Abstract
In this study, the electrochemical performance of the binder-free electrode based on the reinforced resorcinol formaldehyde (RF) carbon aerogels (CAs) was investigated for electric double layer capacitor (EDLC) application. Resorcinol formaldehyde aerogel (RF) was crosslinked using methylene diphenyl diisocyanate (MDI) and then pyrolyzed to produce carbon aerogel (CA). CA was subsequently activated using CO2 gas. The morphological changes due to the reinforcing and activation process were explored by SEM. The BET and BJH results showed an improvement in specific surface area and microporous volume. The CO2-activated CAs displayed up to twice more specific surface areas compared with the unactivated CAs. The compressive test verified an improvement of up to 5 times in the mechanical strength. In order to investigate the electrochemical performance, cyclic voltammetry (CV), charge/discharge (CD), and electrochemical impedance microscopy (EIS) were carried out. In an identical electrode weight, the specific capacity of binder-free electrodes increased about twice, in comparison with the common electrodes due to the removal of the binder and the collector. The highest specific capacitance among the fabricated samples was obtained for the reinforced and activated sample with resorcinol/catalyst (R/C) ratio of 700, which was equal to 55.5 F/g.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Abbas Q, Mirzaeian M, Ogwu AA, et al (2018) ScienceDirect Effect of physical activation / surface functional groups on wettability and electrochemical performance of carbon / activated carbon aerogels based electrode materials for electrochemical capacitors. Int J Hydrogen Energy 1–10. https://doi.org/10.1016/j.ijhydene.2018.04.099
Aghabararpour M, Mohsenpour M, Motahari S, Abolghasemi A (2017) Mechanical properties of isocyanate crosslinked resorcinol formaldehyde aerogels. J Non-Cryst Solids:481, 548–555. 0–1. https://doi.org/10.1016/j.jnoncrysol.2017.11.048
Allahbakhsh A, Bahramian AR (2016) Novolac-derived carbon aerogels pyrolyzed at high temperatures: experimental and theoretical studies. RSC Adv 6:72777–72790. https://doi.org/10.1039/C6RA12947A
Al-muhtaseb BSA, Ritter JA (2003) Preparation and properties of resorcinol-formaldehyde organic and carbon gels. Adv Mater 15:101–114
Alshrah M, Tran MP, Gong P, Naguib HE, Park CB (2017) Development of high-porosity resorcinol formaldehyde aerogels with enhanced mechanical properties through improved particle necking under CO2 supercritical conditions. J Colloid Interface Sci 485:65–74. https://doi.org/10.1016/j.jcis.2016.09.030
Alshrah M, Mark LH, Zhao C, Naguib HE, Park CB (2018) Nanostructure to thermal property relationship of resorcinol formaldehyde aerogels using the fractal technique. Nanoscale 10:10564–10575. https://doi.org/10.1039/c8nr01375f
An H, Wang Y, Wang X, Zheng L, Wang X, Yi L, Bai L, Zhang X (2010) Polypyrrole/carbon aerogel composite materials for supercapacitor. J Power Sources 195:6964–6969. https://doi.org/10.1016/j.jpowsour.2010.04.074
Dawoud B, Amer E, Gross D (2007) Experimental investigation of an adsorptive thermal energy storage. Int J Energy Res 31:135–147. https://doi.org/10.1002/er1235
Fang B, Binder L (2007) Enhanced surface hydrophobisation for improved performance of carbon aerogel electrochemical capacitor. Electrochim Acta 52:6916–6921. https://doi.org/10.1016/j.electacta.2007.05.004
