Abstract
A survey was carried out to detect the presence of aflatoxin B1 in 60 duplicated samples (120 samples) of peanuts butter purchased from the local markets and other traditionally prepared and distributed by the street sellers in Khartoum state, Sudan. AflaTest-P affinity column was used to extract the toxin from the samples, and the concentration was measured by calibrated Vicam fluorometer. Aflatoxin B1 was detected at variable levels in 100% of the screened samples. Traditionally prepared samples showed the highest incidence of aflatoxin B1 which is above the internationally regulated tolerance levels (5–20 ppb). The means and the ranges of the aflatoxin B1 recovered were as follows: 63.9 ppb (29–128 ppb), 54.5 ppb (21–131 ppb) and 101 ppb (17–170 ppb) for samples collected from Khartoum, Khartoum North and Omdurman areas, respectively. Samples from retail stores presented relatively low aflatoxin B1 incidences 14.5 ppb (1–57 ppb), but only 30% of the samples revealed aflatoxin level below 10 ppb. Laboratory segregated and carefully prepared butter from good grade nuts showed the lowest levels of this toxin (3.3 ppb; 2–6 ppb). The results showed that peanuts butter prepared by the street sellers and distributed by the retail stores are evidently hazardous to human health. There is therefore urgent need for strong form of quality control measures and public awareness. The use of excellent grade peanuts and care during processing and storage are priority.
Similar content being viewed by others
References
Payne GA. Process of contamination by aflatoxin-producing fungi and their impacts on crops. In: Sinha KK, Bhatnagar D, editors. Mycotoxins in agriculture and food safety, vol. 9. New York: Marcel Dekker; 1998. p. 279–306, 82.
Santacroce MP, Conversano MC, Casalino E, Lai O, Zizzadoro C, Centoducati G, Crescenzo G. Aflatoxins in aquatic species: metabolism, toxicity and perspectives. Rev Fish Biol Fish. 2008;18:99–130.
Pittet A. Natural occurrence of mycotoxins in foods and feeds: an updated review. Rev Med Vet. 1998;149:479–92.
Elshafie AE, Al-Rashdi TA, Al-Bahry SN, Bakheit C. Fungi and aflatoxins associated with spices in Sultanate of Oman. Mycopathologia. 2002;155:155–60.
Abudulkadar AHW, Al-Ali AA, Al-Kildi AM, Al-Jedah JH. Mycotoxins in food products available in Qatar. Food Control. 2004;15:543–8.
Huang B, Han Z, Cai Z, Wu Y, Ren Y. Simultaneous determination of aflatoxins B1, B2, G1, G2, M1 and M2 in peanuts and their derivative products by ultra-high performance liquid chromatography—tandem mass spectrometry. Anal Chim Acta. 2010;662:62–8.
Elzupir AO, Elhussein AM. Determination of aflatoxin M1 in dairy cattle milk in Khartoum State, Sudan. Food Control. 2010;21(6):945–6.
Fallah AA. Assessment of aflatoxin M1 contamination in pasteurized and UHT milk marketed in central part of Iran. Food Chem Toxicol. 2010;48(3):988–91.
World Health Organization (WHO). Mycotoxins in African foods: implications to food safety and health. World Health Organization Food Safety (FOS). AFRO Food Safety Newsletter 2006; issue number July.
Lezar S, Barros E. Oligonucleotide microarray for the identification of potential mycotoxigenic fungi. BMC Microbiol. 2010;10:87.
Bankloe S, Schollenbeger M, Drochner W. Mycotoxins contamination in food systems in sub-Saharan Africa. 28. Mykotoxin Workshop Hrsg Bydgosczz (polen). 2006;5:29–31.
Wagacha JM, Muthomi JW. Mycotoxins problem in Africa: current status, implications to food safety and health and possible management strategies. Int J Food Microbiol. 2008;124:1–12.
Goncalez EJ, Nogueira JHC, Fonseca H, Felicio JD, Pino FA, Correa B. Mycobiota and mycotoxins in Brazilian peanut kernels from sowing to harvest. Int J Food Microbiol. 2008;123:184–1990.
Bhat RV, Vasanthi S. Mycotoxins food safety risks in developing countries. Food safety in food security and food trade. Vision 2020 for Food, Agriculture and Environment, focus 10, brief 3 of 17, 2003;1–2.
EL-Nezami HS, Nicoletti G, Neal GE, Donohue DC, Ahokas JT. Aflatoxin M in human breast milk samples from Vicatoria, Australia and Thailand. Food Chem Toxicol. 1995;33(3):173–9.
Gulderen Y, Buket E, Gur OM, Bayhan OA. Determination of aflatoxins in peanut butter and sesame samples using high performance liquid chromatography method. Eur Food Res Technol. 2006;224(2):167–70.
Adebajo LO, Idowu AA, Adesanya OO. Mycoflora and mycotoxins production in Nigerian corn and corn-based snacks. Mycopathologia. 1994;126:183–92.
Kumajais S, Nakajima M, Tabata S, Ishikaro E, Tanaka T, Norizuki H, Hoh Y, Aoyama K, Fujita K, Kai S, Sato T, Saito S, Yoshiike N, Sugita-Konishi Y. Aflatoxin and ochratoxin A contamination of retail food and intake of these mycotoxins in Japan. Food Addit Contam. 2008;25(9):1101–6.
