This study aims to understand the impact of spray drying nozzles on particle surface composition and aerosol stability.
The combination formulations of colistin and azithromycin were formulated by 2-fluid nozzle (2 N) or 3-fluid (3 N) spray drying in a molar ratio of 1:1. A 3-factor, 2-level (23) factorial design was selected to investigate effects of flow rate, inlet temperature and feed concentration on yield of spray drying and the performance of the spray dried formulations for the 3 N.
FPF values for the 2 N formulation (72.9 ± 1.9% for azithromycin & 73.4 ± 0.8% for colistin) were higher than those for the 3 N formulation (56.5 ± 3.8% for azithromycin & 55.1 ± 1.6% for colistin) when stored at 20% RH for 1 day, which could be attributed to smaller physical size for the 2 N. There was no change in FPF for both drugs in the 2 N formulation after storage at 75% RH for 90 days; however, there was a slight increase in FPF for colistin in the 3 N formulation at the same storage conditions. Surface enrichment of hydrophobic azithromycin was measured by X-ray photoelectron spectroscopy for both 2 N and 3 N formulations and interactions were studied using FTIR.
The 3-fluid nozzle provides flexibility in choosing different solvents and has the capability to spray dry at higher feed solid concentrations. This study highlights the impact of hydrophobic azithromycin enrichment on particle surface irrespective of the nozzle type, on the prevention of moisture-induced deterioration of FPF for hygroscopic colistin.
This is a preview of subscription content, log in to check access.
Buy single article
Instant access to the full article PDF.
Price includes VAT for USA
Subscribe to journal
Immediate online access to all issues from 2019. Subscription will auto renew annually.
This is the net price. Taxes to be calculated in checkout.
- 2 N:
- 3 N:
- ColAz (1-1):
Co-spray dried colistin and azithromycin at a molar ratio of 1:1
Design of experiments
Dry powder inhaler
Dynamic vapor sorption
Fine particle fraction
Fourier-transform infrared spectroscopy
Geometric standard deviation
Median mass aerodynamic diameter
Next generation Impactor
Powder X-ray diffractometer
Scanning electron microscopy
X-ray photoelectron spectroscopy
Wenzler E, Fraidenburg DR, Scardina T, Danziger LH. Inhaled antibiotics for gram-negative respiratory infections. Clin Microbiol Rev. 2016;29(3):581–632.
Quon BS, Goss CH, Ramsey BW. Inhaled antibiotics for lower airway infections. Annals of the American Thoracic Society. 2014;11(3):425–34.
Dalhoff A. Pharmacokinetics and pharmacodynamics of aerosolized antibacterial agents in chronically infected cystic fibrosis patients. Clin Microbiol Rev. 2014;27(4):753–82.
Borghardt JM, Kloft C, Sharma A. Inhaled therapy in respiratory disease: the complex interplay of pulmonary kinetic processes. Can Respir J. 2018;2018:2732017–7.
Zhou Q, Morton DAV, Yu HH, Jacob J, Wang J, Li J, et al. Colistin powders with high Aerosolisation efficiency for respiratory infection: preparation and In Vitro evaluation. J Pharm Sci. 2013;102(10):3736–47.
Yapa SWS, Li J, Patel K, Wilson JW, Dooley MJ, George J, et al. Pulmonary and systemic pharmacokinetics of inhaled and intravenous colistin methanesulfonate in cystic fibrosis patients: targeting advantage of inhalational administration. Antimicrob Agents Chemother. 2014;58(5):2570–9.
Gurjar M. Colistin for lung infection: an update. J Intensive Care. 2015;3(1):3.
Hartzell JD, Neff R, Ake J, Howard R, Olson S, Paolino K, et al. Nephrotoxicity associated with intravenous Colistin (Colistimethate sodium) treatment at a tertiary care medical center. Clin Infect Dis. 2009;48(12):1724–8.