Gao S, Sui Y, Wei F, Qi J, Meng Q, Ren Y, He Y (2018) Dandelion-like nickel / cobalt metal-organic framework based electrode materials for high performance supercapacitors. J Colloid Interface Sci 531:83–90. https://doi.org/10.1016/j.jcis.2018.07.044
Garakani MA, Abouali S, Zhang B, Xu ZL, Huang J, Huang JQ, Heidari EK, Kim JK (2015) Controlled synthesis of cobalt carbonate/graphene composites with excellent supercapacitive performance and pseudocapacitive characteristics. J Mater Chem A 3:17827–17836. https://doi.org/10.1039/c5ta02916c
González A, Goikolea E, Andoni J, Mysyk R (2016) Review on supercapacitors : technologies and materials. Renew Sust Energ Rev 58:1189–1206. https://doi.org/10.1016/j.rser.2015.12.249
Gu W, Yushin G (2014) Review of nanostructured carbon materials for electrochemical capacitor applications: advantages and limitations of activated carbon, carbide-derived carbon, zeolite-templated carbon, carbon aerogels, carbon nanotubes, onion-like carbon, and graphene. Wiley Interdiscip Rev Energy Environ 3:424–473. https://doi.org/10.1002/wene.102
He G, Ling M, Han X et al (2017) Self-standing electrodes with core-shell structures for high-performance supercapacitors. Energy Storage Mater 9:119–125. https://doi.org/10.1016/j.ensm.2017.07.005
Hong JY, Wie JJ, Xu Y, Park HS (2015) Chemical modification of graphene aerogels for electrochemical capacitor applications. Phys Chem Chem Phys 17:30946–30962. https://doi.org/10.1039/c5cp04203h
Hrubesh LW (1998) Aerogel applications. J Non-Cryst Solids 225:335–342
Jae Y, Chul J, Yi J et al (2010) Preparation of carbon aerogel in ambient conditions for electrical double-layer capacitor. Curr Appl Phys 10:682–686. https://doi.org/10.1016/j.cap.2009.08.017
Jia X, Dai B, Zhu Z, Wang J, Qiao W, Long D, Ling L (2016) Strong and machinable carbon aerogel monoliths with low thermal conductivity prepared via ambient pressure drying. Carbon N Y 108:551–560. https://doi.org/10.1016/j.carbon.2016.07.060
Jin E, Jae Y, Kwon J et al (2015) Oxygen group-containing activated carbon aerogel as an electrode material for supercapacitor. Mater Res Bull 70:209–214. https://doi.org/10.1016/j.materresbull.2015.04.044
Katti A, Shimpi N, Roy S, Lu H, Fabrizio EF, Dass A, Capadona LA, Leventis N (2006) Chemical, physical and mechanical characterization of isocyanate-crosslinked amine-modified silica aerogels. Chem Mater 18:285–296
Kim SJ, Hwang SW, Hyun SH (2005) Preparation of carbon aerogel electrodes for supercapacitor and their electrochemical. Mater Sci 40:725–731
Lee YJ, Jung JC, Yi J, Baeck SH, Yoon JR, Song IK (2010) Preparation of carbon aerogel in ambient conditions for electrical double-layer capacitor. Curr Appl Phys 10:682–686. https://doi.org/10.1016/j.cap.2009.08.017
Lee YJ, Park HW, Park S, Song IK (2012a) Electrochemical properties of Mn-doped activated carbon aerogel as electrode material for supercapacitor. Curr Appl Phys 12:233–237. https://doi.org/10.1016/j.cap.2011.06.010
Lee YJ, Park HW, Park S, Song IK (2012b) Nano-sized Mn-doped activated carbon aerogel as electrode material for electrochemical capacitor : effect of activation conditions. Nanosci Nanotechnol 12:6058–6064. https://doi.org/10.1166/jnn.2012.6283
Lee YJ, Park HW, Hong UG, Song IK (2013) Characterization and electrochemical performance of graphene-containing carbon aerogel for supercapacitor. J Nanosci Nanotechnol 13:7944–7949. https://doi.org/10.1166/jnn.2013.8105
Lee EJ, Lee YJ, Kim JK, Lee M, Yi J, Yoon JR, Song JC, Song IK (2015) Oxygen group-containing activated carbon aerogel as an electrode material for supercapacitor. Mater Res Bull 70:209–214. https://doi.org/10.1016/j.materresbull.2015.04.044
