Abstract
Computers and electronic equipment are an important component of the infrastructure of our modern environment. It is therefore essential that we know the effects of volcanic ash on such equipment. This paper presents the results of a pilot study to test computers and cooling fans in an ash-charged environment to assess their vulnerability. In the experiment, ash was poured on to computers and cooling fans in a sealed 0.216 m3 perspex box, with the effects on both the ash and the equipment monitored. Three different types of ash (1996 Ruapehu andesitic ash, Sakurajima andesitic ash and Kaharoa rhyolitic ash) were used in the experiments.
In the first experiment each type of ash was photographed by Scanning Electron Microscope (SEM), then passed through the bearing unit of a cooling fan and photographed again afterwards. The bearings within the cooling fan continued to work even after 720 h of testing and there was no significant abrasion of the fan-shaft bearing. The ash was however fragmented, suggesting that the brittle ash shattered to fine ‘dust’, which caused significantly less abrasion to the bearings or shaft than expected. Three computers were then tested in the sealed box. Ash was introduced at increasing rates to simulate catastrophic entry of ash into a work environment, and computers were tested throughout using the BURNIN® testing programme. Failure times ranged from 100 to 150 h; most failures occurring when humidity was increased by spraying water mist into the airflow. If dried out the computers continued to operate again if failure was not catastrophic. Card slot edge connectors proved to be one of the weakest links, as a bridge of ash formed across the gap. They were also subject to abrasion with some of the gold plating being removed. This did not however cause operating difficulties.
The conclusions are that computers are more resilient than originally thought, unless the ash is moist. Simple ‘low-tech’ procedures should be adequate to protect computers from small amounts of dry and moist ash contamination.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Angelson, R.: 1999, Helical Scan vs. Linear Recording tape drives, their susceptibility to dusty environments. Tandberg Data, http://www.tandberg.com/support/wp0005ruan.html
R. J. Blong (1984) Volcanic Hazards: A Sourcebook on the Effects of Eruptions Academic Press Australia 424
S. A. Bradford (1992) Corrosion Control Van Nostrand Reinhold New York
G. Campbell (1990) ArticleTitleBURNIN, PC Computer Programme: The Premium Exercise and Diagnostic Tool Bulletin Board Support 805 528–3753
Casadevall, T. J., Delos Reyes, P. J., and Schnieder, D. J.: 1996, The 1991 Pinatubo eruption and their effects on aircraft operation. In: C. G. Newhall and R. S. Punongbayan (eds), Fire and Mud; Eruptions and Lahars of Mount Pinatubo, Philippines, Philippine Institute of Volcanology and Seismology and University of Washington Press, pp. 1071–1088.
R. B. Commizzoli R. P. Kleiner P. C. Milner J. D. Sinclair (1986) ArticleTitleCorrosion of electronic materials and devices Science 234 340–345
Deguchi, K.: 1988, Effects of volcanic ash from Sakurajima on living environment and anti-ash device of housing. In Proceeding of the Kagoshima International Conference on Volcanoes. Kagoshima, Japan, 724–727.
J. R. Duncan D. J. Spedding (1974) ArticleTitleThe Mode of Initial Reaction of SO2 at a Metal Surface Corros. Sci 14 241–249
Dunn, M. G. and Wade, D. P.: 1994, Influence of ash clouds on gas turbine engines, Proceedings First International symposium on volcanic ash and aviation safety. U.S. Geological Survey Bull, pp. 107–119.
Durand, M., Gordon, K., Johnston, D., Poirot, T., Scott, B. J., Lorden, R. and Shephard, B. 2001, Impacts of, and responses to, ash fall in Kagoshima from Sakurajima Volcano–lessons for New Zealand., Institute of Geological Nuclear Sciences Science Report 2001/20: 53 pp.
F.E.M.A.: 1984, The mitigation of ashfall damage to public facilities. Lessons learned from the 1980 eruption of Mount St. Helens, Washington. Federal Emergency Management Agency, USA. Bull. 22, 70 pp.
R. V. Fisher H. V. Schmincke (1984) Pyroclastic Rocks Springer-Verlag Heidelberg
J. S. Gilbert S. J Lane R. S. J Sparks (1991) ArticleTitleCharge measurements on particle fallout from a volcanic plume Nature 349 598–600
E. W. Gray (1978) ArticleTitleEffects of vapors from phenol boards and connector lubricants on activation of wire spring relay contacts IEEE Trans. Comp., Hybrids, Manuf. Technol 1 107–111
Heiken, G. and Wohletz, K.: 1985 Volcanic Ash, University of California Press, 246 pp.