Linden PK, Kusne S, Coley K, Fontes P, Kramer DJ, Paterson D. Use of parenteral colistin for the treatment of serious infection due to antimicrobial-resistant Pseudomonas aeruginosa. Clinical infectious diseases : an official publication of the Infectious Diseases Society of America. 2003;37(11):e154–60.
Lin Y-W, Zhou QT, Hu Y, Onufrak NJ, Sun S, Wang J, et al. Pulmonary pharmacokinetics of Colistin following Administration of dry Powder Aerosols in rats. Antimicrob Agents Chemother. 2017;61(11):e00973–17.
Lin Y-W, Zhou QT, Cheah S-E, Zhao J, Chen K, Wang J, Chan H-K, Li JJAA, Chemotherapy. pharmacokinetics/pharmacodynamics of pulmonary delivery of colistin against Pseudomonas aeruginosa in a Mouse Lung Infection Model. 2017;61(3):e02025–02016.
Lin Y-W, Zhou QT, Han M-L, Chen K, Onufrak NJ, Wang J, Turnidge JD, Howden BP, Forrest A, Chan H-KJAa, chemotherapy. Elucidating the Pharmacokinetics/Pharmacodynamics of Aerosolized Colistin against Multidrug-Resistant Acinetobacter baumannii and Klebsiella pneumoniae in a Mouse Lung Infection Model. 2018;62(2):e01790–01717.
Lin Y-W, Zhou QT, Han M-L, Onufrak NJ, Chen K, Wang J, Forrest A, Chan H-K, Li JJAa, chemotherapy. Mechanism-based pharmacokinetic/pharmacodynamic modeling of aerosolized colistin in a Mouse Lung Infection Model. 2018;62(3):e01965–01917.
Li J, Nation RL, Turnidge JD, Milne RW, Coulthard K, Rayner CR, et al. Colistin: the re-emerging antibiotic for multidrug-resistant gram-negative bacterial infections. Lancet Infect Dis. 2006;6(9):589–601.
Antoniu SA, Cojocaru I. Inhaled colistin for lower respiratory tract infections. Expert Opin Drug Deliv. 2012;9(3):333–42.
Cai Y, Chai D, Wang R, Liang B, Bai N. Colistin resistance of Acinetobacter baumannii: clinical reports, mechanisms and antimicrobial strategies. J Antimicrob Chemother. 2012;67(7):1607–15.
Paterson DL, Harris PN. Colistin resistance: a major breach in our last line of defence. Lancet Infect Dis. 2016;16(2):132–3.
Li J, Rayner CR, Nation RL, Owen RJ, Spelman D, Tan KE, et al. Heteroresistance to colistin in multidrug-resistant Acinetobacter baumannii. Antimicrob Agents Chemother. 2006;50(9):2946–50.
Zhou QT, Sun SP, Chan JG, Wang P, Barraud N, Rice SA, et al. Novel inhaled combination powder containing amorphous Colistin and crystalline Rifapentine with enhanced antimicrobial activities against planktonic cells and biofilm of Pseudomonas aeruginosa for respiratory infections. Mol Pharm. 2015;12(8):2594–603.
Montón C, Prina E, Pomares X, Cugat JR, Casabella A, Oliva JC, et al. Nebulized Colistin and continuous cyclic azithromycin in severe COPD patients with chronic bronchial infection due to Pseudomonas aeruginosa: a retrospective cohort study. Int J Chron Obstruct Pulmon Dis. 2019;14:2365–73.
Wolter J, Seeney S, Bell S, Bowler S, Masel P, McCormack J. Effect of long term treatment with azithromycin on disease parameters in cystic fibrosis: a randomised trial. Thorax. 2002;57(3):212–6.
Phaff SJ, Tiddens HA, Verbrugh HA, Ott A. Macrolide resistance of Staphylococcus aureus and Haemophilus species associated with long-term azithromycin use in cystic fibrosis. J Antimicrob Chemother. 2006;57(4):741–6.