Leventis N, Sotiriou-Leventis C, Zhang G, Rawashdeh AMM (2002) Nanoengineering strong silica aerogels. Nano Lett 2:957–960
Li W, Zhang B, Lin R, Ho-Kimura SM, He G, Zhou X, Hu J, Parkin IP (2018) A dendritic nickel cobalt sulfide nanostructure for alkaline battery electrodes. Adv Funct Mater 1705937:1–10. https://doi.org/10.1002/adfm.201705937
Lim MB, Hu M, Manandhar S, Sakshaug A, Strong A, Riley L, Pauzauskie PJ (2015) Ultrafast sol-gel synthesis of graphene aerogel materials. Carbon N Y 95:616–624. https://doi.org/10.1016/j.carbon.2015.08.037
Lota G, Centeno TA, Frackowiak E, Stoeckli F (2008) Improvement of the structural and chemical properties of a commercial activated carbon for its application in electrochemical capacitors. Electrochim Acta 53:2210–2216. https://doi.org/10.1016/j.electacta.2007.09.028
Maleki H, Durães L, Portugal A (2014) An overview on silica aerogels synthesis and different mechanical reinforcing strategies. J Non-Cryst Solids 385:55–74. https://doi.org/10.1016/j.jnoncrysol.2013.10.017
Marx J, Brouschkin A, Roth S, Smazna D, Mishra YK, Wittich H, Schulte K, Adelung R, Fiedler B (2018) Fundamentals of the temperature-dependent electrical conductivity of a 3D carbon foam — aerographite. Synth Met 235:145–152. https://doi.org/10.1016/j.synthmet.2017.12.006
Michael AA, Nicholas L, Koebel MM (2011) Resorcinol-formaldehyde aerogels.
Mudasar F, Katsura Y, Kitahara K, Kimura K (2019) Enhanced thermoelectric figure of merit by composite effects and low thermal conductivity in distrontium silicide ( Sr 2 Si ). J Alloys Compd 782:1031–1040. https://doi.org/10.1016/j.jallcom.2018.12.037
Mulik S, Sotiriou-Leventis C, Leventis N (2006a) Acid-catalyzed time-efficient synthesis of resorcinol-aldehyde aerogels and crosslinking with isocyanates. Polym Prepr 47:364–365
Mulik S, Sotiriou-leventis L, Leventis N (2006b) Acid-catalyzed time-efficient synthesis of resorcinol-formaldehyde aerogels and crosslinking with isocyanates. Polym Prepr 47:364–365
Mulik S, Sotiriou-leventis C, Leventis N (2008) Macroporous electrically conducting carbon networks by pyrolysis of isocyanate-cross-linked resorcinol-formaldehyde aerogels. Chem Mater 20:6985–6997
Nystrom G, Marais A, Karabulut E et al (2015) Self-assembled three dimensional and compressible interdigitated thin-film supercapacitors and batteries. Nat Commun 6:7259. https://doi.org/10.1038/ncomms8259
Pavia DL, Lampman GM, Kriz GS, Vyvyan JA (2014) Introduction to spectroscopy, 5th edn. Cengage Learning
Qin CL, Lu X, Yin GP et al (2009) Activated nitrogen-enriched carbon/carbon aerogel nanocomposites for supercapacitor applications. Trans Nonferrous Met Soc China (English Ed) 19:s738–s742. https://doi.org/10.1016/S1003-6326(10)60142-2
Quan X, Fu Z, Yuan L, Zhong M, Mi R, Yang X, Yi Y, Wang C (2017) Capacitive deionization of NaCl solutions with ambient pressure dried carbon aerogel microsphere electrodes †. RSC Adv 7:35875–35882. https://doi.org/10.1039/C7RA05226J
Ramos-Fernández JM, Martínez-Escandell M, Rodríguez-Reinoso F (2008) Production of binderless activated carbon monoliths by KOH activation of carbon mesophase materials. Carbon N Y 46:384–386. https://doi.org/10.1016/j.carbon.2007.11.042
Ruiz V, Blanco C, Santamaría R, Ramos-Fernández JM, Martínez-Escandell M, Sepúlveda-Escribano A, Rodríguez-Reinoso F (2009) An activated carbon monolith as an electrode material for supercapacitors. Carbon N Y 47:195–200
