Abstract
The hydrophilic characteristics of zinc oxide combined with the electronic properties of this width band gap semi-conductor were used to produce transparent, anti fog and photocatalytic porous films by using a simple sol–gel dip-coating process. The observed values of contact angles (near to 10°) and calculated spreading coefficients (close to zero) indicate that sol–gel dip-coated ZnO porous films show excellent wettability. The photocatalytic behavior of these films measured from methylene blue degradation is dependent on the film thickness in agreement with wettability results; as the film thickness increases from 0.1 ± 0.05 to 0.5 ± 0.05 the photocatalytic reaction rate constant increases from 0.9 × 10−3 to 5.5 × 10−3 min−1.
Similar content being viewed by others
References
Karunakaran C, Rajeswari V, Gomathisankar P (2011) Mater Sci Semiconduct Process 14:133–138
Behnajady MA, Modirshala N, Hamzavi R (2006) J Hazard Mater B133:226–232
Chakrabarti S, Dutta BK (2004) J Hazard Mater B112:269–278
Otten A, Herminghaus S (2004) Langmuir 20:2405–2408
Gould P (2003) Mater Today November:44–48
Queré D (2002) Nature Material 1:14–15
Young T (1805) Philos Trans R Soc Lond 95:65–87
Li Y, Pham JQ, Johnston KP, Green PF (2007) Langmuir 23:9785–9793
Spanhel L, Anderson MA (1991) J Am Chem Soc 113:2826–2833
Tokumoto MS, Briois V, Santilli CV, Pulcinelli SH (2003) J Sol-Gel Sci Technol 26:547–551
Huang WX, Huang H, Li H, Zhou ZH, Chen H (2009) Mater Res Innovat 13:459–463
Spanhel LJ (2006) Sol-Gel Sci Technol 39:7–24
JCPDS (1996) PDF no 036-1451
Malagutti AR, Mourão HAJL, Garbin JR, Ribeiro C (2009) Appl Catal B90:205–212
Acknowledgments
This work has been financially supported by CAPES, CNPQ and FAPESP.
Author information
Authors and Affiliations
Corresponding author
Electronic supplementary material
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
da Silva, M.N., Santilli, C.V. & Pulcinelli, S.H. Wettability and photodegradation activity of sol–gel dip-coated zinc oxide films. J Sol-Gel Sci Technol 63, 230–234 (2012). https://doi.org/10.1007/s10971-012-2721-y
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10971-012-2721-y