Li J, Milne RW, Nation RL, Turnidge JD, Coulthard K. Stability of colistin and colistin methanesulfonate in aqueous media and plasma as determined by high-performance liquid chromatography. Antimicrob Agents Chemother. 2003;47(4):1364–70.
Vehring R. Pharmaceutical particle engineering via spray drying. Pharm Res. 2008;25(5):999–1022.
Zhou Q, Loh ZH, Yu J. Sun S-p, Gengenbach T, Denman JA, Li J, Chan H-K. how much surface coating of hydrophobic azithromycin is sufficient to prevent moisture-induced decrease in Aerosolisation of hygroscopic amorphous Colistin powder? AAPS J. 2016;18(5):1213–24.
Kondo K, Niwa T, Danjo K. Preparation of sustained-release coated particles by novel microencapsulation method using three-fluid nozzle spray drying technique. Eur J Pharm Sci. 2014;51:11–9.
Pabari RM, Sunderland T, Ramtoola Z. Investigation of a novel 3-fluid nozzle spray drying technology for the engineering of multifunctional layered microparticles. Expert Opin Drug Deliv. 2012;9(12):1463–74.
Wan F, Maltesen MJ, Andersen SK, Bjerregaard S, Foged C, Rantanen J, et al. One-step production of protein-loaded PLGA microparticles via spray drying using 3-fluid nozzle. Pharm Res. 2014;31(8):1967–77.
Mangal S, Xu R, Park H, Zemlyanov D, Shetty N, Lin YW, et al. Understanding the impacts of surface compositions on the in-vitro dissolution and Aerosolization of co-spray-dried composite powder formulations for inhalation. Pharm Res. 2018;36(1):6.
Anderson MJ, Whitcomb PJ. Design of experiments. Kirk-Othmer Encyclopedia of Chemical Technology. 2000:1–22.
Mangal S, Nie H, Xu R, Guo R, Cavallaro A, Zemlyanov D, et al. Physico-chemical properties, Aerosolization and dissolution of co-spray dried azithromycin particles with L-Leucine for inhalation. Pharm Res. 2018;35(2):28.
Hassanpour Aghdam M, Ghanbarzadeh S, Javadzadeh Y, Hamishehkar H. Aggregated Nanotransfersomal dry powder inhalation of Itraconazole for pulmonary drug delivery. Adv Pharm Bull. 2016;6(1):57–64.
Wang X, Qin Y, Zhang T, Tang W, Ma B, Gong J. Measurement and correlation of solubility of azithromycin monohydrate in five pure solvents. J Chem Eng Data. 2014;59(3):784–91.
Freudenthal O, Quiles F, Francius G, Wojszko K, Gorczyca M, Korchowiec B, et al. Nanoscale investigation of the interaction of colistin with model phospholipid membranes by Langmuir technique, and combined infrared and force spectroscopies. Biochim Biophys Acta. 2016;1858(11):2592–602.
Leng D, Thanki K, Foged C, Yang M. Formulating inhalable dry powders using two-fluid and three-fluid nozzle spray drying. Pharm Res. 2018;35(12):247.
Zhou QT, Armstrong B, Larson I, Stewart PJ, Morton DA. Understanding the influence of powder flowability, fluidization and de-agglomeration characteristics on the aerosolization of pharmaceutical model powders. Eur J Pharm Sci. 2010;40(5):412–21.
Zhu K, Tan RB, Ng WK, Shen S, Zhou Q, Heng PW. Analysis of the influence of relative humidity on the moisture sorption of particles and the aerosolization process in a dry powder inhaler. J Aerosol Sci. 2008;39(6):510–24.
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Electronic supplementary material
About this article
Cite this article
Shetty, N., Zhang, Y., Park, H. et al. Surface Composition and Aerosolization Stability of an Inhalable Combinational Powder Formulation Spray Dried Using a Three-Fluid Nozzle. Pharm Res 37, 219 (2020). https://doi.org/10.1007/s11095-020-02937-2
- aerosol performance
- dry powder inhaler
- spray drying
- surface composition
- three-fluid nozzle