Song Z, Duan H, Li L, Zhu D, Cao T, Lv Y, Xiong W, Wang Z, Liu M, Gan L (2019) High-energy flexible solid-state supercapacitors based on O, N, S-tridoped carbon electrodes and a 3.5 V gel-type electrolyte. Chem Eng J 372:1216–1225. https://doi.org/10.1016/j.cej.2019.05.019
Tsuchiya T, Mori T, Iwamura S, Ogino I, Mukai SR (2014) Binderfree synthesis of high-surface-area carbon electrodes via CO 2 activation of resorcinol – formaldehyde carbon xerogel disks : analysis of activation process. Carbon N Y 76:1–10. https://doi.org/10.1016/j.carbon.2014.04.074
Van Aken KL, Pérez CR, Oh Y et al (2015) High rate capacitive performance of single-walled carbon nanotube aerogels. Nano Energy 15:662–669. https://doi.org/10.1016/j.nanoen.2015.05.028
Wang H, Liu Y, Li M et al (2010) Multifunctional TiO2nanowires-modified nanoparticles bilayer film for 3D dye-sensitized solar cells. Optoelectron Adv Mater Rapid Commun 4:1166–1169. https://doi.org/10.1039/b000000x
Wang X, Liu L, Wang X, Bai L, Wu H, Zhang X, Yi L, Chen Q (2011) Preparation and performances of carbon aerogel microspheres for the application of supercapacitor. J Solid State Electrochem 15:643–648. https://doi.org/10.1007/s10008-010-1142-5
Wang G, Zhang L, Zhang J (2012) A review of electrode materials for electrochemical supercapacitors. Chem Soc Rev 41:797–828. https://doi.org/10.1039/c1cs15060j
Wang C, Chen H, Lu S (2014) Manganese oxide / graphene aerogel composites as an outstanding supercapacitor electrode material. Chem A Eur J. https://doi.org/10.1002/chem.201303483
Yang MH, Jeong JM, Huh YS, Choi BG (2015) High-performance supercapacitor based on three-dimensional MoS2/graphene aerogel composites. Compos Sci Technol 121:123–128. https://doi.org/10.1016/j.compscitech.2015.11.004
Yang I, Kim S-G, Kwon SH, Kim MS, Jung JC (2017) Relationships between pore size and charge transfer resistance of carbon aerogels for organic electric double-layer capacitor electrodes. Electrochim Acta 223:21–30
Yang I, Kwon D, Kim MS, Jung JC (2018) A comparative study of activated carbon aerogel and commercial activated carbons as electrode materials for organic electric double-layer capacitors. Carbon N Y 132:503–511. https://doi.org/10.1016/j.carbon.2018.02.076
Zhang G, Dass A, Rawashdeh AMM, Thomas J, Counsil JA, Sotiriou-Leventis C, Fabrizio EF, Ilhan F, Vassilaras P, Scheiman DA, McCorkle L, Palczer A, Johnston JC, Meador MA, Leventis N (2004) Isocyanate-crosslinked silica aerogel monoliths: preparation and characterization. J Non-Cryst Solids 350:152–164
Zhang Y, Wen G, Fan S, Ma W, Li S, Wu T, Yu Z, Zhao B (2019) Alcoholic hydroxyl functionalized partially reduced graphene oxides for symmetric supercapacitors with long-term cycle stability. Electrochim Acta 313:59–69. https://doi.org/10.1016/j.electacta.2019.05.021
Zhu C, Liu T, Qian F, Han TYJ, Duoss EB, Kuntz JD, Spadaccini CM, Worsley MA, Li Y (2016) Supercapacitors based on three-dimensional hierarchical graphene aerogels with periodic macropores. Nano Lett 16:3448–3456. https://doi.org/10.1021/acs.nanolett.5b04965
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Additional information
Publisher’s note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Aghabararpour, M., Motahari, S., Sanaee, Z. et al. Fabrication of binder-free electrode using reinforced resorcinol formaldehyde-based carbon aerogels. J Nanopart Res 21, 178 (2019). https://doi.org/10.1007/s11051-019-4624-0
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11051-019-4624-0