
Winfield BA (1979a) A study of the factors affecting the rate of fouling of reverse osmosis membranes treating secondary sewage effluents. Water Res 13(7):565–569
Winfield BA (1979b) The treatment of Sewage effluent by reverse osmosis-pH based studies of the fouling layer and its removal. Water Res 13:561–564
Xu P, Bellona C, Drewes JE (2010) Fouling of nanofiltration and reverse osmosis membranes during municipal wastewater reclamation: membrane autopsy results from pilot-scale investigations. J Membr Sci 353(1–2):111–121
Yang HL, Huang C, Pan JR (2008) Characteristics of RO foulants in a brackish water desalination plant. Desalination 220:353–358
Yoon SH, Lee CH, Kim KJ, Fane AG (1998) Effects of calcium ion on the fouling of nanofiltration by humic acid in drinking water production. Water Res 32:2180–2186
Yuan W, Zydney AL (1999) Humic acid fouling during micro-filtration. J Membr Sci 157:1–12
Zeiher EHK, Ho B, Williams KD (2003) Novel antiscalant dosing control. Desalination 157:209–216
Zhao Y, Song L, Ong SL (2010a) Fouling behavior and foulant characteristics of reverse osmosis membranes for treated secondary effluent reclamation. J Membr Sci 349(1–2):65–74
Zhao Y, Song L, Ong SL (2010b) Fouling of RO membranes by effluent organic matter (EfOM): relating major components of EfOM to their characteristic fouling behaviors. J Membr Sci 349(1–2):75–82
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Pandey, S.R., Jegatheesan, V., Baskaran, K. et al. Fouling in reverse osmosis (RO) membrane in water recovery from secondary effluent: a review. Rev Environ Sci Biotechnol 11, 125–145 (2012). https://doi.org/10.1007/s11157-012-9272-0
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11157-012-9272-0