Mechanically synthesized hybrid powders of the AMg2/graphite + Al2O3 system and coatings deposited by cold gas dynamic spraying from these powders are studied. The effect of Al2O3 concentration in the powder on surface morphology, structure and microhardness of the coatings formed is determined.
Similar content being viewed by others
Notes
Here and subsequently through the test the content of elements and chemical compounds is given in weight fractions, expressed as a %.
References
A. P. Alkhimov, V. F. Kosarev and A. N. Papyrin, “Method cold gas-dynamic deposition,” Soviet Physics Doklady, 35(12), 1047–1049 (1990).
C. Suryanarayana, “Mechanical alloying and milling,” Progr. Mater. Sci., 46, 1 – 184 (2001).
C. Suryanarayana, “Nanocrystalline materials,” Int. Mater. Rev., 40, 41 – 64 (1995).
A. V. Aborkin, I. A. Evdokimov, V. E. Vaganov, et al., “Influence of mechanical activation mode on morphology and phase composition of Al – 2Mg – nC nanostructured composite material,” Nanotechnologies in Russia, 11(5 – 6), 297 – 304 (2016).
L. Ajdelsztajn, B. Jodoin, G. E. Kimand J. M. Schoenung, “Cold spray deposition of nanocrystalline aluminum alloys,” Metall. Mater. Trans. A, 36, 657 – 666 (2005).
P. Richer, B. Jodoin, L. Ajdelsztajn, and E. J. Lavernia, “Substrate roughness and thickness effects on cold spray nanocrystalline Al – Mg coating,” J. Thermal Spray Technol., 15(5 – 6), 246 – 254 (2006).
B. Jodoin, L. Ajdelsztajn, E. Sansoucy, et al., “Effect of particle size, morphology, and hardness on cold gas dynamic sprayed aluminum alloy coatings,” Surf. Coat. Technol., 201(6), 3422 – 3429 (2006).
E. Irissou, J.-G. Legoux, B. Arsenault, and C. Moreau, “Investigation of Al – Al2O3 cold spray coating formation and properties,” J. Thermal Spray Technol., 16(5 – 6), 661 – 668 (2007).
A. S. Oryshchenko and D. A. Gerashchenkov, “Aluminum matrix functional coatings with high microhardness on the basis of Al – Sn + Al2O3 composite powders fabricated by cold gas dynamic spraying,” Inorg. Mater.: Appl. Res., 7(6), 863 – 867 (2016).
V. E. Arkhipov, A. F. Londarskii, G. V. Moskvitin, and M. S. Pugachev, Gas Dynamic Spraying Coating Structure and Properties [in Russian], KRASAND, Moscow (2017).
A. V. Aborkin, M. I. Alymov, V. E. Arkhipov, and D. S. Khrenov, “Formation of heterogeneous powder coatings with two-level micro- and nano-composite structure under gas dynamic spraying conditions,” Dokl. Akad. Nauk, 478(6), 1 – 5 (2018).
A. V. Aborkin, M. I. Alymov, A. V. Kireev, et al., “Mechanically synthesized composite powder based on AMg2 alloy with graphite additives: Particle size distribution and structural phase composition,” Nanotechnologies in Russia, 12(7 – 8), 383 – 387 (2017).
D. A. Gerashchenkov, B. V. Farmakovskii, A. F. Vasil’ev, and A. Ch. Mashek, “Study of the flow temperature in cold gas dynamic spraying of functional coatings,” Vopr. Materialoved., No. 2(77), 87 – 96 (2014).
S. Yin, X. Wang W. Y. Li, and H. Jie, “Effect of substrate hardness on the deformation behavior of subsequently incident particles in cold spraying,” Appl. Surf. Sci., 257, 7560 – 7565 (2011).
O. Cetin, O. Tazegul, and E. S. Kayali, “Effect of parameters to the coating formation during cold spray process,” in: Proceedings of the 2nd World Congress on Mechanical, Chemical, and Material Engineering (MCM’16) (2016), pp. 1401 – 1407.
A. V. Aborkin, M. I. Alymov, A. V. Kireev, A. V. Sobol’kov, and V. E. Arkhipov, “Structure and efficiency of gas dynamic spraying of hybrid coatings based on a nano-crystalline aluminum matrix,” Metallurg, No. 8, 73 – 77 (2018).
Research was carried with partial financial support of the RFFI within the scope of scientific project 16-48-330156p a. In order to perform research equipment of the distribution center of the collective usage of ASMAN RAN was used.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Metallovedenie i Termicheskaya Obrabotka Metallov, No. 6, pp. 30 – 36, June, 2019.
Rights and permissions
About this article
Cite this article
Aborkin, A.V., Arkhipov, V.E., Sachkova, N.V. et al. Effect of Al2O3 on the Microhardness of AMg2/Graphite Nanocomposite Powder Gas Dynamic Coatings on Aluminum Alloys. Met Sci Heat Treat 61, 360–365 (2019). https://doi.org/10.1007/s11041-019-00430-1
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11041-019-00430-1