Chun HS, Kim HJ, Ok HE, Hwang JB, Chung DH. Determination of aflatoxin levels in nuts and their products consumed in South Korea. Food Chem. 2007;102(1):385–91.
Omer RE. Studies on the effect of field storage environment on aflatoxin contamination of the Rahad Agricultural Scheme. M.Sc Thesis, Khartoum University, Sudan, 1992.
Omer RE, Bakker MJ, Van’tveer P, Hooganboom RLAP, Polman THG, Alink GM, Idris MO, Kadaru AMY, Kok FJ. Aflatoxin and liver cancer in Sudan. Nutr Cancer. 2001;32:174–80.
Sanchis V, Sala N, Palmoes A, Santamarina P, Burdaspal PA. Occurrence of aflatoxin and aflatoxigenic molds in foods and feed in Spain. J Food Prot. 1986;49:445–8.
Elshafie AE, Abdelbasit KM, Abdalla MH. Aflatoxin production and morphological characters of Aspergillus flavus isolates from Sudan. Indian J Microb Ecol. 1991;2:79–85.
Connole MD, Blaney BJ, McEwan T. Mycotoxins in animal feeds and toxic fungi in Queensland 1971–1980. Aust Vet J. 1981;57:314–8.
Tabata S, Kamimura H, Ibe A, Hashimoto H, Iida M, Tamura Y, Nishima T. Aflatoxin contamination in foods and feed stuffs in Tokyo: 1986–1990. J AOAC Int. 1993;76:32–5.
Omer RE. Peanut buuter consumption and hepatocellular carcinona in Sudan. PhD Thesis, Wageningen University, Grafisch Bedrijf and Looijen B.V. Publisher, Wageningen, Netherlands, 2001.
Elshafie AE, Al-Shally NS. Mycoflora and mycotoxigenic moulds of pistachio nuts for human consumption in the Sultanate of Oman. Sci Technol. 1998;3:1–6.
Abdulmagid AM. Problems of aflatoxins in Sudanese food and feed stuffs. Joint UNESCO/Roastan/UNEP, Egypt, 1988; 12–25.
Candlish AAG, Haynes CA, Stimson WH. Detection and determination of aflatoxin using affinity chromatography. Int J Food Sci Technol. 1988;23:479–85.
Hanafi MO. Prevention and control of aflatoxin in Sudan. Joint FAO/WHO/UNICEF second international conference 1987;10 pp.
Jiménez M, Mateo R, Querol A, Huerta T, Hernández E. Mycotoxins and mycotoxigenic mould in nuts and sunflower seeds. Mycopathologia. 1991;115:121–7.
Doster MA, Michailides TJ. Aspergillus mold and aflatoxins in pistachio nuts in California. Phytopathology. 1994;84:583–90.
Lisker N, Michaeli R, Frank ZR. Mycotoxigenic potential of Aspergillus flavus strains isolated from peanuts growing in Israel. Mycopathologia. 1993;122:177–83.
Abdelhamid AM. Occurrence of some mycotoxins (aflatoxin, ochratoxin A, citrinin, zearalenoneand vomitoxin) in various Egyptian feeds. Arch Tierernahr. 1990;40:647–64.
Steiner WE, Brunschweiler K, Leimbacher E, Schneider R. Aflatoxins and fluorescence in Brazil nuts and pistachio nuts. J Agric Food Chem. 1992;40:2453–7.
Heperkan D, Aryan N, Ayfer M. Mycoflora and aflatoxin contamination in shelled pistachio nuts. J Sci Food Agric. 1994;66:273–8.
Dutta TK, Das P. Isolation of aflatoxigenic strains of Aspergillus flavus and detection of aflatoxin B1 from seeds in India. Mycopathologia. 2000;151:29–33.
Burdaspal PA, Gorostidi A, Tejedor MC. A survey of the occurrence of aflatoxins in edible nuts in Spain. Abstract, International symposium and workshop on food contamination: mycotoxins and phytotoxins, 14–15 Nov 1990, Cairo, Egypt.
Doster MA, Michailides TJ. Development of Aspergillus mold in liter from pistachio. Plant Dis. 1994;78:393–7.
Austwick PKC, Ayerst G. Toxic products in groundnuts mycoflora and toxicity. J Chem Ind. 1963;2:55–61.
Jackson CR. Growth of Aspergillus flavus and other fungi in windrowed peanuts in Georgia. Trop Sci. 1965;2:27–34.
Abeywickrama A, Bean GA. Toxigenic Aspergillus flavus and aflatoxins in Sri Lanka medicinal plant material. Mycopathologia. 1990;113:187–90.
Acknowledgments
This work was funded by Sudanese Standard and Metrology Organization. We thank staff of Faculty of Public and Environmental Health, Khartoum University, and Sudanese Standard and Metrology Organization for the use of these facilities.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Elshafie, S.Z.B., ElMubarak, A., El-Nagerabi, S.A.F. et al. Aflatoxin B1 Contamination of Traditionally Processed Peanuts Butter for Human Consumption in Sudan. Mycopathologia 171, 435–439 (2011). https://doi.org/10.1007/s11046-010-9378-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11046-010-9378-2