G. Heiken M. Murphy W Hackett W. Scott (1995) Volcanic Hazards to Energy Infrastructure-Ash Fallout Hazards and Their Mitigation. World Geothermal Congress Florence, Italy 2795–2798
I. M. Hutchings (1992) Tribology: Friction and Wear of Engineering Materials Edward Arnold London
D. M. Johnston (1997) Physical and Social Impacts of Past and Future Volcanic Eruptions in New Zealand. Massey University Palmerston North, New Zealand
Kenworthy, K.: 1995, Even Computers make Mistakes, Windows Magazine, February 1995. http://stabilant.com/revrw15h.htm
K. Kinoshita (1996) ArticleTitleGround observation and satellite images of sakurajima plumes Atmospheric Environment 30 IssueID16 2831–2837
Labadie, J. R.: 1994, Mitigation of volcanic ash effects on aircraft operating and support systems. In: T. J. Casadevall (ed), Volcanic Ash and Aviation Safety: Proceedings of the First International Symposium on Volcanic Ash and Aviation Safety. U.S. Geological Survey Bulletin 2047, 125–128 pp.
Lichti, K. A., Gilman, N. A., Sanada, Y., Kurata, N. H., Ikeuchi, J, and Christenson, B. W. 1996, Corrosion chemistry of some volcanic environments. Proceeding of the 18th Geothermal Workshop 18, pp. 21–28.
Liebert: 2003, Environmental control; Deluxe system 3TM–DX installation manual. Copyright Liebert Corporation. www.liebert.com/assets/products/english/products/env/de13/60hz/instman/acrobat/sl_18205.pdf.
Malcolm, L. and Van Rossen, A: 1997, Ashes to ashes? Rangipo rebuild, International Water and Power Dam Construction (February) 105 p.
A. S. Marfunin (1994) Advanced Mineralogy Springer-Verlag Berlin, New York
Matsumoto, H., Okabyashi, T., and Mochihara, M.: 1988, Influence of eruptions from Mt. Sakurajima on the deterioration of materials. In:Proceedings Kagoshima International Conference on Volcanoes, pp. 732–735.
Miller, T.: 1999, Volcanic ash hazards to aviation across the North Pacific. In: Guffanti et al. (eds), Proceedings of the Workshop on Present and Future Directions in Volcano-hazard Assessments, Open-File Report – U.S. Geological Survey, U.S. Geological Survey, Reston, VA, United States, 12 pp.
T. P. Miller T. J. Casadevall (2000) Volcanic ash hazards to aviation Sigurdsson (Eds) et al. Encyclopaedia of Volcanoes Academic Press San Diego, CA, United States 915–930
Myers, F. and Brantley, S.: 1995, Volcano Hazards Fact Sheet: Hazardous Phenomena at Volcanoes, U.S. Geological Survey.
W. I. Rose (1977) ArticleTitleScavenging of volcanic aerosol by ash: atmospheric and volcanologic implications Geology 5 621–624 Occurrence Handle1:CAS:528:DyaE1cXhtVSluw%3D%3D
H. C. Shields C. J. Weschler (1998) ArticleTitleAre indoor air pollutants threatening the reliability of your electronic equipment Heating/Piping/Air Conditioning Engineering 70 IssueID5 46–54
Walley, W.: 2001, Feeling hot. Smaller equipment size creates bigger heat concerns, www.internettelphony.com.
C. J. Weschler H. C. Shields (1991) ArticleTitleThe effects of ventilation and indoor air quality on electronic equipment ASHRAE Transactions: Symposia 91-4-1 455–463
Westbrook, J. H. and Conrad, H.: 1971, The Science of Hardness Testing and its Research Technology, Environment and Man Monograph 34, Institute of Behavioural Science, Univ. of Colorado, 143 pp.
Zinser, L. M.: 1994, Effects of volcanic ash on aircraft power plants and airframes. In: T. J. Casadevall (ed), Volcanic Ash and Aviation safety: Proceedings of the First International Symposium on Volcanic Ash and Aviation Safety, U. S. Geological Survey Bulletin 2047, 141–146 pp.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Gordon, K.D., Cole, J.W., Rosenberg, M.D. et al. Effects of Volcanic Ash on Computers and Electronic Equipment. Nat Hazards 34, 231–262 (2005). https://doi.org/10.1007/s11069-004-1514-1
Received:
Accepted:
Issue Date:
DOI: https://doi.org/10.1007/s11069-004-1514-1